2'03 2'03 2'03 $4 0 "2(.- -(21 -# 322(-& -(21 . 1130$ , 6(,3, 1 %$27 ./2(,3, /$0%.0, -"$ -# 2. & (- *-.5+$#&$ .% 2'$ /0.#3"2 (2 (1 $11$-2( + 2' 2 7.3 .0 -7 .2'$0 ./$0 2.0 .% 2'$ ,.5$0 0$ # -# 3-#$012 -# 2'$ ".-2$-21 .% 2'(1 , -3 + !$%.0$ 2'$ $-&(-$ (1 $4$0 12 02$# 7 / 02("3+ 0 22$-2(.2. 2'$ '(&'+(&'2$# !7 2'(1 17,!.
'$ 1.4-#2 1. 6 2 #$5$+./$# 3. /1.5(#$ - $%%("($-3 1$+( !+$ -# 3(,$ 2 5(-& ,$3'.# .% ,.6(-& '(&' 04 +(38 341% '$ + 3$23 ".-"$/32 (- $-&(-$$1(-& -# #$2(&- ' 5$ !$$- (-".1/.1 3$# (-3. 3'(2 , "'(-$ +.-& 6(3' 3'$ '(&'$23 04 +(38 / 132 -# 6.1*, -2'(/ 7"$++$-3 2$15("$ 6(++ !$ #$1(5$# (% /1./$1 ./$1 3(.- -# , (-3$- -"$ /1 "3("$2 1$ %.++.6$# $ *-.6 2(-"$ 8.4 ' 5$ /41"' 2$# 3'$ (-#42318 +$ #$1 (- ,.6(-& $7"$++$-"$ 3' 3 %4341$ /$1%.1, -"$ -# #$/$-# !(+(38 1$ .% /1(,$ (,/.13 -"$ +2. (2 ".
$'& $'& # ! Before Operating . . . . . . . . . . . . . . . . . . . . . . . . . 4 While Operating . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Improper use or maintenance by the operator or owner of the machine can result in injury. To reduce the potential for any injury, comply with the following safety instructions. Operate the machine only after reading and understanding the contents of this manual. A free replacement manual is available by sending complete model and serial number to: The Toro Company 8111 Lyndale Ave. S., Bloomington, MN 55420-1196.
Do not touch engine, muffler, exhaust pipe or hydraulic tank while engine is running or soon after it has stopped because these areas could be hot enough to cause burns. Before disconnecting or performing any work on the hydraulic system, all pressure in system must be relieved by stopping engine and lowering implements to the ground. If a cutting unit strikes a solid object or vibrates abnormally, stop immediately.
!% ! " ! ! " ! &() ' !! % ! &() ' !! % &() ' " &() ' &() ' ! " ! &() ' "!! " ! &(
& # & * ) +&) & # & # ) +&) & # & # ) +&) % !% Briggs & Stratton Vanguard, twin cylinder, 4 cycle, air cooled, 16 hp @ 3600 rpm, 35.90 cu. in. (588 cc) displacement, governed speed of 3200 rpm. Mechanical fuel pump, large capacity dual element air cleaner. 5-1/4 pint oil capacity. , # ' !+. 20 liter. ) +!&% )!- Eaton model 11 hydrostatic transmission integrally coupled to a Peerless model 1310 axle. Travel speed range is 0-13.5Km/h (0-8.
0# 1&'0 !& /1 0 !&#!)*'01 1- 002/# ** . /10 ,#!#00 /6 $-/ 00#+ *6 & 3# ##, /#!#'3#" '1&-21 1�# . /10 1-1 * 0#172. ! ,,-1 # !-+.*#1#" -+# . /10 + 6 & 3# */# "6 ##, 00#+ *#" 1 $ !1-/6 01-/ -/) 00#+ *6 &##* 006 . !#/0 * 1 0&#/ &##* -*1 -!),21 -!)#1 # " !/#4 .0!/#4 -2,1',% / 0&#/ -!),21 5*# 00#+ *6 &##* 006 0&#/ -11#/ ', 201 -3#/ .0!/#40 -2,1',% / 0&#/ -!),21 .
