A SAFETY FIRST Instructions: contained in: warnings: within: this manual sod warning seals marked with a Ak symbol on the blower Cohen critical points which most be taken ino consecrations to prevent pushbike serious bodily injury. and for (hig reason vou dre requested to read alt such instructions Carefully and follow then without fail: Note that there may be mes when warning seals peal off or become soiled and impossible 10 read.
1. Parts location 1 Frame 2. Shoulder Strap A. Spark Plug Cap 4; Throttle Lever 5. Stop Switch (behind) 6. Net 7..Choke Lever B Air Cleaner 9. Solute Case 10. CAUTION” Label 11: Elbow 12, Fuel Tank 13. Re coll Starter 14; Ignition Switch 15: Engine Cover: 16. Carrying handle 2. Specifications WM: MODEL TBL7800/7800R Dissension {in} TBL7800 = BOOTBLACK ny Weight ky (ibs) B71XABTNAE (14.6310, 1x10.4) 37 {x464x495 (14 6x18.5x10.4) 10.5 (28.2) Fuel Tank Capacity tier (li.
3. Warning fables on the machine {1} Head owner's manual before operating this machine: (2) Wear head, eye and: ear protection. {3} Handling this machine improperly: could result in accidents causing serious injury or death.
[2 Ak 5. For sate operation WARNING Read this Blower Owner/Operator Manual 1 carefully. Be sure you understand how to Li operate this unit properly before you use it ! Failure 1o.do so could result in serious injury. 1:2. Be sure fo keep this manual handy so that vou | may refer to i Eater whenever any questions [i arise. Also note that you are requested to i contact the dealer from whom you purchased i the product for assistance the event that you 1. have any guest ions ‘which cannot ‘be 1 answered herein.
AA 5. For safe operation vibration are mentioned 4s: furors, in order 10 reduce the isk: of whitening disease the Hollowing precautions are strongly recommended; A) Keen your body warm, Never use: blower dining rains: 1B) Saar thick anti vibration gloves: ©) Take more than § minutes of break inv warm place frequently.
A 5. For safe operation 4; Check your: equipment before operation, especially the muffler, alr intakes and air fighters. WM WORKING PLAN «When planing your work schedule, allow. plenty of time 10 rest. Limit the amount of time over which the product is. 10: be used continuously to somewhere: around: 30. 40 minutes per session.
A 5. For safe operation A WARNING Check to sea if the shuck-absorbing rubber mount has become cracked or otherwise damaged, Note that failing to replace: this rubber mount when it has became cracked or damaged may cause the engine to come loose from its frame during use; thus resulting in possible serious bodily injury. Cracked; be sure to replace without delay, AA WARNING Reducer the risk of injury associated with contacting rotating pars, stop tha engine before installing br removing attachments.
16 A 5. For safe operation use mister attachment when water is available: ©} Conserve water by Using power blowers instead af hoses for many: lawn and garden applications, including areas such as gutters, screens, patios, grills, porches and gardens. 4: Never toi touch the spark plug or plug cord while tha. engine: is. in. operation.
18 A 5. For safe operation maintenance: of repair work not described in this manual must be performed, please contact & representative from Ing Tor nearest Tan aka militarized servicing dealer for assistance, 75: Do not Use any accessory or attachment dither than Tan aka recommended by manufacturer.
F3 [TBL7800R] Sef up BW LOWER TUBES 1: Connection blower: and: swivel joint with flexible: hose, Clamp both ends of the flexible hose securely with the hardware supplied with the unit. 2. Align ihe protrusion and the groove provided on the tube ends and twist the tube until connection: is Socked up: my E% NOTE | Eight lubricant may be Used 10 vase Assembly of 1 fexdblé pipe 16 blower skibob.
7. Fuel 22 u FUEL Aw Warning « « Gasoline is very flammable, Avoid smoking or bringing any flame or sparks near fuel, Make sure fo stop the engine and allow it cool before refueling the unit. Defect outdoor bare ground for fueling and move: al least 3m (101) away from the. fueling point before starting the engine. The Tan aka engines are lubricated by oil specially. formatted for air-cooled 2-cycle gangling engine use.
