Product Manual

6710 2 rev. 10/13/10
WARNINg INFORMATION
This is the safety alert symbol. It is used to alert you
to potential personal injury hazards. Obey all safety
messages that follow this symbol to avoid possible
injury or death.
IMPORTANT: READ THESE INSTRUCTIONS BEFORE OPERATING
BEFORE USING THIS DEVICE, READ THIS MANUAL COMPLETELY AND THOROUGHLY, UNDERSTAND ITS OPERATING
PROCEDURES, SAFETY WARNINGS AND MAINTENANCE REQUIREMENTS.
It is the responsibility of the owner to make sure all personnel read this manual prior to using the device. It is also the responsibility of
the device owner to keep this manual intact and in a convenient location for all to see and read. If the manual or product labels are lost
or not legible, contact Sunex for replacements. If the operator is not fluent in English, the product and safety instructions shall be read
to and discussed with the operator in the operator's native language by the purchaser/owner or his designee, making sure that the
operator comprehends its contents.
THE NATURE OF HAZARDOUS SITUATIONS
The use of portable lifting devices is subject to certain hazards that cannot be prevented by mechanical means, but only by the exer-
cise of intelligence, care, and common sense. It is therefore essential to have owners and personnel involved in the use and operation
of the equipment who are careful, competent, trained, and qualified in the safe operation of the equipment and its proper use. Ex-
amples of hazzards are dropping, tipping or slipping of loads caused primarily by improperly securing loads, overloading, off centered
loads, use on other than hard level surfaces, and using equipment for a purpose for which it was not designed.
METHODS TO AVOID HAZARDOUS SITUATIONS
• Read,study,understand,andfollowallinstructionsbeforeoperatingthisdevice.
• Inspectthejackbeforeeachuse.Donotusejackifdamaged,altered,modied,inpoorcondition,leakingair,orunstabledueto
loose or missing hardware or parts. Make repairs before using.
• Ajackbelievedtobesubjectedtoabnormalorshockloadshouldbeinspectedbyanauthorizedservicecenter.
• Itisthejackowner’sresponsibilitytomakesureonlytrainedpersonnelusethisdevice.
• Noalterationsormodicationsshallbemadetothisdevice.
• Noattachmentsand/oradaptersshallbeusedunlesssuppliedbySunexandintendedtobeusedonthisspecicdevice.
• Liftandsupportonlyareasofthevehicleasspeciedbythevehiclemanufacturer.
• WeareyeprotectionthatmeetsANSIZ87.1andOSHAstandards.
• Thisjackcanbeusedasajackstandaftertheloadisliftedbutshouldbeusedinamatchedpairtosupportoneendofavehicle
only. Jacks used as jack stands are not to be used to simultaneously support both ends or one side of a vehicle.
• Whenusingthisjackasajackstand,thesecondlargesupportpinprovidedshouldbeputthroughtheramtubeleavingenoughpin
 exposedoneithersideoftheramtubetorestontopofthejack’ssleevewhentheairisslowlyreleasedforlowering.Theairinthe
 jackshouldbecompletelyreleasedwhenthepinisrestingonthejack’ssleeve.
• Makesurethesetupisstablebeforeworkingonvehicle.
• Ifjacksareusedinpairs,liftingtheloadisnotsynchronizedandtheoperatorshouldbecarefultoliftonejackatatimein
reasonable short increments to prevent unstable conditions.
• Ifthejackisnotusedtosupporttheload,immediatelyplacetwojackstandsinthedesignatedlocationsrecommendedbythe
vehicle manufacturer. Jack stands are to be used in a matched pair to support one end of a vehicle only, not to support both ends or
one side of a vehicle.
• Neverusethesaddle'slocatinglugsonthejack’sorjackstandstoliftorsupporttheload.
• Donotusejackbeyondratedcapacity.Liftonlydeadweight.
• Donotexceed200P.S.I.inputairpressure.
• Centerloadonsaddle.
• Useonlyonhard,levelsurface.
• Alwayslowerthejackslowlyandcarefully.
• Failuretoheedthesewarningsmayresultinseriousorfatalpersonalinjuryand/orpropertydamage.
WARNING: Indicates a hazardous
situation which, could result in death
or serious injury.
WARNING
WARNING
WARNING