8 )' #' ( #" & & + "(# '(#& #& '' ! - "' &( + # ( "(# #" # ( !#)"( " # ' "'( '$ & " ' ( # ( ( &#) ( + "'( "#( & '$ & #"(# # ( " &#)( # ( ( &#) & ! " " '(#& #& !#)"( " # )& ' # !#)"( " $ ( (# & ! & + ( '# ( ' & + $' & + !#)"( " & + ' &' " # ")(' )& '( & " &# (# (#$ # '(#& #& + ( $' & + + ' &' " #
!8" ! " ! $,.4$ " /1"0$5 5 1'$01 -# +."*-32 1$"30(-& %0.-2 $-# .% 12$$0(-& 0.# 2. 12$$0(-& 1$"2.0 &$ 0 5'$$+ 0$ 0 6+$ .-+7 (& $ /.1(2(.- 0.# 1. "304$# $-# .% 0.# (1 2. 2'$ 0$ 0 $"30$ 120 (&'2 $-# .% 0.# 2. 12$$0(-& 1$"2.0 &$ 0 5(2' % 12$-$01 /0$4(.31+7 0$,.4$# *$ 130$ 5 1'$0 (1 .- $ "' 1(#$ .% - / +.&. ".4$0 (-2. /+ "$ 12$$0(-& 1$"2.0 (&'2$- -32 2. , %2 +! ! ! $,' 241' %415'& '.& /( 23''1+.) 1/& +2 3/ 3*' 1'$1 '.3'1 20/,' *$(3 20-+.
SETĆUP INSTRUCTIONS Seat Kit, Model No. 02305, Deluxe Suspension Seat: INSTALL LIFT ARM KIT (Fig. 10-17) 1. ))- &3 ')/(. - . -&# - .) )..)' ) - . -/-* (-#)( 1#." & ,! -* ,- -' && -* ,- ,,# ! )&.- ( & (! &) %(/.- ' && -* ,- .) *)-#.#)( )( .)* ) , , & ,! -* ,- . -&# 1#." ), ( . $/-.#(! & 0 , .) ')/(. )( ,#!". -# ) -/-* (-#)( " ,)/( - ,) #- -"#** 1#.")/. &# . ,' %#. #2 /..#(! (#. # . ,' #. ) & ), &) .#(! /..
. ! +( ! +( +**!% +%!* &, ( %)!&% ( ( " * +**!% +%!* ) ! # # "$ %$$ % $ # $' & " " % $ # # %" ' $ # " '# !" & %# ) " & ( ( #& *!% %$$ % $ " & #$ "# # %" "" " " $ %$$ % $ % $ ' "" " " #%!! $ " $ $ " " %$$ % $ ' $ #$ "# !" & %# ) " & # $ !! " " $
! " # !" # " ! # " " 03%7-2+ 877-2+ #2-7 -+ (*0 * &)/.- - /,$)" # )"' , & . .* /..$)" /)$. (*0 # $"#. *! /. +$)- %/-. -/++*,. +- , 1 .* #$ 0 $( )-$*) .1 ) $"#. *! /. -/++*,. ) rear ,*'' , , & . +' - (*0 # $,+$) *.. ,- /,$)" rear $"#. *! /. +$)- ) , $)-. '' $) .# - ..$)" $) $ . *) $"#. *! /. +' . (*0 # $,+$) *.. ,- /,$)" !,*). $"#. *! /. +$)- ) , $)-. '' $) .# - ..$)" $) $ . *) $"#.
! " ! " ! 4& " ("(& #-0$, 8*5) " 5)*$,/&44 &26"- 50 5)& %&4*3&% )&*()5 0' $65 "/% 104*5*0/ *5 "("*/45 5)& '30/5 &%(& 0' 5)& #&%,/*'& "5 0/& &/% 63/ 5)& 4611035 $"14$3&8 50 "%+645 5)& )&*()5 0' 5)& #&%,/*'& &26"- 50 5)& ("(& #-0$, 004&/ $"33*"(& #0-54 0/ #&%#"3 "%+645&3 *( &1&"5 5)& 130$&%63& "5 5)& 05)&3 &/% 5)&/ 3&$)&$, 5)& 03*(*/"- &/% !-+,7)2 2876 6)'85-2+ 5300)5 &5%'/)76 '5&3 */*5*"- 4&5 61 )&*()5 0' $65 .
! " # !" # " ! # " #"" # "! -+ /2&6-1+ 766-1+ #1-6 !" #"" # " $ "! -+ # !$"# & " ! # # ! % # ! $## $ # !! ! ! # % # ! " $! & # #& " ! & " ! " ! & /2&6-1+ -9)( 766-1+ #1-65 " & " ! & " $! "# $ ! # " # -+74) ",4756 8&5,)4 &44-)4 *4&0) /&68&5,)4 /2'.