7. Fuel rings; fuel Ines or fuel tank of the engine, MW HOW TO MIX FUEL © IMPORTANT Pay attention to agitation. 1: Measure out the quantities of gasoline and oil-to be mixed. 2: Put-some of the gasoline into a clean, approved dual container: 5. Pol In all of the ofl and agitate well. 4: Pour In the rest of gasoline and agitate again tor at least. one: minute. As some oils may. be difficult io. agitate depending on oll ingredients sufficient agitation is necessary for the engine to last ling. Be.
7..Fuel FOR YOUR ENGINE LIFE, AVOID; J FUEL WITH NG AIRFOIL GASOLINE} = it will cause severe damage to the internal engine parts Nero Quickly. 2 GASOHOL = It can: cause deterioration of rubber and/or plastic pairs and disruption of engine lubrication. 3.0L FOR 4:CYCLE ENGINE USE “It can Gauss spark: plug: folding, ‘exhaust port blocking, of lepton ding sticking, 4. Mixed fuels which have been left unused for period of one premonition may slog the carburetor and resultant engine failing fo operate properly.
£5: {TBL7800] Itl@ [TBL7800R] FO ITRL7800] Flo. 28 8. Operation CONTROL ARM [TBL7800] (£5) SHO the Upper ent ol the control akin hand and; while puling it away from the unit, rotate am forward {anticlockwise as the arrow direction) until it clicks: {The first position) Audi you want; you san rotate armorer forward until it clicks: {The second position} Choose the arm: position: according fo. vols working condition +: Twofold the arm; reverse the cuds.
Fl F12 {181.7800} F13 [TBL7600R] Fa 30 4. Operation ‘exhaust port. 6. Nee the engine is running, gradually: penitent hoke it twas sat closed, dnd let the engine ri at idle peed for a minute to wait up: ER NOTE When the ending falls 10 stein alter several attempts due to overcooking: open the chichis and satrap pulling the Ope. ADJUSTING IDLE SPEED (F11) «The idling speed is get for: 2000 mm at the factory.
9. Maintenance Maintenance, replacement, or repair of the emission control device and systems may be performed: by any non-road: engine: repair ‘establishment or individual. Bailey Every Every Every Systematization. Procedure oF 25 hours.
F15 Fig in Fi7 = F (060.70) Maintenance CLEANING AIR FILTER: 1: Unscrew 2: knob bolts and remove the air-cleaner cover. Then remove a air filled mounted inside the air cleaner cover. (1) Knob Alt (2) Ai filter 2: Wash the alr filter inf: fresh, non: Amiable cleaning solution (ex. warm soapy Water) and then dry. A WARNING Saturate the air filter in 2 cycle ot or the: equivalent. Squeeze the air filter io distribute the vil completely and to remove any excess oil.
Fig Fig 38 9. Maintenance © IMPORTANT * Nat Wat using any. spark plugs ‘fierier than hose designated may result in the engine failing to operate proper origin the engine becoming overheated and damaged. To install the spat plug. fist ure the plug unit it ls finger feint, thee tighten ita gunner wm more with schizophrenic: “ W MUFFLER A WARNING = Inspect periodically, the muffler for loose teenagers, any: damage or cohesion. if any.
9. Maintenance F20 m (1) Three Bolts {2} Spark Arrested. WAR INLET NET: @ IMPORTANT «Blowing air is taken in: from the alr inlay net: When air fiat has dropped dow duding operation. stop the Angie and inspection air inlet net for blocking hy. tacticians: Note that failure da remove gny:siichiotistacies may. result in the engine becoming overheated and damaged.
los 9; Maintenance A WARNING The flap on the end of the strap works as a stopper. Never install the strap with the flapped side Inside; or the unit may fall from the operate, which could result in Injury to the ‘operator landlord damage to the unit. © \IMPORTANT Do not apply liquid type screw lock glue on screws. or ‘bolts ‘used to fix plastics components: ‘Adherence of this type of glue may cause cracks ‘ort plastics and end up with the breakage. 10.