8 Owner' sf Operator's Manual Sauna heater installation, wiring, operating instructions, troubleshooting, maintenance and guarantee. IMPORTANT! This manual must be left with owner, manager, or operator of Sauna after it is used by electrician! MODEL MODEL HCT105-1 HCT120-1 HCT144-1 HCT105-3 HCT120-3 HCT144-3 CONTROLS CONTACTORS F-2T F-2 FX404 FX503 ,.,.... , �. � � � ,� c ,,....
81205_NC
THE SAUNA ROOM SHOULD BE PROVIDED WITH PROPER VENTILATION MINIMUM CLEARANCES, MIN-MAX SPACE, ADEQUATE VENTILATION HEATER MIN. CLEARANCE FROM WALL AND FENCE VENTILATION, MIN. SQ.IN. INLET AND OUTLET 10 kW--+ 30 sq.in. 12.5 kW and 15 kW ---+ 45 sq.in. 5" MIN. 110 kW) 6" MIN. 112.5-15 kW ) "' "' "' 21/2" ,- ,.. 20" I,. 20" .. I-' WOOD FENCE "' -1 / --.,, .,, .,, .,, V' 1-:r:w (:>:r: (') _ _J W,t I ::, . a: �o ::ez � 2 1/2" Figure 4 . �o cor---- �. a., � HEATER MIN.
Power source: 240V, single phase power into contactor box shall be provided from an NRTL --11 .. ��1 Listed (UL, ETL, TUV, etc.) load center with branch circuit protectors LOAD CENTER (Supplied by Electrician) Line 2 -------- ------------ - T' - - --------- ,' Line 1 - - - - - - - - ' l SAUNA CONTROL F-2T , ,.. ' ' '' ' -- �1 '. 2 l4ol4ol ' , l2 ' L2 ' CONTACTOR BOX FX404 ·······················. �---···.'l...... ! ---;-' ---------;----,; ii i TTTT ' Terminal Block �-t1_ --- ---�-' .
Power source: 208V, three phase power into contactor box G SAUNA CONTROL F-2T N L1 L3 L2 '' ' G�� CONTACTOR BOX FX503 001---------------- ---- ------------�:____::::::::::::::::::::::::� -=- --=- ------ ---- Thermostat ' ' ' ' ' ' ' #14 ·-------'T-' ' ' ' ' ' '' '' '' '' '' ' ' ' Room Light Switch '---�-------� ' 1 • • • • • • • • C: 2 3 4 :.:; "':, Q) N To sauna interior light. 120V, 100W maximum Q) C: :.:; • ��:����l TO CERTIFIED TO PANEL C22.2 NO.
81205_NC
MODEL VOLTAGE PH WIRE SIZE WATTS AMPS HCT105-1 10 000 41.7 HCT120-1 12 600 52.7 HCT144-1 14 800 61.7 240 240 240 1 1 1 breaker to load center load center to contactor #6 copper #6 copper #4 copper (4) #10 copper (4) #10 copper (4) #8 copper breaker to contactor 208 208 208 27.3 HCT105-3 9 800 HCT120-3 12 300 34.1 HCT144-3 14 400 40.
1205_NC
J. warranty on parts is void if installer/electrician fails to follow necessary wiring information provided or fails to follow code for proper wire size, amperage, etc. OVERHEATING LIMITER Club heaters are equipped with 2 overheating limiters which are safety devices. If an abnormal heating condition should occur, the heater will automatically shut off, and it will not come on again until it cools.
MAINTENANCE INSTRUCTIONS 1. Use only clean water on Sauna stones. Do not use spa or pool water as it will destroy your heater. 2. Clean water should always be used in Sauna buckets and water should be dumped out after every use. Scour buckets and dippers occasionally when film collects from usage. Use plastic bucket liner in bucket to prevent water leakage. 3.
GUARANTEE This Sauna heater is guaranteed for one year from date of purchase, and includes all heater parts such as heating elements, controls, contactors, etc. This guarantee covers faults in manufacture and material only, and includes the exchange of new parts supplied by the manufacturer or manufac turer's agent, after the faulty part has been returned to same. The replacement of parts under warranty does not extend the warranty period beyond the original one year.
SPARE PARTS SAUNA HEATERS 1 HCT105-1, HCT120-1, HCT144-1 HCT105-3, HCT120-3, HCT144-3 1 2 3 4 5 6 7 8 9 10 11 12 /,1/;4 5 .