swisherinc.com OWNER’S MANUAL MODEL NO. LS722 STARTING SERIAL #: L206-010001 LS10528 STARTING SERIAL #: L206-010001 LS728 STARTING SERIAL #: L206-010001 IMPORTANT Read and follow all Safety Precautions and Instructions before operating this equipment. Rev.
LIMITED WARRANTY The manufacturer’s warranty to the original consumer purchaser is: This product is free from defects in materials and workmanship for a period of two (2) year from the date of purchase by the original consumer purchaser. We will repair or replace, at our discretion, parts found to be defective due to materials or workmanship.
SAFETY PRECAUTIONS This Safety Alert Symbol indicates important messages in this manual. When you see this symbol, carefully read the message that follows and be alert to the possibility of personal injury. Read this manual completely. This machine can amputate hands, feet, and throw objects. Failure to observe the following safety instructions could result in serious injury or death.
Fluid escaping from a very small hole can be almost invisible. Do not check for leaks with your hand. Escaping fluid under pressure can have sufficient force to penetrate skin, causing serious personal injury. Leaks can be located by passing a piece of cardboard or wood over the suspected leak and looking for discoloration. IF injured by escaping fluid, see a doctor at once. Serious infection or reaction can develop if proper medical treatment is not administered immediately.
TOWING SAFETY • Do not allow persons to ride on splitter. Do not carry any cargo or wood on your splitter. It may fall off and endanger vehicles that are following you. • Be sure support leg is in the travel position and coupling secure. This must also be retracted so not to interfere while towing. Retract support leg by removing pin, sliding up, and replacing pin. • Never exceed 45 MPH while towing your splitter. Be extra cautious when traveling over rough terrain, especially over railroad tracks.
OPERATION Intended use: This log splitter is intended and designed to only split wood. NEVER use for any other purposes. Doing so can cause injury or VOID THE WARRANTY. ASSEMBLY INSTRUCTIONS This log splitter has been partially assembled at the factory. Refer to the drawings and part lists should it become necessary to disassemble the unit for repair or replacement of parts. Inspect all components for damage. WARNING: Exercise extreme caution, as parts are very heavy.
OPERATION TOWING This unit should not be towed on any street, highway, or public road without checking the existing federal, local, and state laws. Any licensing or modifications such as taillights, etc., need to comply with existing federal, local, or state vehicle requirements is the sole responsibility of the purchaser. Obey all regulations when towing on public roads and highways. See also TOWING SAFETY.
MAINTENANCE & STORAGE WARNING: Disconnect spark plug before performing any maintenance or making adjustments. RESERVOIR FLUID Check the hydraulic fluid level in the reservoir tank before each use. Operating without an adequate oil supply will cause severe damage to the pump. Change the hydraulic fluid in the reservoir per manufacturers recommendations. Be aware of the environment when disposing of used petroleum products.
SAFETY DECALS Replace decals immediately if damaged.
ASSEMBLY DETAIL LS722, LS10528, LS728 MODELS 10
SERVICE PARTS Please have Model and Serial Numbers ready when ordering parts. Color cannot be guaranteed upon service parts.
BEAM DETAIL ALL MODELS NOT ALL PARTS ARE ON ALL MODELS ITEM NUMBER 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 DESCRIPTION Beam W eldment W edge W eldment W edge GIB Angle Bolt 3/8-16 X 1 1/4 Carriage Nut 3/8-16 Nyloc Nut 1/2-13 Nyloc Jam 1/2-13 X 3 1/2 GR5 ZP Ram Cylinder - LS722 Model Ram Cylinder - LS10528 and LS728 Model 2-W ay Pipe Nipple Steel Pin Clip Pin Hydraulic Fitting Stationary Line Assembly Return Line Fitting Valve Control Valve Inlet Fitting Valve Control Handle Handle Grip Mas
1 2 ENGINE DETAIL LS10528 MODELS ITEM # 1 2 3 4 5 6 7 8 9 10 NOTSHOWN NOTSHOWN DESCRIPTION Engine Bolt 5/16-18 X 1 1/4 Serr. Flange Nut 5/16-18 Serr.
NOTES: ______________________________________________________________________ ______________________________________________________________________ ______________________________________________________________________ ______________________________________________________________________ ______________________________________________________________________ ______________________________________________________________________ ______________________________________________________________________ ________
SPECIFICATIONS LS722 Models LS10528 LS728 Splitting Force 22 Tons 28 Tons 28 Tons Engine 7 Hp Briggs and Stratton Intek OHV 10.
LOG SPLITTER OWNER’S MANUAL MODEL NO. LS722 LS10528 LS728 HOW TO ORDER REPAIR PARTS: Each Log Splitter has its own serial number. Each engine has its own serial number. The serial number for the Log Splitter will be found on the right hand side of the hydraulic oil reservoir. The serial number for the engine will be found on the top of the blower fan housing. All Log Splitter parts listed herein may be ordered directly from Swisher Mower & Machine Co. Inc.