Installation Guide

ManualsBrandsSunjoy ManualsFire Pit Patio SetsLinfield Black 5-Piece Aluminum Patio Firepit Chat Set with Gray Back Pillows and Seat Cushions

Table Of Contents

Country of Origin: China Production Number: xxxxxxxxxx

This a

liance com

lies with “ANSI Z21.97-2017

CSA 2.41-2017

Outdoor Decorative Gas A

liances.

Propane cylinder required (not included)

1 AA 1.5V battery required (not included)

WARNING: For Outdoor Use Only.

Installation and service must be performed by a

qualified installer, service agency, or the gas

supplier.

DANGER

FIRE OR EXPLOSION HAZARD

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. If odor continues, leave the area immediately

4. After leaving the area, call your gas supplier or fire

department.

Failure to follow these instructions could result in

fire or explosion, which could cause property

damage, personal injury, or death.

INSTALLER: Leave this manual with the

appliance.

CONSUMER: Retain this manual for future

reference.

WARNING: If the information in this manual is not

followed exactly, a fire or explosion may result causing

ert

dama

ersonal in

or loss of life.

WARNING

Do not store or use gasoline, or other flammable vapors and liquids, in the vicinity of this or

any other appliance.

An LP-cylinder not connected for use shall not be stored in the vicinity of this or any other

liance.

DANGER CARBON MONOXIDE HAZARD

This appliance can produce carbon monoxide which has no odor.

Using it in an enclosed space can kill you.

Never use this appliance in an enclosed space such as a camper, tent,

car or home.

IMPORTANT, RETAIN FOR FUTURE REFERENCE: READ CAREFULLY

For Outdoor Use only. Not for Commercial Use.

ITEM No.: A208019800

Summary of content (30 pages)