SET-UP INSTRUCTIONS 6. !!$ &% ! ! % % $ ! #! !% % #! %! % !# $ !#% #! %! $ # % % &% 2 INSTALL BELT TENSIONERS (Fig. 28 & 30) (Fixed Cutting Units) 1. &# % $ ! # #! %! %# % ! & % # # % ( % " 1 3 2. "& * ! #! % &%% & %$ !% $ ! # # &%% & % $% % % $ ! # % %! $ ! % $ ! # # % ( % "$ # ( ( $ # &% $" # 3.
&$0-" +0*/"- ( * " -) ,-&*$ .% '(" ("1&. ,&* +//"- ,&* &$0-" (" *"- - '"/ "' #" &#"( #)"( & " '$& " ' ' # #+' &$. !#* #(( & $ " " * ' $ " ' )& " '$& " ' (# #)"( & " &! # "#( & !#* #( & * ' $ " #* ' )$ #& #+" #" #)"( & " &! )"( " + ( ' & # # &! "'( * ' $ " " #(( & $ " " - 0//&*$ *&/ ." 0/&+* 2%"* /"*.
SET-UP INSTRUCTIONS 4. To tension rear counterbalance spring, rotate counterbalance knob (Fig. 35) until distance between center of anchor bolt opening and inside of frame X" is as follows: A. Distance X" is 50mm when equipped with 5 or 8 blade reels without baskets. B. Distance X" is 15mm when equipped with 5 or 8 blade reels with baskets. 4 3 1 5 Plain water freezes solid at 32_ F (0_C). The 3-1/2 pound (1 .6 kg) calcium chloride to one gallon (3.
# "#' #) % '' %+ '%# +' * #) % #* #"'# #' % $ %'& # ' ! " " & ) % #%%#& #" " ' % #% ' #" * % &( ' (% '' %+
BEFORE OPERATING CHECK ENGINE OIL (Fig. 38) The engine is shipped with 1-3/4 quarts (w/ filter) (1.7 l) of oil in the crankcase; however, level of oil must be checked before and after engine is first started. 1. Position machine on a level surface. 2. Unscrew dipstick and wipe it with a clean rag. Screw dipstick into the tube and make sure it is seated fully. Unscrew dipstick out of tube and check level of oil.
(' &# &7"0 3*'! 1712#+ '1 "#1'%,#" 2- -.#0 2# -, #,%',# -'* -0 1 13 12'232# #,%',# -'* &# 0#1#04-'0 '1 $'**#" 2 2&# $ !2-07 5'2& ..0-6'+ 2#*7 /3 021 -$ #,%',# -'* &#!) 0#1#04-'0 -'* *#4#* #$-0# #,%',# '1 $'012 12 02#" ," " '*7 2�# $2#0 -1'2'-, + !&',# -, *#4#* 130$ !# ," 12-. 2&# #,%',# #+-4# !!#11 . ,#* #6.-1',% &7"0 3*'! 1712#+ "'.12'!) $'**#0 ! .
& ( $# ! #! 3 , .#)( * & " - .", /( .#)(- )( .) ' % ." ' "#( ')0 ),1 , .1) .) ')0 #. %1 , ( .", .) -.)* ' "#( -#(! ." " & ( .) ) ." ,#!". )). *, -- .)* ) * & .) ')0 ),1 , ( )..)' ) * & .) ')0 %1 , ), .) --#-. #( -.)**#(! 1" ( ')0#(! ),1 , &-) &&)1 * & .) ')0 ), ')0 #. .) ( /., & *)-#.#)( .) -.)* ' "#( $& $% & ($& $" $&( $ #$( & '( ! $ $$( $# & * &' + # $% & ( # $&+ & $ #! 3 ) -. ,.
) *()# $)( "*- *(& $( %$ ) #% " ' (&'! "' , ( " #" %#"' # & ' && ! + #('* % & " '# # & ' $#& ' #" $ % '#% ' (&'! "' (%" &$% " ' "& #" "# # * & '# " % & ' "& #" #("' % # * & '# % & &$% " ' "& #" *' *)) $ *$ ) "% ! *& " + ' ) *() $ ( ' ,( * " *) % "+ , #& ( & (' # ) ) # ' (" % ( ' " * " &'#% " ! " *' %' $ ) " + '
! # "#!$ # " "# !# "# +-* ) *$#'! * $ #+ + , ' +/#, " #+ #' )(+#,#(' &(. ((, *(& ,* ,#(' ) % ' & $ +-* ) % #+ #' ' -,* % )(+#,#(' (. "($ % . * ,( )(+#,#(' 2 /" ' +, *,#'! (% '!#' 2 ' ,"*(,,% % . * ,( " % ,"*(,,% )(+#,#(' '+ *, $ 0 #',( #!'#,#(' +/#, " ' *(, , #, %( $/#+ ,( +, *, ," '!#' % + $ 0 /" ' '!#' +, *,+ !-% , ," "($ ,( $ ) '!#' *-''#'! +&((,"%0 !# # #4 56+:+38 4:+6.+'8/3- 4, 8.
