Use and Care Manual

ManualsBrandsSunstone ManualsBuilt-In GrillsRuby 5 Pro-Sear 42 in. Burner Built-In Gas Grill with Infrared and Rotisserie Rod - Propane Only

USE & CARE GUIDE –Service Access

Easy Service Access

Your grill is specially designed for easy Self-Service, similar to opening the hood of your car – the grill’s

control panel opens 90 degree’s open revealing all inside valves and wires.

1. Open Hood, and remove All Cooking Grates

so only the Flavorizer Grids remain.

2. Locate and Remove the Screws shown in

picture to right using the Allenn Wrench.

3. Pull Grill away from island 1 to 2 inches

4. Remove the Knobs, & Drip-Pan

(See Knob Removal on Next Page)

5. Lift Up on Control Panel, gripping the top

sides on panel, lift upwards so the notch

panel is fitted into is released.

6. Open Control Panel 90 degree, revealing all

inside components for easy access.

Summary of content (8 pages)

PAGE 1
USE & CARE GUIDE –Service Access Easy Service Access Your grill is specially designed for easy Self-Service, similar to opening the hood of your car – the grill’s control panel opens 90 degree’s open revealing all inside valves and wires. 1. 2. 3. 4. 5. 6. Open Hood, and remove All Cooking Grates so only the Flavorizer Grids remain. Locate and Remove the Screws shown in picture to right using the Allenn Wrench.
PAGE 2
USE & CARE GUIDE –Service Access Removing the BBQ Control Knobs Locate the Small Alan Wrench from inside your product manual package. This is used in order to remove each knob, by inserting and turning it into the small hole located on the underside of each knob. 1. 2. 3. 4. Rotate each BBQ Control Knob all the way so that the small hole is visible at the top. Locate the Small Allen Wrench from inside your product manual package.
PAGE 3
USE & CARE GUIDE –Check Parts Check Parts After removing a few components, like a Cooking Grate and Flavorizer Grid you will begin to see how the grill is configured with the various parts. 1. Inspect the Burners are all LEVEL and fixed properly in their place, if any burner has shifted – inspect that the valve is properly lined up with burner, if necessary remove the burner and re-insert into position, with back bolt inserting in through hole. 2.
PAGE 4
USE & CARE GUIDE –Leak Test WARNING: Always take a leak test before lighting the grill to prevent a possible fire or explosion. Never store a spare propane cylinder in the vicinity of this Grill, or in the vicinity of any other potential heat source. Never attempt to attach this grill to the self-contained LP gas system. Do not use grill until leak testing. Before Testing DO NOT smoke while leak testing. Extinguish all open flames.
PAGE 5
USE & CARE GUIDE –Leak Test Liquid Propane Leak Testing Procedure Test connection from LP Tank to Regulator Test connection from grill to LP Hose Natural Gas Leak Testing Procedure If unable to stop gas leak, turn gas off Test connection from gas line to adapter Test connection next to NG regulator Test Quick Disconnect Page 5
PAGE 6
USE & CARE GUIDE –Attention & Warnings WARNING: When Lighting the Grill. DO NOT RELEASE KNOB, GAS WILL CONTINUE TO FLOW. WARNING: Keep any electrical supply cords and the fuel supply hose away from any heated surfaces. WARNING: Failure to open the lid while igniting the barbecue’s burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame-up which can cause serious bodily injury or death. CAUTION: Inspect the hose before using the grill.
PAGE 7
USE & CARE GUIDE - Grill Safety CAUTION Do Not close grill hood for more than 3-5 minutes with burners set to HIGH temperature, or damage may occur to grill that is not covered under manufacture warranty. CAUTION When using your Sunstone™ Grill, always cook with hood up when knobs are on HIGH HEAT setting. NEVER close the hood and walk away. Always turn burners to LOW HEAT when hood is in down position Grill Operation. Do not use grill for other than intended use.
PAGE 8
USE & CARE GUIDE - Warranty SUNSTONE - RUBY SERIES GRILL WARRANTY WARRANTY ON PARTS_________________________________________________________________________  MAIN BURNERS ------------------------------------------ LIMITED LIFTIME, with THREE YEAR GUARANTEE  COOKING GRATES ----------------------------------------LIMITED LIFETIME  FLAVORIZER GRIDS ---------------------------------------LIMITED LIFETIME  FIREBOX & COMPONENTS ----------------------------- LIMITED LIFETIME  VALVES, KNOBS, LIGHTS & ALL OTHER