PAGE 1
ITEM No.: A208019800 WARNING: For Outdoor Use Only. Installation and service must be performed by a qualified installer, service agency, or the gas supplier. INSTALLER: Leave this manual with the appliance. CONSUMER: Retain this manual for future reference. DANGER FIRE OR EXPLOSION HAZARD If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. If odor continues, leave the area immediately 4. After leaving the area, call your gas supplier or fire department.
PAGE 2
TABLE OF CONTENTS General information …………….…….………………….………………..………….…… 2 Specification……….……………………………………….……………….……….……… 3 Important safety information and precaution……………….….….….….…….…… 3-4 Expanded view……………………………………………………….……….……..……… 5 Parts list……………………….………………………….………………………………6-7 Installation………………………….………………………..………………….………8-15 Location……………………………………………………………………….…….…….. 16 Set up……………………………………………………………….…………….……...… 16 Gas connection ………………………………….……………….
PAGE 3
SPECIFICATION Product name HD PROVENCE 5PC GAS FIRE PIT TABLE Model NO. A208019800 Rated Heat Output 37,000BTU/HR Fuel Propane-LP Gas Supply 20 lb. LP-Gas cylinder Manifold Pressure 11 Inches W.C. Orifice Size (diameter) 1.9mm Gas Supply Pressure Max.250 PSI Min.25 PSI IMPROTANT SAFETY INFORMATION AND PRECAUTION  The installation must conform with local codes, or in the absences of local codes with the National Fuel Gas Code, ANSI Z223.
PAGE 4
 The pressure regulator and hose assembly provided with the appliance must be used. The replacement part must be the same as the part specified by manufacturer.  The assembly of LP-gas and leak checking please refer to the “Gas connection” on page 17 and “leak Test” on page 18.  Children and adults should be alerted to the hazards of high surface temperatures and should stay away to avoid burns or prevent clothing ignition.
PAGE 5
EXPANDED VIEW Country of Origin: China 5 of 19
PAGE 6
Parts List Label Part Number Description Qty A P003100088 Lid 1 B P002100348 Table top 1 C P002500120 Fire bowl 1 D P005400423 Leg1 1 E P005400424 Leg2 1 F P004000240 Back panel 1 G P003800413 Side panel1 1 H P006700057 Tank holder 1 I P006600020 Lava rock 4kg Country of Origin: China Part Image 6 of 19
PAGE 7
J P003800414 Side panel2 1 K P004100113 Panel 1 L P005400425 Leg1 1 M P005400426 Leg2 1 N P005100055 O 3 Chain 1 Lid handle 1 Hardware Pack Label Part Number Description Qty Add AA H010020011 Bolt M6*15 12 2 BB H010020014 Bolt M6*10 4 1 CC H010110016 Bolt M4*8 4 1 DD H010020023 Bolt M6*30 4 1 EE H050010028 Flat washer M6 20 3 FF H050010065 Flat washer M4 4 1 Part Image If you want to replace the parts listed, please contact Customer Servic
PAGE 8
INSTALLATION 1 4x 1x 1x 1x Country of Origin: China 8 of 19 4x
PAGE 9
2 4x 1x Country of Origin: China 1x 9 of 19 4x
PAGE 10
3 4x 1x 1x Country of Origin: China 10 of 19 4x
PAGE 11
4 4x 1x Country of Origin: China 11 of 19 4x
PAGE 12
5 4x 1x Country of Origin: China 12 of 19 4x
PAGE 13
6 4x 1x Country of Origin: China 13 of 19 4x
PAGE 14
7 1x Country of Origin: China 14 of 19
PAGE 15
8 1x Country of Origin: China 1x 1x 15 of 19
PAGE 16
LOCATION Your Gas appliance must be installed on a flat, stable surface, away from any combustible materials or construction. SET-UP Your Gas appliance comes assembled, ready for a Gas connection. 1- Remove the appliance from container box and place it on any level, outdoor, non-combustible surface. NOTE: Do not place this appliance on grass or dirt area. This may prevent proper safety venting. 2- Open the gas door and put the cylinder inside. 3- Unscrew the battery box as shown in Fig 1.
PAGE 17
Fig.7 Fig 7 Fig 8 OPERATION: LEAK TEST !!!WARNING!!!  Do not use an open flame to check for leaks.  Do not smoke during testing.  Do not test indoors.  A leak check must be performed whenever the gas cylinder is replaced. 1. Make sure the control knob is in the “OFF” position. 2. Make sure the gas cylinder is correctly and securely connected to the pressure regulator, without over tightening. 3. Turn on the gas cylinder valve.
PAGE 18
NOTE: While in use, the burner flame should be mainly blue in appearance with a small amount of yellow. The flame can be identified by the following figure. Warning: Lighting the Fire Pit improperly could lead to an unsafe condition. 7. Press in and turn the control valve knob clockwise to OFF to shut down fireplace. Close the gas cylinder valve when the fireplace is not in use. (CAUTION: Do not kink flexible gas hose. If it is kinked, a gas leak could occur.
PAGE 19
TROUBLE SHOOTING: PROBLEM OBSERVED Gas odor POSSIBLE CAUSE CORRECTIVE MEASURES Gas leak See “If you smell gas:” on front cover of manual Check all gas connections Delayed ignition Low gas pressure Check gas supply pressure Clogged or dirty burner Clean burner ports-see manual ports Blocked orifice section Spent battery Check orifice opening Change new battery Incorrect burner flame Incorrect gas supply or Check gas supply pressure pressure Blocked orifice Check and clean orifice opening Clogged or dirty
PAGE 20
ITEM No.: A211000700 WE HAVE YOU IN MIND, LET US SERVE YOU! Questions? Issues? CONTACT US 24 hours / 7 days a week www.sunjoyonline.com customer.care@sunjoygroup.
PAGE 21
2 / 11 Safety Information  One people are required for this assembly. WARING:  Some parts may contain sharp edges. Wear Keep all children and pets away from assembly area. protective gloves. Children and pets should be supervised when they are When assembling and using this product, in the area of the Chair construction.  basic safety precautions should always be followed to reduce the risk of personal injury and damage to equipment. Please read all instructions before assembly and usage.
PAGE 22
3 / 11 EXPLODED DRAWING Country of Origin: China
PAGE 23
4 / 11 Parts List Label Part Number Description Qty A P001500060 Back 4 B P001600193 Seat 4 C1 P001400236 Handrail（Right） 4 C2 P001400237 Handrail（Left） 4 D1 P005400415 Leg（left） 4 D2 P005400416 Leg（right） 4 D3 P005000427 Support Bar （Middle） 4 D4 P005000426 Support Bar （back） 4 E P001800127 Cushion 4 F P001700104 Back Cushion 4 Country of Origin: China Part Image
PAGE 24
5 / 11 Hardware Pack Label Part Number Description Qty Add AA H100010026 Bolt M6*20 56 1 BB H010010184 Bolt M8*40 16 1 CC T000001422 Big washer 16 1 DD R990020516 Nut M8 16 1 EE H050020016 Spring Washer M8 16 1 FF H050010017 Flat washer M8 16 1 GG H090030002 Allen Key Size 4 1 0 HH H090010003 Wrench M8 2 0 II H100010014 Bolt M8*20 16 1 Country of Origin: China Part Image
PAGE 25
6 / 11 1 4x 1x 1x Country of Origin: China
PAGE 26
7 / 11 2 6x 1x Country of Origin: China 1x
PAGE 27
8 / 11 3 4x 1x 1x Country of Origin: China 1x 1x 4x
PAGE 28
9 / 11 4 4x Country of Origin: China 4x 4x 4x 4x
PAGE 29
10 / 11 5 1x Country of Origin: China 1x
PAGE 30
11 / 11 Care and Maintenance Before using, clean the Chair completely with a soft dry towel. When not in use, wipe free of any dirt or loose objects, wash with a mild solution of soap and water; rinse thoroughly and dry completely. Do not use strong detergent or abrasive cleaners. Over time nuts and bolts can loosen. Occasionally, check nuts and bolts, re‐tighten if necessary.