USER MANUAL DV WITH CONTROLLER VERSION 1.01.13 90925372


65

s.Instructionsdesignedtoenableadjustmentandmaintenancetobe
carriedoutsafely,includingtheprotectivemeasuresthatshouldbetaken
duringtheseoperations
s.1.Protectivemeasuresandadditionalprotectivemeasures
Adjustmentandmaintenancemustbedonebyskilledtechnicians–usuallybasedonservicecontractsfor
someyearsorlong‐termESCOcontracts.
Theunitsareprovidedwithguardstoavoidunintendedhazardsandinjurybecauseofrotatingpartsinthe
unit.Thepotentialsourcesofharmarethefanswith
fastrotatingimpellers.Hazardsfromtheimpellers
areobviousduringoperation,butwhenpoweriscut‐off,theimpellersarestillpotentialhazardsdueto
after‐runforatleast20seconds.Noticethatevencut‐offtheimpellersarestillpotentialhazards.
Thefanguard’saretheinspectiondoors
andthedoorsareprovidedwithlocks.Insidethedoorsare
additionalprotectioninstalled–guardsthatonlycanberemovedbyuseoftools.
Othermotor‐drivenpartsaredamperswithdampermotorsandrotaryheatexchangers,butthemovement
issoslowthatguardmeasuresarenotnecessary.Just
keepyourhandsawayfromplaceswithriskofinjury.
Useparticulaterespiratorwhenfiltersarereplaced.
s.1.1Necessaryprotectionmeasurespriortostart‐up. 
Ensurethatallprotectionmeasuresareinstalledcorrectbeforestart‐up.
s.1.1.1Designofprotectionmeasures
Insidethedoorsareadditionalprotectioninstalled–guards
thatonlycanberemovedbyuseoftools.
s.1.1.2Configurationoffrequencyconverterswithinstalledguard
Afrequencyconverterismountedbesidethefaninsomeunits.Iftheconfigurationoffrequencyiscarried
outwiththefaninoperation,theguardmustbeinstalledforsafetyreasonsanda
longcablemustbe
installedbetweenthefrequencyconverterinsidetheunitandthecontrolpaneloutsidetheunit.
s.1.2Safeadjustmentandmaintenance
Beforemaintenanceandrepair,theunitmustbeswitchedoffbyswitchingofftheautomaticcircuit
breakersandblockthembypadlocks.Notethatlampsmust
beswitchedonduringmaintenance(lamps
areanaccessory–onlyinstalled,ifordered).
Usecut‐resistantglovesforprotectionagainstinjuryfromsharpmetalplateedges.UseCE‐markedgl oves
forthispurpose.Usehelmetduringmaintenanceworkintheunit.




