User's Manual
Table Of Contents
- Front Cover
- Foreword
- Table of Contents
- Foreword ii
- List of Figures vii
- List of Tables xi
- Commercial Warranty xiii
- Model Numbering, Charts, and Specifications xvii
- Chapter 1 Introduction 1-1
- Chapter 2 Radio Power 2-1
- Chapter 3 Theory of Operation 3-1
- Chapter 4 Troubleshooting Procedures 4-1
- Chapter 5 Troubleshooting Charts 5-1
- Chapter 6 Troubleshooting Waveforms 6-1
- Chapter 7 Troubleshooting Tables 7-1
- Chapter 8 Schematics, Board Overlays, and Parts Lists 8-1
- Appendix A Replacement Parts Ordering A-1
- Glossary Glossary-1
- Index Index-1
- List of Figures
- List of Tables
- Related Publications
- Commercial Warranty
- Model Numbering, Charts, and Specifications
- Portable Radio Model Numbering System
- ASTRO XTS5000 VHF Model Chart
- ASTRO XTS5000R (Ruggedized) VHF Model Chart
- ASTRO XTS5000 UHF Range 1 Model Chart
- ASTRO XTS5000R (Ruggedized) UHF Range 1 Model Chart
- ASTRO XTS5000 700–800MHz Model Chart
- ASTRO XTS5000R (Ruggedized) 700–800MHz Model Chart
- Specifications for VHF Radios
- Specifications for UHF Range 1 Radios
- Specifications for 700–800 MHz Radios
- Chapter 1 Introduction
- Chapter 2 Radio Power
- Chapter 4 Troubleshooting Procedures
- Chapter 5 Troubleshooting Charts
- 5.1 List of Troubleshooting Charts
- 5.2 Main Troubleshooting Flowchart
- 5.3 Power-Up Failure
- 5.4 DC Supply Failure
- 5.5 Display Failure (NNTN4563, NNTN4819, & NNTN4717 VOCON Kits)
- 5.6 Display Failure (NTN9564)
- 5.7 Volume Set Error
- 5.8 Channel/Zone Select Error
- 5.9 Button Test
- 5.10 Top/Side Button Test
- 5.11 VCO TX/RX Unlock
- 5.12 VOCON TX Audio
- 5.13 VOCON RX Audio
- 5.14 RX RF
- 5.15 TX RF (VHF)
- 5.16 TX RF (UHF R1/700-800MHz)
- 5.17 Keyload Failure
- 5.18 Secure Hardware Failure
- Chapter 6 Troubleshooting Waveforms
- Chapter 7 Troubleshooting Tables
- Appendix A Replacement Parts Ordering
- Glossary
- Index
- Back Cover
6881094C31-C October 14, 2003
Troubleshooting Charts: Power-Up Failure 5-3
5.3 Power-Up Failure—Page 1
MAEPF-27389-C
Radio
Power-Up
Failure
Remove
R528 (VOCON)
Replace U301
(Flipper) and
place R528
back on board
Fixed?
Place R528
back on board
Probe
32.768 kHz
Clock at R316
Signal
Present?
Is
VOCON Board
NNTN4563, NNTN4819,
or NNTN4717
kit?
Signal may appear
for a very short period
of time (50 ms). Use
an oscilloscope with
trigger to capture signal.
Verify integrity
of C308 and
C309
Remove
Shield
SH101
Verify Standard
Bias in
Table 5-1
Standard
Bias OK?
Isolate and
Repair Problem
See DC Supply
Failure flowchart
No
No
No
No
Ye s
Ye s
Ye s
Ye s
1
2