CARE AND USE FOR WALL HOODS (Turn Book Over for Installation Instructions) READ AND SAVE THESE INSTRUCTIONS HTSW HCSW HDW HGSW HSW 5551 McFadden Avenue, Huntington Beach, CA 92649 • 800/735-4328 ECO 71592 • 35-05-310A • © BSH Home Appliances Corp.
IMPORTANT SAFETY INSTRUCTIONS WARNING TO REDUCE THE RISK OF FIRE, ELECTRIC SHOCK, OR INJURY TO PERSONS, OBSERVE THE FOLLOWING: 3. Clean ventilating fans frequently. Grease should not be allowed to accumulate on fan or filter. 4. Use proper pan size. Always use cookware appropriate for the size of the surface element. CAUTION FOR GENERAL VENTILATING USE ONLY. DO NOT USE TO EXHAUST HAZARDOUS OR EXPLOSIVE MATERIALS OR VAPOR. 1. Use this unit only in the manner intended by the manufacturer.
LES INSTRUCTIONS DE SÉCURITÉ IMPORTANTES AVERTISSEMENT POUR RÉDUIRE LE RISQUE D’INCENDIE, DE CHOC ÉLECTRIQUE, OU DE LA BLESSURE AUX PERSONNES, OBSERVER LE SUIVANT: ATTENTION SEULEMENT POUR L’UTILISATION D’AÉRATION. NE PAS L’UTILISER POUR ÉPUISER LA VAPEUR OU LES MATIÈRES EXPLOSIVES OU DANGEREUSES. 1. Utiliser cet appareil seulement dans la manière destinée par le fabricant. Si vous avez des questions, contacter le fabricant (800/735-4328). 2.
CONTROL PANELS MODELS: HDW, HTSW ELECTRONIC TOUCH CONTROLS MODELS: HCSW and HSW ELECTRONIC PUSH BUTTONS A. Motor OFF button B. Motor ON button and speed selector 1, 2, 3, 1..... C. Speed 1 LED D. Speed 2 LED E. Speed 3 LED F. Intensive 4th speed LED G. Intensive 4th speed button - this speed will run for 10 minutes, and then return to previous setting, including OFF. H. Light ON, OFF button A. Motor OFF button B. ON button and motor speed selection button 1, 2, 3, 1,.... C. Speed 3 LED D.
OPERATING INSTRUCTIONS - HOOD The blower should be turned on for about 5 minutes before cooking in order to establish air currents upward through the hood. Thus when heat, smoke, moisture, grease and cooking odors are produced, they will be carried outside instead of drifting into other rooms. Use the low speeds for normal use and the higher speeds for strong odors or fumes. Drafts across the range or cooktop will reduce the effectiveness of the hood. Such drafts should be prevented when possible.
Replace Lights For Models HDW, HGSW, HCSW30/36/42 (Fig. 3) • Unscrew the light cover. • Remove the damaged light and replace with a new 12 Volt, 20 Watt (maximum) halogen light made for a G-4 base. Follow package directions and do not touch new light with bare hands. • Reinstall the light cover.
Fig.
THERMADOR HOOD WARRANTY Length of Warranty FULL ONE YEAR WARRANTY Covers one year from date of installation, or date of occupancy on a new, or previously unoccupied dwelling. Save your dated receipt or other evidence of installation/ occupancy date. Thermador Will Pay For: All repair labor and replacement parts found to be defective due to materials and workmanship. Service must be provided by a Factory Authorized Service Agency, during normal working hours.
INSTALLATION INSTRUCTIONS WALL HOOD SERIES: HDW, HSW, HCSW, HGSW, HTSW FOR RESIDENTIAL USE ONLY NOT TO BE INSTALLED OVER GAS GRILLS PLEASE READ ENTIRE INSTRUCTIONS BEFORE PROCEEDING. INSTALLATION MUST COMPLY WITH ALL LOCAL CODES. IMPORTANT: Save these Instructions for the Local Electrical Inspector’s use. INSTALLER: Please leave these Instructions with this unit for the owner. OWNER: Please retain these instructions for future reference.
E. Due to size and weight of this unit two installers are recommended. F. When cutting or drilling into wall or ceiling, do not damage electrical wiring and other hidden utilities. G. Ducted fans must always be vented to the outdoors. Do not vent to the attic or crawl space. H. WARNING - TO REDUCE THE RISK OF FIRE, USE ONLY METAL DUCT WORK. I. Install this hood in accordance with all requirements specified.
Page 3 33" 33" 25-5/8" 25-5/8" 25-5/8" 25-5/8" 42-1/2" 42-1/2" 42-1/2" 42-1/2" 30" 36" 42" 48" 21-5/8" 21-5/8" 21-5/8" 21-5/8" 23-1/4" 23-1/4" 18-7/8" 18-7/8" 19-5/8" 37 42 HSW30 HSW36 33" 33" 33" 33" 42-1/2" 42-1/2" 49-1/4" 36" 42" 48" 23-1/4" 33" 45-7/8" 36" HTSW36 57 29-3/4" -3/ 33" 45-7/8" 42" HTSW42 68 29 4" 33" 54" 36" HGSW36 88 25-5/8" * Height if Upper Telescope Piece is Left Off.
Parts Included with your Hood • • • • • • • • • • • • • Parts Not Included with your Hood Hood Canopy Assembly with Ventilator and Light Bulbs Installed Care & Use /Installation Instructions Registration Card.
Preparation of mounting surface (Drywall) 1. Select a mounting height comfortable for the user and mark on wall behind cooktop. 2. Mark center line of cooktop and draw vertical line from bottom of hood to the ceiling. 3. Tape template, matching centerline and hood bottom as shown in Fig. A. 4. Mark centers of the 6 fastener locations through template on wall then remove template. 5. Mark wall with horizontal line 1" above highest and 1" below lowest fastener location. 6.
Appliance Installation: A. Install transition on top of hood if removed for shipping. Fig. C B. Hang hood on 2 mounting hooks through the rectangular cutouts on back of hood. Fig. D C. Level the appliance, using a carpenters level across bottom of hood with leveling screws in mounting hooks or rectangular cutouts. D. Secure hood with 2 screws on top and 2 screws on bottom. See Fig. D. E. Connect ducting (Fig. C).
Do not use duct smaller than the transition. Wiring: Warning: Turn off power circuit at the service panel before wiring this unit. Wiring to power supply 1. 120 V AC, 15 AMP branch circuit required. 2. Remove the knockout and install the conduit connector (1/2") in junction box. 3. Run 3 wires; black, white and green (wire gauge per code) in 1/ 2" conduit from service panel to junction box. 4. Connect black wire from service panel to black or red in junction box, white to white and green to green-yellow.
Alternate - reduced ceiling height Installation for HDW and HTSW and HGSW models: The hood may be installed with only the lower part of the duct cover to reduce the overall height. This hood height is signified by * in Table 1. For the duct cover to slide down and engage the top of the hood, the ceiling bracket must be mounted 1/4" below the ceiling.