MSDS

MATERIAL SAFETY DATA SHEET
THE TESTOR CORPORATION
440 BLACKHAWK PARK AVENUE
ROCKFORD, ILLINOIS 61104
Telephone number:[phone] (M-F 8:00 AM - 4:30 PM CDT)
24 hour Chemtrec telephone number: *[phone] Page 1 of 4
24 hour Chemtrec International number: *[phone] (collect calls accepted).
*TO BE USED ONLY IN THE EVENT OF CHEMICAL EMERGENCIES INVOLVING
A SPILL, LEAK, FIRE, EXPOSURE, OR ACCIDENT INVOLVING CHEMICALS.
Date prepared: 3/12/2012
This MSDS complies with OSHA 29 CFR 1910.1200 (The Hazard Communication Standard)
*********************************************************************************
----------------- SECTION I - PRODUCT IDENTIFICATION ----------------------------
PRODUCT IDENTITY (TRADE NAME): Water-Base Paints (all colors) for Paint Sets:
#4071, #4072, #6196, #9135, #9136, #9163, #9169,
#9174, #9175, #9178, #9188, #9196, #9197, #9199,
#9215, #9216, #9219
(This MSDS covers all products listed on page 4.)
---------------------------------------------------------------------------------
----------------- SECTION II - HAZARDOUS INGREDIENTS & COMPOSTION INFORMATION ---
SPECIFIC_CHEMICAL_NAME CAS_# %_WT OSHA_PEL/TWA ACGIH_TLV/TWA
Propylene Glycol n-Butyl Ether 5131-66-8 5-12 Not Estab. Not Estab.
Dipropylene Glycol n-Butyl Ether 29911-28-2 1-5 Not Estab. Not Estab.
Trimethyl Pentanediol Diisobutyrate 6846-50-0 1-3 Not Estab. Not Estab.
Carbon Black Pigment** 1333-86-4 0.1-4.0 3.5 mg/cu.m. 3.5 mg/cu.m.
Titanium Dioxide Pigment** 13463-67-7 0.1-20 15 mg/cu.m.* 10 mg/cu.m.*
** Contained at levels 0.1% or greater in products identified with a "+"
on page 4.
Non-Hazardous and Other Not Avail. Balance * Total Dust
Ingredients Below Reportable Levels
---------------------------------------------------------------------------------
------------------ SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS --------------
BOILING RANGE: 212 to 447 deg.F SPECIFIC GRAVITY (Water=1): 1.118 (TYP)
GALLON WEIGHT OF VAPOR PRESSURE: 17.1 mm Hg @ 20 deg.C (calc.)
PRODUCT (Lbs/Gal): 9.31 (TYP) VAPOR DENSITY: Lighter than air.
PERCENT VOLATILES EVAPORATION RATE: Slower than Ethyl Ether.
(By Volume): 72.5 (TYP)
---------------------------------------------------------------------------------
----------------- SECTION IV - FIRE & EXPLOSION HAZARD DATA ---------------------
FLASH POINT (SFCC): > 200 deg. F
OSHA FLAMMABILITY CLASSIFICATION: Combustible Liquid - CLASS IIIB
FLAMMABLE LIMITS (calc.) IN AIR: LEL 2.6, UEL 12.5
EXTINGUISHING MEDIA: Alcohol resistant foam, carbon dioxide, dry chemical or
water fog.
SPECIAL FIRE FIGHTING PROCEDURES: A stream of water could spread fire. Avoid
breathing vapors. Keep personnel removed from and upwind of fire. Wear full
protective equipment: Eye/Face Shield, Body (Full Bunker Gear), Respiratory
(SCBA).
UNUSUAL FIRE AND EXPLOSION HAZARDS: Cool fire exposed containers with water
spray (fog). Vapors may travel to an ignition source and flash back.
Overexposure to decomposition products may cause a health hazard.