z Model Number 465630003 Owner'sManual i i Assembly, Operation, Use and Care i ThisGrillis for OutdoorUseOnly Read and follow all safety statements, assembJy instructions, and use and care directions before attempting to assembJe and cook. hstalledassembler: Leave these instructions with consumer. Consumer: Keep this manua[ for future reference. Failure to follow aJ[ manufacturer's instructions could result in fire or explosion which could cause property damage, personal injury or death.
FOR YOUR SAFETY 1, Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance, 2, An LP tank not connected for use shall not be stored in the vicinity,of this or any other appliance, FOR YOUR SAFETY If you smell gas: 1, Shut off gas to the appliance, 2, Extinguish any open flame, 3, Open lid, 4, If odor continues, immediately call your gas supplier or your fire department, Safety SymboJs The symbols and boxes shown below explain what each heading means
LP (Liquefied Petroleum Gas) • Is nontoxic, odorless and colorless when produced, For Your Safety, LP gas has been given an odor (similar to rotten cabbage) so that it can be smelled, LP gas is highty flammable and may ignite unexpectedJy when mixed with air. CAUTION For residential use onJy, Do not use for commercial cooking.
Warranty Thermos warrants to the original consumer-purchaser that this product shall be free from defects in workmanship and materials under normal and reasonable use and correct assembly (If assembled by consumer*purchaser) as follows: (I) The aluminized top and bottom for a period of three (3) years from date of purchase; excluding the paint finish; (2) The burner/venturi assembly for a period of three (3) years from date of purchase; (3) The cooler and lifting mechanism for a period of one (I) year from
For Your Safety ............................................................. 2 Safety SymboJs LP (Liquefied Petroleum Gas) ................................................. 3 Grill Service Center installation Safety Precautions Warranty information Warranty .................................................................. 4 TaMe of Contents ........................................................... 5 Grill Features ............................................................. 6°7 Parts List ...
-- Heat indicator lass Ignitor Level Cooter Foot CooJer shelf support Pull handWCooler shelf 6 ° Fire & Ice
Too[holders Match lighting Cup/can Tool set Grease bottle Lift handle Fire & iceo 7
Key 5 6 7 8 9 I0 11 12 13 14 15 8, Fire & Ice Quantity 1 1 1 1 1 1 1 1 1 2 17 18 19 20 21 22 1 1 1 1 1 1 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 I I 1 1 1 1 1 1 1 2 1 1 1 1 1 1 2 1 1 43 44 1 4 Description TorsionBar Part Number 21-6047o009-200 Grill Lid 65-6048-018-200 Center LidSpacer UpperLatch HandleAssembly HeatShield Grate Burner CollectorBox Electrode LowerHeatShield Side Shelf-Left PivotPin IgnitorWire Side Shelf: Right Grill Bottom LowerLatch LatchClasp HeatIndicator
I Fire & Iceo 9
/ 10, Fire & Ice
To raise grill... PRESS and RELEASE foot pedal on front of coobr. Foot pedal MUST BE RELEASED once the grill begins to rise so that the grill will lock into position. Slide coobr lid back to open and lift grill Jid to remove packed components.
IMPORTANT: DO NOT attach gas regulator to grill at this point. will not close if regulator is in place. Slide wheels onto axle. Secure with axle screw into each end of the axle.
Attach grease bottle by sJiding bottle bracket over tabs on left side of plinth. Grease bottle Twist I Jb. LP gas cylinder (sold separately) into regulator. Regulatom 1 lb.
2. Push and hold the gas interlock downward. 4, Release regulator lock and gas interlock. Regulator lock should spring back to original position to lock regulator in place. NOTE: Gas cylinder and regulator MUST be removed before lowering grill. Grill should not be removed when grill is in raised position.
Attach side sheNes by sJiding shelf rods into holes on each side of grill. NOTE: Shelf with regulator cut-out attaches to right side.
The pull handle on your cooler may converted for use as a shelf by ut[izing the bui[t4n support in the handle. To use the pu[[ handle as a sheff,.. 1. Raise pu[[ handle to horizontal position. 2, Lower the support wire (built into handle). 3. Place support wire into slot in cooler body.
To remove grill from cooler for taNetop use ... Begin with grill in the lowered position. Grasp the plinth on each side (see arrows) and Jift grill from cooler. NOTE: • Grill should not be removed when grill is in raised position. • Do not press pedal when grill is removed. If pedal is accidentally pressed after grill is removed, the grill skirts will raise, tf this happens, align and place grill properly back on skirts prior to lowering (see page 12 for lowering instructions).
To cJose Jegs and return grill to cooJer... Press legs inward to reJease from locked position, then fold legs under plinth. NOTE: Regulator and gas cyJinder MUST be removed from grill before pJacing grill onto cooler. AJign posts beneath plinth with hoJes on top of cooler and slide grill downward onto cooler.
