Corner Shower Seat dole C81616 QO Product Warnings O Safety Guidelines O Kit Contents O Required Tools O Preparation Tips O Installation Procedure O Cleaning & Maintenance O Surface Repair O Warranty Information Form # 194-09-14
The Swan stone Assurance — if our product is properly installed and maintained, as stated in these instructions, it will not leak. Remember Safety R First l IMPORTANT NOTICE I The Swan Corporation, the makers of the Swan stone Wall Systems and Panels, cannot anticipate every possible circumstance that might involve a potential hazard during the installation of our product(s). The warnings and instructions in this installation guide are, therefore, not all-inclusive.
Safety Guidelines IMPORTANT NOTICE IMPORTANT NOTICE: Indicates that equipment or property damage can result if instructions are not followed. Read and Understand the Manual llama \t is the responsibility of any individual who "/ Installs or maintains this product to fully understand and follow proper installation and maintenance procedures. Be aware of the inherent dangers in the use of power tools when installing this product, Read and understand all Wakings, Cautions, and important Notices in this manual.
Safety Guidelines General Information particles from going into the air. Always work in a well ventilated area. Always use an OSHA approved dust mask when cutting, diffing, or sanding Swan stone products. Power Tool Hazard To prevent personal injury or possible death, always follow the electrical safety recommendations of the power tool's manufacturer. Do not use power tools in an unsafe manner. Power tools should only be connected o a circuit protected by a ground-fault circuit interrupter (GF1). .
General Information installation Procedure Preparation Tips O The mounting surface most be free of dirt, firm, waxes, or sny other residues. Caulking Tips O Follow the instructions on the sealant tube. O When job is complete, inspect all caulked areas for gaps and fill as needed. © Clean up any excess alcohol and a clean cloth. O Be very careful not to disturb caulk joints.
Installation Procedure 2. Use to 3" long #12 drywall screws to attach the 2 x 6 supports to the stud wall, as shown. NOTE: After installing the 2 x & wall support, finish out the wall with drywall and a Swan stone wall panel system or a wall covering of your choice. Afire the wall covering has been installed, set, and allowed to cure, move on to Step 3. 3.
Installation Procedure 4. Drill six pilot holes at the marked locations, using the 3/16" drill bit. Drill through the wall panel and into the 2 x 6 inch support block installed earlier. 26 “ SUPPORT LACK f DRILL THE SIX PILOT HOLES YW USING & 3/167BT. oA | swan stone SHEET ) SWAN STONE SHEET 375" PILOT HOLE. DO NOT PENETRATE, 2X6 WALL SUPPOSITORY) 316" PLOT HOLE] = 3 8. Use the 3/8" drill bit to enlarge the 3/16” pilot holes through the Swan stone wall panel or other wall material.
installation Procedure b, [f the wall comer is not exactly 80 degrees 9. Set the shower seat into place. square, it will be necessary to sand the sides of the seat in order to achieve a proper fit. Use a coarse grit (80 grit) sandpaper when sanding the seat. a. Make sure the locking labs molded into the underside of the seat engage behind the stainless steel support bracket. b. Apply a continuous bead of silicone around the TmfilnggIfig;figOU outer perimeter of the shower seat lo completely seal the joint. ¢.
Maintenance and Surface Repair Care and Cleaning The Swan stone products are stain and abrasion resistant; however, the finish requires reasonable care. IMPORTANT NOTICE Because cleaning products change over time, always check the manufacturer's instructions to make sure it is compatible with solid surface acrylic. DO NOT use a cleaner if the label indicates it should nat be used on solid surface acrylics.
Warranty LIMITED WARRANTY FOR RESIDENTIAL APPLICATIONS If a Swan stone product covered by this warranty is found to be defective in materials or workmanship, after inspection by an authorized Swan Corporation representative, we will repair, or at our option, exchange the product for a similar model. This warranty extends for a designated period of time, so long as it remains in use in its original place of installation.
Save these Installation Instructions for future reference. They provide important information on cleaning, maintenance, and surface repair of Swan stone products. &V Swan www.swanstone.
