Air Compressor User Manual

ManualsBrandsTask Force, a Lowe's brand ManualsAir Compressor83691

TASK FORCE

Air Compressor

Electric Handheld

Item #83691

2 gallons

100 max psi

120 VAC -- 15 amp minimum circuit

Includes: 25 ft nylon coil hose and 17 pc accessory kit

OWNER'S MANUAL

and Parts List

For customer service, contactq

,, 1-800-628-8815 ext. 5000 J

WARNING!

_, ead and understand all safety precautions and operating instructions before using

this portable air compressor.

Midwest Air Technologies, Inc., 625 Barclay Boulevard, Lincolnshire, IL 60069

1/12/03

Rev.01

Summary of content (10 pages)

PAGE 1
TASK Item #83691 FORCE Air Compressor Electric Handheld 2 gallons 100 max psi 120 VAC -- 15 amp minimum circuit Includes: 25 ft nylon coil hose and 17 pc accessory kit OWNER'S MANUAL and Parts List ,, For customer service, contactq 1-800-628-8815 ext. 5000 J WARNING! _, ead and understand all safety precautions this portable air compressor. and operating instructions before using Midwest Air Technologies, Inc.
PAGE 2
TABLE OF CONTENTS Page Safety Definitions .................................................................................................. 3 Glossary ................................................................................................................ 3 Duty Cycle ............................................................................................................ 3 Description of Operation .......................................................................................
PAGE 3
Safety Definitions The information listed below should be read and understood by the operator. This information is given to protect the user while operating and storing the air compressor. We utilize the symbols below to allow the reader to recognize important information about their safety. Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. Indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury.
PAGE 4
Important Safety Instructions and Guidelines • Save all instructions Improper operation or maintenance of this product could result in serious injury and/or property damage. Read and understand all • of the warnings and safety instructions provided before using this equipment. The air compressor should be operated on a dedicated 15 amp circuit. If the circuit does not have 15 free amps available, a larger circuit must be used. Always use more air hose before utilizing extension cords.
PAGE 5
Risk of Electrical Shock Do not use the air compressor in the rain or wet conditions. Electrical repairs should be performed by authorized personnel such as an electrician and should comply with all national and local electrical codes. The air compressor should also have the proper three prong grounding plug, correct supply voltage, and adequate fuse protection. Risk of Never operate the compressor near combustible materials, gasoline or solvent vapors.
PAGE 6
Operating Procedures Daily Start-Up Procedures 1. Set the On/Off switch to the Off position. 2. Check the air compressor visually for any damage or obstruction. 3. Close the drain valve. 4. Plug the power cord into the proper receptacle. 5. Turn the On/Off switch to the On position and the compressor should start and build air pressure in the tank to cut-out pressure and then shut off automatically. 6. Adjust the regulator to a PSI setting that is recommended for your application. 7.
PAGE 7
Troubleshooting The air compressor should be turned off and unplugged from the power source before any maintenance is performed as well as the Guide air bled from the tank and the unit allowed time to cool. Personal injuries could occur from moving parts, electrical sources, compressed air, or hot surfaces. PROBLEM POSSIBLE CORRECTION Air leak from safety valve. Operate the safety valve manually by pulling on the ring. If the valve continues to leak when in the closed position, it should be replaced.
PAGE 8
....37 21 _ 17 ........ % T 30 j- . 18 __.... /' / / 4O j- 2 16_¸¸¸¸¸¸¸¸ 15.¸¸¸¸¸¸¸ 14-.¸¸ "1 12 13. 34-¸¸ 22 27 28 _5 43 0 42 .........51 ® .....
PAGE 9
AiR COMPRESSOR MODEL LFD2H PART UST Ref. # Part Number 1 Description QTY. DC Motor 1 Ref. #1 Part Number 27 ..... 2 Motor Bolt, M5 x 0.8 x 110 28 ............ Lock Washer, 5ram 6 4 Motor Housing 1 29 30 ........ 5 Eccentric 1 6 Connecting Rod 1 Bearing 31 32 33 1 .... 8 Piston Ring 1 9 Piston Plate 1 Valve 1 11 Screw, M3 x 0.
PAGE 10
Limited Warranty Midwest Air Technologies, Inc. warrants to the original purchaser that each new air compressor and service part is free from defects in material and workmanship and agrees to repair or replace under this warranty any defective product or part as follows from the original date of purchase. 1 YEAR - Warranty on all air compressor products.