T300e Operator Manual

MAINTENANCE

Tennant T300e (03- 2015)

TROUBLESHOOTING - Continued

PROBLEM CAUSE SOLUTION

T railing water - poor or

not water pickup

Full recovery tank or excessive foam

buildup

Drain recovery tank

Loose drain hose cap or flow control

valve is open

Replace cap or close flow control valve on

drain hose

Worn squeegee blades Rotate or replace squeegee blades

Clogged drip trap (Squeegee

assembly)

Remove cover and clean

Clogged squeegee assembly Clean squeegee assembly

Loose vacuum hose connection Secure vacuum hose connection

Clogged vacuum hose Flush vacuum hose

Damaged vacuum hose Replace vacuum hose

Clogged float shut-off screen in

recovery tank

Clean screen

Recovery tank lid not completely

closed

Check lid for obstructions

Defective seals on recovery tank lid Replaced seal

Little or no solution flow Empty solution tank Refill solution tank

Low solution flow rate set Increase solution flow rate

Clogged solution tank filter Clean filter

Plugged solution supply line Flush solution supply line

Short run time Low battery charge Charge batteries

Batteries need maintenance See BATTERIES

Defective battery or end of battery life Replace batteries

Battery discharge indicator (BDI)

programmed incorrectly

See CHARGING BATTERIES

Faulty charger Replace battery charger

Brush pressure set too high Lower brush pressure. Lower dual down

pressure lever if equipped