Installation

ManualsBrandsT and S Brass ManualsShop AllT and S Brass 48" Water Hose with 3/8" NPT Male Outlet, Quick Disconnect, and Vacuum Breaker

Installation and

Maintenance

Instructions

Water and Steam

Appliance Connectors

Deutsch: Installations- und

Wartungsanleitungen

Español: la Instalación y las

Instrucciones de

Mantenimiento

Français: les Instructions

d’Installation et

d’Entretien

Limited Five (5) Year Warranty

T&S warrants to the original purchaser (other

than for purposes of resale) that such product is free

from defects in material and workmanship for a

period of five (5) years from the date of purchase.

During this one-year warranty period, if the product

is found to be defective, T&S shall, at its options,

repair and/or replace it. To obtain warranty service,

products must be returned to...

T&S Brass and Bronze Works, Inc.

Attn: Warranty Repair Department

2 Saddleback Cove

Travelers Rest, SC 29690

Shipping, freight, insurance, and other transpor-

tation charges of the product to T&S and the return

of repaired or replaced product to the purchaser are

the responsibility of the purchaser. Repair and/or

replacement shall be made within a reasonable time

after receipt by T&S of the returned product. This

warranty does not cover Items which have received

secondary finishing or have been altered or modi-

fied after purchase, or for defects caused by physi-

cal abuse to or misuse of the product, or shipment

of the products.

Any express warranty not provided herein, and

any remedy for Breach of Contract which might arise,

is hereby excluded and disclaimed. Any implied

warranties of merchantability or fitness for a particu-

lar purpose are limited to one year in duration. Under

no circumstances shall T&S be liable for loss of

use or any special consequential costs, expenses

or damages.

Some states do not allow limitations on how long

and implied warranty lasts or the exclusion or limi-

tation of incidental or consequential damages, so

the above limitations or exclusions may not apply

to you. Specific rights under this warranty and other

rights vary from state to state.

P/N: 098-010964-45 Rev.1

Date: 981203

Drawn: CW

Checked: MAB 4/5/99

Approved: MW 4/6/99

Summary of content (12 pages)

PAGE 1
Installation and Maintenance Instructions Limited Five (5) Year Warranty T&S warrants to the original purchaser (other than for purposes of resale) that such product is free from defects in material and workmanship for a period of five (5) years from the date of purchase. During this one-year warranty period, if the product is found to be defective, T&S shall, at its options, repair and/or replace it. To obtain warranty service, products must be returned to... T&S Brass and Bronze Works, Inc.
PAGE 2
Exploded View 1 2 3 4 5 6 Some items are listed for instructional purposes and may not be sold as seperate parts.
PAGE 3
Part Number Guide Safe-T-Link Fittings and Accessories 1 Asm, Hose Coated - Water Asm, Hose Coated - Steam 90º Street Elbow, Male/Female 90º Elbow, Female/Female Shut-Off Valve Asm, Quick Disconnect - Water Asm, Quick Disconnect - Steam Asm, Kit - Restraining Cable 2 3 4 5 6 HW HS * * * AW AS ** * These accessories must be supplied by installer, if necessary.
PAGE 4
General Instructions Important Safety Instructions: 7. Final assembly must be tested for leaks. WARNING: Please read all instructions carefully. Failure to fully read instructions and follow them could result in severe injury or death. Instructions: Safe-T-Link Water and Steam Connectors General 1. Carefully read these entire Installation Instructions prior to start of work. 1.
PAGE 5
General Instructions 2. If supply side Tee is female, apply Teflon Tape or sealant to threads of a pipe Nipple (not supplied), and thread Nipple into female pipe Tee. Then, thread onto exposed thread of Nipple, no.4, and tighten. 3. Apply thread Teflon Tape or sealant to male thread of no.1 Connector. Thread male no.1 Connector into no.4 and tighten. WARNING: No.5 must be oriented so fluid enters Coupling half and exits Nipple half. Follow flow direction arrows marked below and no.5 itself.
PAGE 6
Instrucciones Generales Instrucciones Importantes De Seguridad: reparos, mantenimiento o limpieza. 7. El ensamble final debe de ser ensayado por filtraciones. AVISO: Por favor lea todas las instrucciones cuidadosamente. El no leer y seguir las instrucciones completas puede resultar en grandes lesiones o muerte. Instrucciones: Safe-T-Link Conectores De Agua Y Vapor General 1. Lea todas las instrucciones cuidadosamente, antes de comenzar este trabajo. 1.
PAGE 7
Instrucciones Generales 2. Si las roscas de la unión en “t” en el extremo del surtidor son femeninas, aplique cinta de Teflon o sellador a las roscas del tubo (no esta surtido), y enrosque el tubo dentro de la unión femenina en T. Luego, enrosque en la rosca exhibida del tubo, la parte No.4 y apriete. No.2 (Masculino/Femenino) en el instrumento y apriete. 4. Conecte de nuevo las dos mitades. AVISO: La parte No.
PAGE 8
Instructions Générales • Éviter les mouvements sur les appareils mobiles(ceux qui avoir les roulettes appliqué à l’usine) sauf que pour les réparations, l’entretien ou le nettoyage. Les Instructions De La Sécurité Importantes: Avertissement: Prier lire tous les instructions prudemment. Si vous ne les lire pas et si vous ne les suivre pas complètement vous pouvoir devenir blessé ou vous pouvoir mourir. 7. Vous devoir vérifier l’assemblage pour les fuites.
PAGE 9
Instructions Générales 2. Si le côté d’alimentation être feminin, appliquer le ruban en Téflon ou l’enduit étanche aux filets du raccord du tuyau(pas fournir) et mettre le raccord à travers le “T” feminin. Puis mettre aux filets exsposés du raccord, Nº.4, et resserrer. Avertissement: Nº.5 devoir s’orienter pour permettre l’entrée du fluide à la moitié d’attelage et sortir la moitié du raccord. Suivre les flèches de la direction de la circulation indiqué au-dessous et sur soi-même. 3.
PAGE 10
Allgemeine Anleitungen • Bewegung nach der Installation auf feststehenden Geräten (solche mit von dem Hersteller installierten Rollen) ausgenommen bei Reparaturen, Wartung oder Reinigung Wichtige Sicherheitsanweisungen: WARNUNG: Bitte alle Anweisungen sorgfältig durchlesen. Das Unterlassen, die Anweisungen vollständig durchzulesen und sie zu befolgen, kann zu schweren Verletzungen oder zum Tod führen. 7. Zusammengesetzte Garnitur muß auf Dichtigkeit geprüft werden.
PAGE 11
Allgemeine Anleitungen 2. Falls das T-Stück der Zuleitung Seite ein Innengewinde hat, Teflonband oder Dichtungsmittel auf das Gewinde eines Rohrstopfens (wird nicht mitgeliefert) der Zufuhrseite auftragen und Stopfen durch das Innengewinde des T-Rohrs führen. Dann durch das freiliegende Gewinde des Stopfens Nr. 4 führen und festziehen. 3. Stopfenhälfte von Nr. 5 in Nr. 2 (Außen-/Innengewinde) des Geräts einschrauben und festziehen. 4. Die Nr. 5 Hälften wieder verbinden. WARNUNG: Nr.
PAGE 12
RELATED T&S BRASS PRODUCT LINE G-6 Sure-Link Restraining Cable T&S BRASS AND BRONZE WORKS, INC. A firm commitment to application-engineered plumbing products 2 Saddleback Cove, P.O. Box 1088, Travelers Rest, SC 29690 Phone: (864) 834-4102 Fax: (864) 834-3518 E-mail: tsbrass@tsbrass.