$! %(+'!(!)/ '%"/ '!1!- %. 0.! 1 -%*0. // $(!)/. ! '!.. +/ /* ' 4 *2) ) /$!-!"*-! ! %""% 0'/ /* # /$!- !/2!!) /$! -!!' ' !. ) ! &)%"! /* - %.! ) '*2!- ")"% ** !$ %*) 0'' %(+'!(!)/ '%"/ '!1!- -! -2 // $(!)/ /* /$! !.%-! $!%#$/ /* - %.! &, ("% ** !$ %*) 0.$ %(+'!(!)/ '%"/ '!1!- "*-2 // $(!)/ /* '*2!- *' '%"/ '!1!- %) *2) +*.%/%*) .! *) .
% % # # # # ! $ % $*$% ! # %$ !% & %% %& % # ' #* % &%$ %&# % $ (&30$ $ 0 "322(,& 3,(2 *-") 3.
$! /- /%+* 0*%/ * 0//%*# 0*%/ . #-! .! "%//%*#. )0./ ! (0 -% /! -!#0( -(4 2%/$ + !*!- ( 0-,+.! %/$%0) .! -! .! " ) $%*! %. +,!- /! 0* !*+-) ( +* %/%+*. (0 -% /! ! -%*#. * 0.$%*#. "/!- !1!-4 $+0-. +" +,!- /%+* ! -%*#. * 0.$%*#. )0./ ! (0 -% /! %(4 2$!* +,!- /%*# +* %/%+*. -! !3/-!)!(4 0./4 * %-/4 0./4 * %-/4 +,!- /%*# +* %/%+*. +0( 0.! %-/ /+ #!/ %*/+ /$! ! -%*#. * 0.$%*#. -!.
!, #( # # )%! ( ( ' % $& &$)( # )' %&$% & ' ( $# $ % & ($& ' #) ! $& !) '% ( $#' Daily Maintenance Check For Week Of _________________ Maintenance C Check Item b MON TUES WED THURS FRI SAT SUN n Safety Interlock Operation n Brake Operation n Engine Oil Level n Air Filter Pre–cleaner Clean Engine Cooling Fins n Unusual Engine Noises n Unusual Operating Noises n Hydraulic System Oil Level n Hydraulic Hoses for Damage n F
" +) ! '(13' 4'37+%+0) 13 /#-+0) #&,645/'054 51 5*' /#%*+0' 4512 '0)+0' #0& 3'/17' -': (31/ 5*' 48+5%* +) %15)#% !)1 #+%!-%1 &.!, /1% #+%!-%1 !&3%1 %5%18 ./%1!3)-' (.412 !-$ !)1 #+%!-%1 #!131)$'% !&3%1 %5%18 ./%1!3)-' (.412 .1% &1%04%-3 #+%!-)-' )2 1%04)1%$ 6(%- ./%1!3)-' )- $4238 .1 $)138 #.-$)3).-2 %+%!2% +.#*)-' #+)/2 !-$ 1%,.5% !)1 #+%!-%1 #.5%1 +%!- #.5%1 3(.1.4'(+8 (!-'% .
! " ! ! !! ! ,* # 0./$0 2'0.22+$ ./$0 2(.- (1 #$/$-#$-2 3/.- /0./$0 #)312,$-2 .% 2'0.22+$ ".-20.+ $%.0$ #)312(-& 2'$ " 0!30$2.0 1130$ 2'$ 2'0.22+$ ".-20.+ (1 ./$0 2(-& /0./$0+7 ..1$- " !+$ "+ ,/ 1"0$5 1$"30(-& " !+$ 2. $-&(-$ .4$ 0$,.2$ 2'0.22+$ ".-20.+ +$4$0 %.05 0# 2. /.1(2(.- 3++ %(0,+7 .- 2'0.22+$ " !+$ 3-2(+ ! "* .% 15(4$+ ".-2 "21 12.