Propane Cylinder Use (1 Jb. Disposable) • Use only cylinder marked "Propane Fuel". • Size should be 4" diameter, 8" height, or 3" diameter, 10" height. • Save cylinder cap and reinstall when not in use. • Cylinder supply system must be arranged for vapor withdrawal. Gas cylinder must be upright in use. Use only I Jb. propane bottles as specified above. Use of other gas bottles could cause gas leak or fire. Leak Testing (1 lb. Disposable) .
Propane CyJinder Use (20 lb. Refillable) The 20 Jb. LP tank used with your grill must meet the following requirements: • Purchase LP tanks only with these required measurements:12" (30.5cm) (diameter) x 18" (45.7 cm) (tall) with 20 Ib. (9 kg.) capacity maximum. • Tank must be constructed and marked in accordance with specifications for LP tank of the U.S.
Leak Testing (20 lb. RefillabJe) fl_ For your safety • Leak test must be repeated each time LP tank is exchanged or refilled. • Do not smoke during leak test. • Do not use an open flame to check for gas leaks. • Grill must be leak checked outdoors in well*ventilated area, away from ignition sources such as gas fired or electrical appliances. During leak test, keep grill away from open flames or sparks. Use a clean paint brush and 50/50 soap and water solution. Use mild soap and water.
Nipple must be centered into the LP tank valve. 6. Turn the coupring nut clockwise to tighten to a futt solid stop. The hose*end will sea! on the back*check feature in the LP tank varve, resurting in some resistance. An additional one-half to three quarters turn is required to complete connection. Tighten by hand only - do not use tools. NOTE: if you cannot complete connection, disconnect hose-end and repeat steps 5 and 6.
Do not use grill until Jeakchecked. ff Jeak is detected at any time, STOP and call the Fire Department. • If you cannot stop a gas leak, immediately cJose LP tank valve and call LP gas suppJier or your fire department! Leak Testing Valves, Hoses and Regulator 1. Turn grill control knob to off. 2. Be sure connector is tightly connected to LP tank, 3. Completely open LP tank valve by turning hand wheel counter clockwise. If you hear a rushing sound, turn gas off immediately.
For Safe Use Of Your Grill: • Do not leave the appliance unattended. Keep children and pets away from the appliance at all times. • Never use regulator from this grill with any other LP appliance. • When cooking, the appliance must be on a level surface in an area clear of combustible material. • Do not block holes in bottom or back of grill. • Check burner flames regularly. • Use grill only in well*ventilated space.
Safety Tips ,& The use of alcohol, prescription or nonprescription drugs may impair the consumer's ability to properly assemble or safely operate the appliance, ,& When grill is not in use, disconnect 1 Ib, cylinder or turn off20 Ib, cylinder.
Match Lighting 1. Push Regulator/Valve in and turn counterclockwise to MGHTING POSFION. 2. Attach match to match lighting stick, light match. 3. Insert match lighting stick into vent hole at rear of grill. If burner does not light within 5 seconds, turn knob to OFF, wait 5 minutes, try again. Burner Flame Check Light burner. Look through viewing glass on front of grill and make sure burner stays lit while rotating the regulator knob from HIGH to LOW. Always check flame prior to each use.
General Grill Cleaning . Do not mistake brown or black accumulation of grease and smoke for paint. Interiors of gas grills are not painted at the factory (and should never be painted). Apply a strong solution of detergent and water or use a grill cleaner with scrub brush on insides of grill lid and bottom. Rinse and allow to completely air dry. Do not apply a caustic grill/oven cleaner to painted surfaces. . Plastic Side Shelves: Wash with warm soapy water and wipe dry.
Non-Stick Cooking Surface Use and Care, , Use only plastic tools, . Do not cut food on surface. . . Do not put pots or pans on surface. Do not leave lid down for more than 10 minutes without food on the grill. Non-stick surface may be damaged. Food Safety Food safety is an important part of enjoying the outdoor cooking experience.
Troubleshooting Problem Possible Cause Prevention/Cure Burner will not Electrode and burner are wet. Wipe dry with cloth. Electrode cracked or broken, "sparks at crack". Replace electrode. Wire is loose or disconnected. Reconnect or replace ignitor wire. Wire is shorting (sparking) between ignitor and electrode. Reconnect or replace ignitor wire. Bad ignitor. Replace ignitor. No gas flow. Check to see if LP tank is empty. Obstruction of gas flow. Clear burner.
Recreational Vehicles THERMOS GRILLS has approved use of the Fire & Ice with specific recreationar vehicles subject to the following provisions: The Fire & Ice is to be directly connected to an additional 20 rb, or 30 Ib, DOT/TC LP tank mounted on the RV,The Fire & Ice cannot be attached to any part of the gas system of the RV except directry to the tank itserf, The additional 20 rb,or 30 rb, tank is availabre from your RV dearer and must be mounted on the RV compryingwith approved RV standards, The connect
FJ_e & be o 3S
1" A Division of W.C.