Use and Care Manual
3
• For your own safety, have worn or damaged parts
immediately replaced.
• Take care not to jam your ngers between moving blades
and stationary parts of the equipment while you are
adjusting the equipment.
• While you are carrying out maintenance work on the
blades, remember that the blades can still move even if
the power source has been switched o.
Battery + Charger Safety
Instructions
NOTE: This unit is a core tool. The battery and the charger
are not included. They must be purchased separately. The
iON16LM-CT is compatible with the following batteries
(models iBAT40 and iBAT40XR) and chargers (models
iCHRG40 and iCHRG40QC).
We pay a great deal of attention to the design of every battery
pack to ensure that we supply you with batteries that are safe,
durable, and have a high energy density. The battery cells have
a wide range of safety devices. Each individual cell is initially
formatted and its electrical characteristic curves are recorded.
These data are then used exclusively to be able to assemble
the best possible battery packs.
Despite all the safety precautions, caution must always be
exercised when handling batteries. The following points must
be obeyed at all times to ensure safe use. Safe use can only
be guaranteed if undamaged cells are used. Incorrect handling
of the battery pack can cause cell damage.
IMPORTANT! Analyses conrm that incorrect use and poor
care of high-performance batteries are the main factors
responsible for personal and/or product damage.
mWARNING! Use only approved replacement batteries;
other batteries may damage the lawn mower and cause it to
malfunction, which can lead to serious personal injury.
mCAUTION! To reduce the risk of injury, charge the
EcoSharp
®
iBAT40 battery pack or the EcoSharp
®
PRO
iBAT40XR battery pack only in their compatible chargers
(models iCHRG40 and iCHRG40QC). Other types of chargers
present risk of re, personal injury, and damage. Do not wire
a battery pack to a power supply plug or car cigarette lighter.
Such misuse will permanently disable or damage the battery
pack.
• Avoid dangerous environments – Do not charge the
battery pack in rain, snow, or in damp or wet locations.
Do not use the battery pack or charger in the presence of
explosive atmospheres (gaseous fumes, dust, or ammable
materials) because sparks may be generated when inserting
or removing the battery pack, which could lead to a re.
• Charge in a well-ventilated area – Do not block the
charger vents. Keep them clear to allow for proper
ventilation. Do not allow smoking or open ames near a
charging battery pack. Vented gases may explode.
NOTE: The safe temperature range for the battery is -4°F
(-20°C) to 113°F (45°C). Do not charge the battery outside
under extremely cold or extremely hot conditions; charge it
at room temperature.
• Maintain charger cord – When unplugging the charger, pull
the plug, not the cord, from the receptacle to reduce the
risk of damage to the electrical plug and cord. Never carry
the charger by its cord or yank it by the cord to disconnect
it from the receptacle. Keep the cord away from heat, oil,
and sharp edges. Make sure the cord will not be stepped
on, tripped over, or subjected to damage or stress when the
charger is in use. Do not use the charger with a damaged
cord or plug. Replace a damaged charger immediately.
• Do not use an extension cord unless it is absolutely
necessary – Using the wrong, damaged, or improperly
wired extension cord poses a risk of re and electric shock.
If an extension cord must be used, plug the charger into
a properly wired 16 gauge or larger extension cord with
blades that are the same number, size, and shape as the
blades on the charger. Make sure that the extension cord is
in good electrical condition.
• Charger iCHRG40 and iCHRG40QC are rated for 120 volt
AC only – The charger must be plugged into an appropriate
receptacle.
• Use only recommended attachments – Use of an
attachment not recommended or sold by the battery
charger or battery pack manufacturer may result in risk of
re, electric shock, or personal injury.
• Unplug charger when not in use – Make sure to remove
battery packs from unplugged chargers.
mWARNING! To reduce the risk of electric shock,
always unplug the charger before performing any cleaning or
maintenance. Do not allow water to ow into the AC/DC plug.
Use a Ground Fault Circuit Interrupter (GFCI) to reduce shock
hazards.
• Do not burn or incinerate battery packs – Battery packs
may explode, causing personal injury or damage. Toxic
fumes and materials are created when battery packs are
burned.
• Do not crush, drop, or damage battery packs – Do not
use the battery pack or charger if they have sustained a
sharp blow, been dropped, been run over, or have been
damaged in any way (e.g. pierced with a nail, hit with a
hammer, stepped on, etc.).
• Do not disassemble – Incorrect reassembly may pose
a serious risk of electric shock, re, or exposure to toxic
battery chemicals. If the battery or charger are damaged,
contact your authorized Snow Joe
®
+ Sun Joe
®
dealer or
call the Snow Joe
®
+ Sun Joe
®
customer service center at
1-866-SNOWJOE (1-866-766-9563).
• Battery chemicals cause serious burns – Never let a
damaged battery pack contact the skin, eyes, or mouth.
If a damaged battery pack leaks battery chemicals, use
rubber or neoprene gloves to safely dispose of it. If skin
is exposed to battery uids, wash the aected area with