Full Product Manual

DANGER
DO NOT PRECEED with cable installation or go
new the lift work area unless visual conrmation
is made of ALL Safety locks. ALL locks MUST be
engaged before proceeding. Failure to comply
with this instruction may result in severe personal
injury or death
DANGER
1. Inspect Cables to insure proper lengths , All
Cables should have ID tags showing proper Cable
lengths.
2. In order to install the Cables it is necessary to
rst extend the hydraulic Cylinder. Remove both
Cylinder port plugs then use an air gun or come-
along to extend the Cylinder.
IMPORTANT!-Be careful not to damage the
chrome rod during this step.
1. Make sure the Cylinder Flange Plate is installed
with the guide assembly facing down and the
Cylinder Retaine’ plate on the outside of the
guide. Lug ends of Cables start at Cylinder.
2. Route the threaded Cable ends through the
ends of each Cross Tube. Care must be taken
when routing the Lifting Cables to ensure they are
routed below the Cross Tube Mounting Bolts.
Care must be taken when routing Lifting
Cables through the Cross Tube. Lifting
Cables must be run BELOW Cross Tube
Mounting Bolts. Serious damages or
injury may occur if Cables are not routed
properly.
3. Route Cables over the Secondary Safety
Sheaves then to the top of each Column. Secure
using the M18 Hex Head Nuts and Flat Washers.
(See NEXT 2 PAGES)
3. You must reinstall the Sheaves. Spacers and
Pins in the same order as they are removed.
STEP 5
STEP 6
(Cable / Sheave Installation)
(Cable Installation)
WARNING
DO NOT exceed 50 PSI. if
cylinder does not move .
STOP and use a come-along
or other Pulling devise. Keep
hands clear.
Rubber tip
air gun
Rear port
DOUBLE sheave
SINGLE sheave
Power-side Post
Lifting Cables
Cross Tube Mounting Bolts
Cylinder
Cylinder
Hydraulic tting
here
Cylinder
guide assy
Warning
1 1/4 minimums
threads must
protrude through
nut
Cylinder retainer
plate
Utility rail
DANGER
Failure to route lifting Cables as described may
lead to serious personal injury and/or death to
operator or bystander and/or may cause damage
to property.
DANGER
DANGER
TORIN COMMERCIAL EQUIPMENT
28 REV 190425