USER MANUAL DV WITH CONTROLLER VERSION 1.01.13 90925372

ManualsBrandsSystemair ManualsAir Handling UnitsDanvent DV - Madam item for DV and Time



26



i.1.7Roofunitwithsteelroof

Forunitswithsteelplateroof,thesteelplatesaredelivereduninstalledonaseparatepallet.Donotstepor

walkontheplates.



.



i.1.8Pre‐assemblystorage



TheAHUmustbeprotectedfromtheweatherandaccidentalimpact.Plasticpackagingmustberemoved

andtheunitcoveredwithtarpaulinorsimilarmaterials.Inordertominimizecondensation,sufficientair

circulationmustbeensuredbetweenthecoveringandtheunit.



i.1.9Tiltlessthan30˚duringtransportati onof

thesectionwithheatpump–DVU

Duringtransportation,theunitsection‐DVU‐mustalwaysbeintheuprightpositionortiltedlessthan30˚.

Ifitisnecessarytotilttheunitmorethan30˚,thesuctionpipeofthecompressormustpointupwardsto

preventtheescape ofoilfromthecompressorsump. 

i.2.Installation‐mechanical

i.2.1Freeareainfrontofandabovetheunit

Important!Whenpositioningtheunitonthesite,itmustbeensuredthatanareawiththesamewidthas

theunitiskeptfreeforserviceandinspectionandalsoforreplacementoffansandexchanger,ifneeded.

Thewidthofthefreeareamustbeatleast900mm.



Important!Forsafeaccesstothecabinetwithelectricalcomponents,ifthecabinetisplacedontopofthe

unit,thefreeareafromtheupperedgeofthecabinettotheceilingmustbeatleast700mm.

i.2.2Supportingsurface

Thesurfacebeneaththeunitmustbelevel,

horizontalandvibration‐free.Thesurfacemustbeableto

withstandtheloadoftheAHU.WeightsofthesectionsarewritteninAnnex2.

Remember!Ductworkmustbesoundinsulatedandmustnotbemounteddirectlyonbeams,trussesor

othercriticalbuildingparts.

i.2.3Adjustablefeetunderlegs

orbaseframeandtransportofsections

Adjustablefeetareprovidedinacartonboxplacedinsidetheunit.Adjustablefeetaredeliveredforindoor

unitsandnotforoutdoorunits.

Sectionscanbetransportedonthesitebyhandmanualforkliftsorsimilar.Theframeprofilesinthe

edges

ofthesectionshavecarryingcapacityforliftingbythehandmanualforklifts.



 

