03 0
Table of Contents $VVHPEO\ 0DQXDO 4XLFN 6WDUW *XLGH :DUQLQJ 7R 8VHUV 6DIHW\ 3UHFDXWLRQV 7HFKQLFDO 6SHFLILFDWLRQV 2SHUDWLQJ ,QVWUXFWLRQV 6DIH 2SHUDWLRQV 7URXEOHVKRRWLQJ 6HUYLFH DQG 0DLQWHQDQFH :K\ LV 0\ 3XPS 1RW 3XPSLQJ" 3DUWV &DWDORJ :DUUDQW\ 2
TPS25 QUICK HOW-TO GUIDE www.tomahawk-power.com Start by assembling sprayer wands 2 1 Washers 1 4 3 5 6 Place washers inside brass connectors ∙Double check that all connections are correct and stable. ∙Place washers inside brass connectors & screw onto the machine.
Warning to Users ThLV gasoline engine must use mixed fuel at a ratio of UDWLR ZLWK 1R JDVROLQH WR WZR VWURNH DXWRPRELOH RLO 127( IXHO UDWLR LV UHFRPPHQGHG IRU /DWLQ $PHULFDQ FRXQWULHV Keep engine at a low speed 3-5 minutes after start and before stop. Using your sprayer at a high engine speed without liquid spray or dust is prohibited and may damage your sprayer engine. When adding fuel, stop the engine and keep away from open flames.
SAFETY PRECAUTION •Wear glasses and gauze mask to protect your eyes and face to protect against dust and pesticide. The use of the machine may be hazardous. The impeller rotating in the volute case may cause harm if you try to touch it. It is important that you read & fully understand the following safety precautions and warning. •Wear closed-toed protective shoes. Do not lend or rent your sprayerd u s t e r w i t h o u t t h e O w n e r ’s Manual.
(5) For the operator’s safety, dusting / spraying must be carried out strictly according to the instruction of the chemicals and agricultural requirements. (6) If you want to stop the engine while dusting, the throttle handle must be set to stop. Fueling Keep the fuel tank far away from the flames or sparks. Do not smoke near fuel. When the machine is running, do not add more fuel to the fuel tank. Warning During operation, the muffler or catalytic muffler and surrounding cover may become extremely hot.
Name 6KLSSLQJ 'LPHQVLRQV × 1 × 2 Net Weight (lbs) Chemical Tank Capacity (gal) 6.6 Water Absorption Volume (gal) 1.45 Working Pressure (MP$) 0 ~ 2.5 (QJLQH Power FF Fuel Type 3UH 0L[ )XHO Way of ignition CDI Way of starting Recoil starting Way of stopping Shutting throttle fully 2. Main Application 4. This 7RPDKDZN Power %DFNSDFN Sprayer is the ideal portable tool for prevention of diseases and for plant protection.
5.Operating Instructions 5.1 Preparation before start 5.1.1 Connecting spraying parts. Before starting, verify all the connections are working. 1.Long Spraying Nozzle 2.Washer 3.Straight Spraying Tube 4.Valve 5.Handle 6.Plastic Tube Never fill the fuel tank to the very top. Never add fuel to the tank in a closed non-ventilated area. Do not add fuel to this unit close to a open fire or sparks. Be sure to wipe off spilled fuel before attempting to start the engine. Do not attempt to refuel a hot engine.
5.3.3 Important notes when spraying: A) Swing the spraying tube with your hand after turning on the handle valve. In order to avoid chemical harm, it is strictly prohibited to spray only in one place. B) Operator should face the wind. The spraying tube should form an approximate 15° angle. C) During spraying, the spraying tube should be swung continuously between the left and the right to increase spraying range. Figure 4 5.3.4 Pressure regulation.
