Built-In Tank Enclosure Kit Owner's Manual Model No. 21287

ManualsBrandsSummit ManualsGrill21287

SUMMIT

BUILT-IN LP TANK ENCLOSURE KIT

42390 US 03/22/04

US English

# 42390

THIS GAS APPLIANCE IS DESIGNED FOR

OUTDOOR USE ONLY.

WARNING: Do not try to light this

appliance without reading the “Lighting”

Instructions section of this manual

 DANGER

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open ﬂ ames.

3. Open lid

4. If odor continues, keep away from the

appliance and immediately call your gas

supplier or your ﬁ re department.

Leaking gas may cause a ﬁ re or explosion

which can cause serious bodily injury or

death, or damage to property.

 WARNING

1. Do not store spare liquid propane

cylinder within 10 feet (3m) of this

appliance.

2. Do not store or use gasoline or other

ﬂ ammable liquids or vapors within 25

feet (8m) of this appliance.

 WARNING: Follow all leak-check

procedures carefully in this manual prior

to barbecue operation. Do this even if the

barbecue was dealer-assembled.

NOTICE TO INSTALLER: These instructions

must be left with the owner and the owner

should keep them for future use.

YOU MUST READ THIS OWNERS GUIDE

BEFORE OPERATING YOUR GAS GRILL

THESE ACCESSORIES MAY BE PURCHASED SEPARATELY.

Summit

Built-In LP Tank Enclosure Kit

(Model #: 21287)

Summary of content (12 pages)

PAGE 1
SUMMIT® # 42390 BUILT-IN LP TANK ENCLOSURE KIT Summit® Built-In LP Tank Enclosure Kit (Model #: 21287) THESE ACCESSORIES MAY BE PURCHASED SEPARATELY. YOU MUST READ THIS OWNERS GUIDE BEFORE OPERATING YOUR GAS GRILL DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flames. 3. Open lid 4. If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department.
PAGE 2
DANGERS & WARNINGS DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner's Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. WARNINGS Do not store a spare or disconnected liquid propane cylinder under or near the barbecue. Improper assembly may be dangerous. Please carefully follow the assembly instructions in this manual. Do not operate the Weber® gas barbecue if there is a gas leak present.
PAGE 3
WARRANTY OPERATING THEREFORE, YOU SHOULD RETAIN YOUR SALES SLIP OR INVOICE. This Limited Warranty shall be limited to the repair or replacement of parts that prove defective under normal use and service and which on examination shall indicate, to Weber’s satisfaction, they are defective. Before returning any parts, contact the Customer service representative in your region using the contact information sheet provided with your manual.
PAGE 4
ASSEMBLY of the floor. The ventilation openings should be of equal size and be spaced at a minimum of 90 degrees, and should be unobstructed. 3). The minimum size of the ventilation hole (s) should not be less than 1/4 inch. 4). The ventilation openings in the sidewalls should not allow venting into the empty or “hollow” area of the “island”.
PAGE 5
ASSEMBLY e). There should be a minimum of 2 inches (50.8mm) between the ground and the floor of the remote LP cylinder enclosure. f). The LP cylinder valve should be readily accessible for hand operation. A door on the remote LP cylinder enclosure to gain access to the LP cylinder valve is acceptable, provided it is non- locking and can be opened without the use of tools.
PAGE 6
ASSEMBLY PARTS LIST 1 Hose and regulator - 1 4 Tank stand - 1 8 4 Tank stand base - 1 2 Tank Scale - 1 2 1/4-20 nut - 6 Nylon washer - 12 4 1/4-20 x 1/2" bolt - 6 2 Cylinder glide - 2 2 1/2" Flare Gasket - 2 3/8" Flare Gasket - 2 6
PAGE 7
ASSEMBLY MOUNTING THE LP TANK BRACKET Mount the LP tank bracket to the right hand side of the enclosure opening using non corrosive hardware.. Mounting holes are provided on the sides and bottom of your LP tank bracket. Be sure to mount the bracket securley to the enclosure before use. MOUNTING HARDWARE NOT INCLUDED. 3 MOUNTING THE LP HOSE AND REGULATOR Securley mount the hose and regulator bracket to the top of the built-in tank enclosure using non corrosive hardware. MOUNTING HARDWARE NOT INCLUDED.
PAGE 8
GAS INSTRUCTIONS top of box 1) Connect the corrugated gas line to the manifold located on the right hand side of grill under the control panel. Use the 1/2" flared gasket(1) to ensure proper seal. Corrugated Gas Line to Manifold 90º fitting back of box Cap (Optional Side Burner) Connection to LP Tank Side View CONNECT GAS SUPPLY A 58" inch corrugated gas line is supplied with the grill. This line needs to pass through the gas inlet opening to the main gas supply.
PAGE 9
GAS INSTRUCTIONS Note: This connection tightens clockwise and will not allow gas to flow unless the connection is tight. The connection requires tightening by hand only. WARNING: Do not use a wrench to tighten the connection. Using a wrench could damage the regulator coupling and could cause a leak. 5) Mix soap and water. 6) Turn on the cylinder valve. CONNECTING THE LIQUID PROPANE CYLINDER WARNING: Make sure that the LP cylinder valve is closed. Close by turning valve clockwise.
PAGE 10
GAS INSTRUCTIONS Note - Since some leak test solutions, including soap and water, may be slightly corrosive, all connections should be rinsed with water after checking for leaks. Make sure side burner is OFF. To perform leak checks: open cylinder valve by turning the cylinder valve hand-wheel counterclockwise. WARNING: Do not ignite burners when leak checking. Check for leaks by wetting the connections with the soap and water solution and watching for bubbles.
PAGE 11
GAS INSTRUCTIONS REFILLING THE LIQUID PROPANE CYLINDER Safe handling tips for Liquid Propane Gas Cylinders We recommend that you refill the LP cylinder before it is completely empty. • Liquid Propane (LP) gas is a petroleum product as are gasoline and natural gas. LP gas is a gas at regular temperatures and pressures. Under moderate pressure, inside a cylinder, LP gas is a liquid. As the pressure is released, the liquid readily vaporizes and becomes gas. • LP gas has an odor similar to natural gas.
PAGE 12
GAS INSTRUCTIONS • Liquid Propane (LP) Cylinder(s) • The joint where the hose connects to the LP cylinder must be leak tested each time the LP cylinder is reconnected. For example, test each time the LP cylinder is refilled. • Be sure the regulator is mounted with the small vent hole pointed downward so that it will not collect water. This vent should be free of dirt, grease, bugs etc.