Service Manual

Electrical
System
Reelmaster 5500-D Page 5 - 1 Electrical System (Rev. C)
Chapter 5
Electrical System
Table of Contents
ELECTRICAL SCHEMATICS, AND ELECTRICAL
HARNESS AND CONNECTORS DRAWINGS 2. . .
SPECIAL TOOLS 3. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TROUBLESHOOTING 5. . . . . . . . . . . . . . . . . . . . . . . . .
Quick Reference Troubleshooting Guide 5. . . . . . .
Diagnostic Light 5. . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnostic Ace Display 5. . . . . . . . . . . . . . . . . . . . .
Check Interlock Switches 6. . . . . . . . . . . . . . . . . . .
Verify Interlock Switches 6. . . . . . . . . . . . . . . . . . . .
Verify Output Functions 6. . . . . . . . . . . . . . . . . . . . .
Retrieving Stored Faults 7. . . . . . . . . . . . . . . . . . . .
Clearing Fault Memory 7. . . . . . . . . . . . . . . . . . . . .
Starting Problems 8. . . . . . . . . . . . . . . . . . . . . . . . . . .
General Run & Transport Problems 9. . . . . . . . . . . .
Cutting Unit Operating Problems 9. . . . . . . . . . . . . .
TurfDefender
TM
Leak Detector 11. . . . . . . . . . . . . . .
TurfDefender
TM
Leak Detector Wiring Diagram 14
ELECTRICAL SYSTEM QUICK CHECK 15. . . . . . . .
Battery Test (Open Circuit) 15. . . . . . . . . . . . . . . . . .
COMPONENT TESTING 16. . . . . . . . . . . . . . . . . . . . . .
Ignition Switch 16. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Glow and Start Relays 17. . . . . . . . . . . . . . . . . . . . . .
Fuses 18. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hydraulic Valve Solenoids 19. . . . . . . . . . . . . . . . . . .
High Temperature Warning and
Shutdown Switch 20. . . . . . . . . . . . . . . . . . . . . . . . .
Warning Light Cluster 21. . . . . . . . . . . . . . . . . . . . . . .
Run (ETR) Solenoid (Solenoid With 3 Wire
Connector) 22. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Run (ETR) Solenoid (Solenoid With 2 Wire
Connector) 23. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Sender 24. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Gauge 25. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Temperature Sender 26. . . . . . . . . . . . . . . . . . . . . . . .
Temperature Gauge 27. . . . . . . . . . . . . . . . . . . . . . . .
Hour Meter 28. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Electronic Control Unit (ECU) 28. . . . . . . . . . . . . . . .
Parking Brake Switch 28. . . . . . . . . . . . . . . . . . . . . . .
Traction Speed Sensor 29. . . . . . . . . . . . . . . . . . . . .
Speedometer 30. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Reels Enable/Disable and Backlap Switches 31. . .
Traction Neutral Switch 32. . . . . . . . . . . . . . . . . . . . .
Seat Sensor 32. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Joystick Raise and Lower/Mow Switches 33. . . . . .
Front Reels Down Sensor (Serial Number
Below 230000000) 34. . . . . . . . . . . . . . . . . . . . . . .
Front Reels Down Switch (Serial Number
230000001 and Above) 34. . . . . . . . . . . . . . . . . . .
SERVICE AND REPAIRS 35. . . . . . . . . . . . . . . . . . . . .
Battery Storage 35. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery Care 35. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery Service 36. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Traction Speed Sensor Replacement 39. . . . . . . . .