6.Safe Operation 6.1 Read the instruction manual carefully. 6.2 Protective gear: a ) Wear a flanged cap b ) Wear dirt/fog-proof goggles c ) Wear a gauze mask d ) Wear a coat guard e ) Wear long sleeve gloves f ) Wear boots 7.Troubleshooting 7.1 Engine troubleshooting guide 3UREOHP )DLOV WR VWDUW &DXVH 5HPHG\ )DLO WR SXVK WKH IXHO LQMHFWLQJ SXPS 3XVK FRQWLQXRXVO\ :DWHU PL[HG ZLWK IXHO 5HSODFH WKH IXHO 'HWHULRUDWLRQ RU FDUERQ GHSRVLW RI VSDUN SOXJ 5HSODFH WKH SOXJ %DG FRQWDFW EHWZHHQ VS
7.2 Troubleshooting for spraying 3UREOHP /LTXLG GRHV QRW VSUD\ RXW /RZ RU QR VSUD\LQJ SUHVVXUH &DXVH 5HPHG\ ,QOHW YDOYH DQG RXWOHW YDOYH EORFNHG 5HSODFH RU FOHDQ :DVKHU LV GDPDJHG 5HSODFH = EHDULQJ LV GDPDJHG 5HSODFH 3LVWRQ LV GDPDJHG Not enough pressure 5HSODFH 5HJXODWH 1RW HQRXJK HODVWLF IRUFH RQ UHJXODWLQJ VSULQJ 5HSODFH &RUURVLRQ UHVLVWDQW VWHHO EDOO ZRUQ 5HSODFH 3UHVVXUH UHJXODWLQJ YDOYH VHDW ZRUQ 5HSODFH 3UHVVXUH LV ILQH EXW VSUD\LQJ LV ORZ 3LVWRQ LV ZRU
9 . Te c h n i c a l M a i n t e n a n c e a n d Long Term Storage Note: The work including maintenance, cleaning and adjusting must be done after stopping the machine. (1)Spraying units a.Clean out any residual chemical mixture in the chemical tank and all other parts after operation with clean water and and dry. Periodically check the braces. Without delay, replace the worn out braces. b.Clean the chemical tank inside and out after spraying. c.Loosen the chemical tank lid. d.
&$/,)251,$ $1' )('(5$/ (0,66,21 &21752/ :$55$17< 67$7(0(17 <285 :$55$17< 5,*+76 $1' 2%/,*$7,216 7KH &DOLIRUQLD $LU 5HVRXUFHV %RDUG WKH 8QLWHG 6WDWHV (QYLURQPHQWDO 3URWHFWLRQ $JHQF\ DQG 7RPDKDZN 3RZHU //& DUH SOHDVHG WR H[SODLQ WKH HPLVVLRQV FRQWURO V\VWHP ZDUUDQW\ RQ \RXU VPDOO HQJLQH HTXLSPHQW 625( ,Q WKH 8QLWHG 6WDWHV DQG &DOLIRUQLD QHZ VPDOO HQJLQH HTXLSPHQW PXVW EH GHVLJQHG EXLOW DQG HTXLSSHG WR PHHW WKH 6WDWH V VWULQJHQW DQWL VPRJ VWDQGDUGV 7RPDKDZN 3RZHU //& PXVW ZDUUDQW WKH H
,I \RX KDYH DQ\ TXHVWLRQV UHJDUGLQJ \RXU ZDUUDQW\ ULJKWV DQG UHVSRQVLELOLWLHV \RX VKRXOG FRQWDFW 7RPDKDZN 3RZHU //& FXVWRPHU VHUYLFH UHSUHVHQWDWLYH DW RU (PDLO VXSSRUW#WRPDKDZN SRZHU FRP '()(&76 :$55$17< 5(48,5(0(176 D 7KH ZDUUDQW\ SHULRG EHJLQV RQ WKH GDWH WKH VPDOO HQJLQH HTXLSPHQW LV GHOLYHUHG WR DQ XOWLPDWH SXUFKDVHU E *HQHUDO (PLVVLRQV :DUUDQW\ &RYHUDJH 7RPDKDZN 3RZHU //& ZDUUDQWV WR WKH XOWLPDWH SXUFKDVHU DQG HDFK VXEVHTXHQW RZQHU WKDW WKH HQJLQH HTXLSPHQW LV 'HVLJQHG EX
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
D 3XOVH YDOYH )RU HQJLQH IDPLOLHV OHVV WKDQ RU HTXDO WR FF )XHO 0HWHULQJ 6\VWHP D *DVROLQH FDUEXUHWRU DVVHPEO\ DQG LWV LQWHUQDO FRPSRQHQWV E )XHO ILOWHU LI VR HTXLSSHG F &DUEXUHWRU JDVNHWV G )XHO SXPS LI VR HTXLSSHG $LU ,QGXFWLRQ 6\VWHP LQFOXGLQJ D ,QWDNH SLSH PDQLIROG E $LU FOHDQHU ,JQLWLRQ 6\VWHP LQFOXGLQJ D 6SDUN SOXJ E ,JQLWLRQ PRGXOH FRLO &DWDO\WLF 0XIIOHU $VVHPEO\ LI VR HTXLSSHG LQFOXGLQJ D 0XIIOHU JDVNHW E ([KDXVW PDQLIROG &UDQNFDVH %UHDWKHU $VVHPEO\ LQFOXGLQJ D %UHDWKHU FRQQHFWLRQ