Installation & Assembly

ManualsBrandsSunjoy ManualsOutdoor HeatingForge Dual Head LP 33,000 BTU Propane Patio Heater

February 16 Made in China 1 / 12

Owner’s Manual

Dual Head Standing Patio Heater

L-PH004PCA

WARNING: FOR YOUR SAFETY

State of California Proposition 65

Warning: Propane and byproducts of

combustion of propane contain chemicals

known to the State of California to cause

cancer, birth defects, or other reproductive

harm.

Propane cylinder required (not included)

1 AA 1.5V battery required (not included)

DANGER CARBON MONOXIDE HAZARD

This appliance can produce carbon monoxide which has no odor.

Using it in an enclosed space can kill you.

Never use this appliance in an enclosed space such as a camper,

tent, car or home.

WARNING: If the information in this manual is not

followed exactly, a fire or explosion may result causing

property damage, personal injury or loss of life.

DANGER

If you smell gas:

 Shut off gas to the appliance.

 Extinguish any open flame.

 If odor continues, keep away from the

Appliance and immediately call your gas

supplier or fire department.

WARNING: Improper installation,

adjustment, alteration, service or maintenance

can cause injury or property damage. Read the

installation, operating and maintenance

instructions thoroughly before installing or

servicing this equipment.

WARNING

Do not store or use gasoline or other flammable

vapors and liquids in the vicinity of this or any

other appliance.

An LP-cylinder not connected for use should

not be stored in the vicinity of this or any other

appliance.

WARNING: For Outdoor Use Only.

This appliance complies with “ANSI Z83.26-2014/CSA 2.37-2014, Gas Fired Outdoor Infrared Patio Heater.

Summary of content (12 pages)

PAGE 1
Owner’s Manual Dual Head Standing Patio Heater L-PH004PCA WARNING: FOR YOUR SAFETY WARNING: For Outdoor Use Only. State of California Proposition 65 Warning: Propane and byproducts of WARNING: If the information in this manual is not combustion of propane contain chemicals followed exactly, a fire or explosion may result causing known to the State of California to cause property damage, personal injury or loss of life. cancer, birth defects, or other reproductive harm.
PAGE 2
Table of Contents Specification …………………………………………………………………………………….. Introduction …………………………………………………………………………………... 1. Safety information …………………………………………………………………….. 2. Product diagram and package list………………………………………………….. 3. Assembly instruction and tools required…………………………………………. 4. Operation ……………………………………………………………………………….. 4.1 Leak check…………………………………………………………………………. 4.2 Ignition and setting control……………………………………………………… 4.3 Shut down……………………………………………………………………......... 5.
PAGE 3
INTRODUCTION Thank you for choosing Dual Head Standing Patio Heater as your form of outdoor heating. Please take time to read these instructions thoroughly and follow each step carefully for safe and easy operation. 1. SAFETY INFORMATION To ensure safe use of your patio heater, pay close attention to these essential safety requirements.  This appliance must only be used outdoors in a well ventilated area, and shall not to be used in a garage or any other enclosed space.
PAGE 4
      Installation and repair should be done by a qualified service person. The heater should be inspected before use and at least annually by a qualified service person. More frequent cleaning may be required as necessary. It is imperative that the control compartment, burners and circulating air passageways of the heater be kept clean. Tank supply system must be arranged for vapor withdrawal. The tank used must include a collar to protect the cylinder valve.
PAGE 5
2.
PAGE 6
3. ASSEMBLY INSTRUCTION 3.1 Tools required One Wrench (attached in Hardware Pack), one Philip Screw Driver and two Adjusting Wrenches. 3.2 Assembly Instructions (Please refer to the attached Diagrams) Step1. Install 4 Shanks Carefully install Shank (left) (chain & hinges attached), Shank (rear) and Shank (right) on base at correct position by using 4 bolts (LA), 4 washers (LG) and 4 lock washers (LM). Do not fasten screws tightly. Step2.
PAGE 7
Step5. Install Post Install Post on Table Top Base by using 6 bolts (LA), 6 nuts (LB) and 6 washers (LG). Step6. Install Table Top & Table Top Décor Carefully install Table Top on Table Top Base by using 6 screws (LC) and 6 washers (LH). Put down Table Top Decorative through Post on Table Top. Fig.7 Step7. Attach Dome Brim to burning system Attach Dome Brim to burning system by using 16 screws (LF) and 16 cap nuts (LI), cap nuts on the upper dome cover. Fig.
PAGE 8
4. OPERATION This dual head patio heater has two heat units which are convenient for warming oneself. The burners can be turned on individually or together. Left burner will operate by turning on left control knob, right burner will operate by turning right control knob. IMPORTANT: Use only standard 20 lb propane cylinder constructed and marked in accordance with the specifications for LP-gas cylinder of the U.S. Department of Transportation (D.O.T.). 4.
PAGE 9
4.1.3 Connections between gas line and gas valve. (1) Be sure the valve of gas cylinder is on. (2) Brush or spoon several drops of soapy solution around the connections through the leak check holes on pole. Inspect whether or not bubbles appear at these connections. (See Fig.15) (3) Unscrew and remove cover of control housing, brush or spoon several drops of soapy solution around the connections. Inspect whether or not bubbles appear at these connections. (See Fig.16) Fig.
PAGE 10
4.2.3 Turn on gas cylinder valve. 4.2.4 Depress and hold igniter button, press in and turn left (right) control knob counterclockwise to High to light the burner. If left (right) burner is lit, release igniter button, and continue to hold in control knob for 1 to 2 minutes to heat thermocouple. When control knob is released, burner should be lit. If not, press in and turn control valve knob clockwise to OFF. Wait a full 5 minutes, and then repeat above steps. 4.2.
PAGE 11
6. Maintenance To obtain the best performance from your heater, make sure you perform the following maintenance activities on a regular basis:  Keep exterior surfaces clean. Use warm soapy water for cleaning. Never use flammable or corrosive cleaning agents. Be sure to keep the area around the burner and control assembly dry at all times. Airflow must be unobstructed. Clear insect nests or webs away from your heater’s exterior and interior.  Carbon deposits may create a fire hazard.
PAGE 12
9. SERVICE For technical assistance on assembly or replacement parts, you can call us toll-free at 1-866-578-6569 from 8 a.m. EST to 8 p.m. PST or email to customer.care@sunjoygroup.com or visit www.sunjoyonline.com to place your order or fax your parts replacement order form together with your purchase receipt to 1-740-283-3549 for assistance. Warning: Use original equipment replacement parts only. Use of unauthorized parts or modification of parts will void the warranty and create an unsafe condition.