" ! # ! ,* Replace spark plugs after every 800 operating hours. Recommended air gap is 7.5 mm (0.030"). Correct spark plug to use is a Champion RC 12YC. 15( The spark plug usually lasts a long time; however, the plug should be removed and checked whenever the engine malfunctions. Clean area around spark plugs so foreign matter cannot fall into cylinder when spark plug is removed. " " With the parking brake released, the drive wheels must rotate freely.
''+ & '+ $ %(+ & +$! , % -( , '+ / 1 *'% , !$, * ''+ & " % &-,+ & "-+, $ , & *! , +, *!& +,'(+ ,' $$'/ %% !& $ * & '* +, *!& *% !& -$$ $ , & -$$ *! , ,-*& ! , & " % &-,+ *( !, , % !& '& $ . $ +-* & ( *#!& * # !+ & , % !& %-+, &', * ( / & ,* ,!'& ( $ !+ * $ + !, ' + * ( & "-+,% &, !+ * )-!* *(52& 5&- '*-4&2 5&- -*/& 03& $-".
! ! +) $! (10 $ %/ &1/0! 0+ !*/1.! ,.+,!. !*# #!)!*0 * . '%*# 0%+* %/!*# #! 0$! /3%0 $ /!0 0$! , .'%*# . '! * 01.* 0$! %#*%0%+* '!5 0+ 6 0+ /0+, 0$! !*#%*! !)+2! 0$! '!5 &1/0 (10 $ 5 0%#$0!*%*# +. (++/!*%*# 0$! (+ ' *10/ +* "( *#! /01 / $! ' &1/0)!*0 5 %*/!.0%*# "!!(!. # 1#! 0$.1 /(+0/ *!40 0+ /01 / $! ,.+,!. %/!*# #! (! . * ! !03!!* 0$! (10 $ ,( 0!/ %/ 7 )) %* 0 3%(( ! *! !// .5 0+ $! ' 0$%/ (! .
MAINTENANCE CHANGING HYDRAULIC OIL FILTER ADJUSTING CUTTING UNIT BELTS (Fig. 76) (Fig. 79) The hydraulic oil filter keeps the hydraulic system relatively free of contaminants. However, the hydraulic oil filter must be serviced at regular intervals. The intervals are: initially, after the first 8 hours of operation, and thereafter every 200 hours of operation or yearly, whichever comes first. Use a genuine TORO oil filter for replacement. 1. Remove hydraulic oil filter from mounting head.
% ".00.1(.- .""301 2 2$0,(- +1 #(1".--$"2 " !+$1 -$& 2(4$ " !+$ %(012 -# 1"0 /$ "+ ,/1 -# 2$0,(- +1 1$/ 0 2$+6 $".--$"2 " !+$1 /.1(2(4$ " !+$ %(012 -# ". 2 2$0,(- +1 5(2' /$20.+$3, )$++6 0$4$-2 ".00.1(.- .% 5(0(-& 2$0,(- +1 !6 //+6(-& 0 %. *(-8.4$0 &0$ 1$ .0. 02 . 8 2. 2'$ (-1(#$ .% ++ ' 0-$11 ".--$"2.01 5'$-$4$0 2'$ ' 0-$11 (1 0$/+ "$# '$-$4$0 5.0*(-& 5(2' 2'$ $+$"20(" + 1612$, +5 61 #(1".
" !'! #!! " "& " " "& $( % "& " " $# '$ "& " " "& $( $( Check Battery Fluid/Connections Lubricate Grease Fittings Every 25hrs Every 50hrs Every 100hrs Every 200hrs Every 400hrs Every 800hrs { Change Engine Oil Service Air Filter Pre Cleaner { Check Cutting Belt Tension Service Air Filter Cartridge { Change Engine Oil Filter { Torque Wheel Lug Nuts Replace Fuel Filter { Replace Hydraulic Filter Adjust Electric Clutch { Change Hydraulic Fluid
_ _ ! "$ ! ! "$ !" # " ! " ! #
The Toro Commercial Products Two Year Limited Warranty The Toro Company warrants your 1996 or newer Toro Commercial Product (Product") purchased after January 1, 1997, to be free from defects in materials or workmanship for the period of time listed below. Where a warrantable condition exists, Toro will repair the Product at no cost to you including diagnosis, labor, parts, and transportation. This warranty begins on the date the Product is delivered to the original retail purchaser.
