DC-Powered Refrigerator & Freezer Models 165/225 Chest Cabinet User’s Guide SunDanzer 11135 Dyer Street Ste C El Paso, TX 79934 USA 1 Rev.
INTRODUCTION Congratulations! You have purchased one of the most efficient refrigeration products available on the market today. The SunDanzerTM chest freezers and chest refrigerators are designed to provide years of efficient trouble-free operation. The design is optimized for energy savings with an efficient DC compressor, thick insulation, and a chest style configuration.
INSTALLATION Unpacking and Cleaning Remove all packaging and securing tapes from the appliance. To avoid injury and damage to the appliance, be extremely cautious when using sharp or pointed tools to complete this task. You may want to leave the lid open allowing the compartment to ventilate for 20-30 minutes to get rid of residual odors. Check with your local Environmental Agency for recommendations on recycling packaging materials in your area.
Electronics Diagram (Direct Battery connection example) or 7.5A fuse Fuse A fuse is required in order to protect the wiring. A standard automobile fuse is recommended, and the fuse should be wired to the positive (“+”) side of the system close to the positive battery terminal. For 12V operation, use a 15A fuse, and for 24Voperation use a 7.5A fuse. Operating Voltage 12V 24V Fuse 15A 7.5A ATTENTION: A 6 ft. (2 m) power cord is supplied.
on the website. In general, the refrigerator models require 120-200 W-hr/day in a 32C ambient. Freezer models require 300-600 W-hr/day. OPERATION Starting the Appliance Once the wiring is complete and the refrigerator has 12 or 24VDC available, the unit will turn on automatically. The thermostat is also an on/off switch for the unit. When the dial is fully counter clockwise, the fridge will be off. The compressor is very quiet and it may be difficult to hear it running.
items for quicker cooling. Items in contact with the interior walls will cool faster and can freeze if the thermostat is set to a colder setting. Baskets Larger models include baskets. These baskets can be configured to hang from the top lip of the refrigerator or can stack in the bottom by adjusting the plastic tabs on the baskets. Door Lock Some units are fitted with a door lock. Keys for the lock will be located inside the fridge.
Internal Cleaning Wash the inside of the appliance with luke warm water and a mild soap. Never use abrasive or corrosive cleaning agents, steel wool, scouring sponges, chemical cleaning agents, or highly perfumed cleaning products to clean the interior as these will damage the surface and leave behind a strong odor. A sponge, towel, or soft brush is recommended. Washing with a mixture of two table spoons of baking soda to 1 quart (1.14L) warm water. After cleaning, thoroughly rinse and dry.
• • Appliance is running too cold. • • • • The lid will not open. • Light will not turn on • Water on interior floor Water on floor near fridge • • Condensate around the door seal. Excessive frost and ice has built up. • • • • • • • Noise Does the cabinet have adequate ventilation around the side walls allowing it to transfer heat properly? (See Installation Section). If the compressor is running and the unit does not cool, then it is most likely low on refrigerant.
END OF LIFE While this refrigerator should last many years, at some point it will be time to dispose of the unit. Be sure to use normal and proper disposal methods based on your local. When disposing of your appliance, use an authorized disposal site. The refrigerant must be completely drained and collected by an authorized technician for recycling prior to disposal. Check with your local Environmental Agency for recommendations on recycling this appliance in your area.
WARRANTY SUNDANZER WARRANTS, TO THE ORIGINAL OWNER, THAT THIS PRODUCT IS FREE FROM DEFECTS IN WORKMANSHIP AND MATERIAL FOR A PERIOD OF TWO YEAR FROM THE PURCHASE DATE. THIS WARRANTY SHALL BE LIMITED TO REPAIRING OR REPLACING, AT SUNDANZER’S OPTION AND WITHOUT CHARGE TO THE PURCHASER, DEFECTIVE COMPONENTS. ALL WARRANTY WORK SHALL BE PERFORMED AT A SUNDANZER APPROVED FACILITY. SHIPPING CHARGES RELATED TO RETURNING THE PRODUCT TO THE SUNDANZER FACILITY ARE NOT COVERED UNDER THIS WARRANTY.
Thank you for buying SunDanzer! 11 Rev.
