Service Manual

Reelmaster 5200-D/5400-D Page 5 - 1 Electrical Systems (Rev. D)
Chapter 5
Electrical System
Table of Contents
Note: For Electrical Schematics, and Electrical Harness and Connectors Drawings,
see Chapter 10 “Electrical Diagrams” in this manual.
SPECIAL TOOLS 2. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TROUBLESHOOTING 4. . . . . . . . . . . . . . . . . . . . . . . . .
Quick Reference Troubleshooting Guide 4. . . . . . .
Diagnostic Light 4. . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnostic Ace Display 4. . . . . . . . . . . . . . . . . . . . .
Check Interlock Switches 5. . . . . . . . . . . . . . . . . . .
Verify Interlock Switches 5. . . . . . . . . . . . . . . . . . . .
Verify Output Functions 5. . . . . . . . . . . . . . . . . . . . .
Retrieving Stored Faults 6. . . . . . . . . . . . . . . . . . . .
Clearing Fault Memory 6. . . . . . . . . . . . . . . . . . . . .
Starting Problems 7. . . . . . . . . . . . . . . . . . . . . . . . . . .
General Run & Transport Problems 8. . . . . . . . . . . .
Cutting Unit Operating Problems 8. . . . . . . . . . . . . .
TurfDefender
TM
Leak Detector 10. . . . . . . . . . . . . .
TurfDefender
TM
Leak Detector Wiring Diagram 13
ELECTRICAL SYSTEM QUICK CHECK 14. . . . . . . .
Battery Test (Open Circuit) 14. . . . . . . . . . . . . . . . . .
COMPONENT TESTING 15. . . . . . . . . . . . . . . . . . . . . .
Ignition Switch 15. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Glow and Start Relays 16. . . . . . . . . . . . . . . . . . . . . .
Fuses 17. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hydraulic Valve Solenoids 18. . . . . . . . . . . . . . . . . . .
High Temperature Warning and
Shutdown Switch 19. . . . . . . . . . . . . . . . . . . . . . . . .
Warning Light Cluster 20. . . . . . . . . . . . . . . . . . . . . . .
Fuel Stop Solenoid (Solenoid With 3 Wire
Connector) 21. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Stop Solenoid (Solenoid With 2 Wire
Connector) 22. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Sender 23. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Gauge 24. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Temperature Sender 25. . . . . . . . . . . . . . . . . . . . . . . .
Temperature Gauge 26. . . . . . . . . . . . . . . . . . . . . . . .
Hour Meter 27. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Electronic Control Unit (ECU) 27. . . . . . . . . . . . . . . .
Parking Brake Switch 27. . . . . . . . . . . . . . . . . . . . . . .
Traction Speed Sensor 28. . . . . . . . . . . . . . . . . . . . .
Speedometer 29. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Reels Enable/Disable and Backlap Switches 30. . .
Traction Neutral Switch 31. . . . . . . . . . . . . . . . . . . . .
Seat Sensor 31. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Joystick Raise and Lower/Mow Switches 32. . . . . .
Front Reels Down Sensor 32. . . . . . . . . . . . . . . . . . .
SERVICE AND REPAIRS 33. . . . . . . . . . . . . . . . . . . . .
Battery Storage 33. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery Care 33. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery Service 34. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Traction Speed Sensor Replacement 37. . . . . . . . .
Electrical
System