Product Manual A

1210, 1310 and 1410 1 rev. 09/28/10
MODELS 1210, 1310 and 1410
CAPACITY: 10 TON
JACK STAND (PAIRS)
Warning information
This is the safety alert symbol. It is used to alert you
to potential personal injury hazards. Obey all safety
messages that follow this symbol to avoid possible
injury or death.
IMPORTANT: READ THESE INSTRUCTIONS BEFORE OPERATING
BEFORE USING THESE STANDS, READ THIS MANUAL COMPLETELY AND THOROUGHLY, UNDERSTAND ITS OPERATING
PROCEDURES, SAFETY WARNINGS AND MAINTENANCE REQUIREMENTS.
It is the responsibility of the owner to make sure all personnel read this manual prior to using these stands. It is also the responsibility of
the stand owner to keep this manual intact and in a convenient location for all to see and read. If the manual or product labels are lost or
not legible, contact Sunex for replacements. If the operator is not fluent in English, the product and safety instructions shall be read to
and discussed with the operator in the operator's native language by the purchaser/owner or his designee, making sure that the operator
comprehends its contents.
THE NATURE OF HAZARDOUS SITUATIONS
The use of portable automotive lifting and support devices is subject to certain hazards that cannot be prevented by mechanical means,
but only by the exercise of intelligence, care, and common sense. It is therefore essential to have owners and personnel involved in the
use and operation of the equipment who are careful, competent, trained, and qualified in the safe operation of the equipment and its
proper use. Examples of hazards are dropping, tipping or slipping of loads caused primarily by improperly secured loads, overloading,
off-centered loads, use on other than hard level surfaces, and using equipment for a purpose for which it was not designed.
METHODS TO AVOID HAZARDOUS SITUATIONS
 • Read,study,understandandfollowallinstructionsbeforeusing.
 • Inspectthejackstandsbeforeeachuse.Donotuseifdamaged,altered,modied,inpoorcondition,orhavelooseormissing
hardware or parts. Make corrections before using the stands.
 • WeareyeprotectionthatmeetsANSIZ87.1andOSHAstandards.
 • Donotusebeyondratedcapacity.Donotshockload.
 • Useonlyonahardlevelsurfacecapableofsupportingtheload.
 • Standsaretobeusedinmatchedpairstosupportoneendofavehicleonly.Donotsimultaneouslysupportbothends
or one side of a vehicle.
 • Applytheemergencybrake,putthegearshiftleverinparkorgearifamanualshifttransmission,andchockthetiresthatwill
not be lifted off the ground.
 • Centerloadonsaddle.Donotusesaddlelugstosupporttheload.
 • Checkthestandsforsolidcontactwiththegroundandvehicle.Makesurethestands'lockingpinsarefullyengagingthestandon 
both sides and the support column's saddle is making contact with a vehicle support surface that can support the load. Consult the
vehicle manufacturer for the proper frame support locations.
 • Neverusethestand'slowersupportplate(ifsoequipped)asaloadbearingsurfaceforthelockingpin.
 • Failuretoheedthesewarningsmayresultinpersonalinjuryand/orpropertydamage.
CONSEQUENCES OF NOT AVOIDING HAZARDOUS SITUATIONS
Failure to read this manual completely and thoroughly, failure to understand its OPERATING INSTRUCTIONS, SAFETY WARNINGS,
MAINTENANCEINSTRUCTIONSandcomplywiththem,andfailuretocomplywiththeMETHODSTOAVOIDHAZARDOUSSITUATIONS
could cause accidents resulting in serious or fatal personal injury and/or property damage.
WARNING: Indicates a hazardous situation
which, if not avoided, could result in death
or serious injury.
WARNING
WARNING
WARNING
WARNING