Service Manual

Hydraulic
System
Reelmaster 5500-D Hydraulic System (Rev. C)Page 4 - 1
Chapter 4
Hydraulic System
Table of Contents
Note: For hydraulic steering cylinder and valve information, see Chapter 7 “Steering and Brakes” in this manual.
SPECIFICATIONS 2. . . . . . . . . . . . . . . . . . . . . . . . . . . .
GENERAL INFORMATION 3. . . . . . . . . . . . . . . . . . . . .
Hydraulic Hoses 3. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hydraulic Fitting Installation 3. . . . . . . . . . . . . . . . . . .
Towing Traction Unit 5. . . . . . . . . . . . . . . . . . . . . . . . .
Check Transmission Fluid 6. . . . . . . . . . . . . . . . . . . . .
Check Hydraulic Fluid 6. . . . . . . . . . . . . . . . . . . . . . . .
HYDRAULIC SCHEMATICS 8. . . . . . . . . . . . . . . . . . . .
RM 5500-D Hydraulic Transmission 8. . . . . . . . . . . .
RM 5500-D Hydraulic System (Serial Number
Below 220000000) 9. . . . . . . . . . . . . . . . . . . . . . . . .
RM 5500-D Hydraulic System (Serial Number
Above 220000000) 10. . . . . . . . . . . . . . . . . . . . . . . .
HYDRAULIC FLOW DIAGRAMS 12. . . . . . . . . . . . . . .
Traction Circuit 12. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lower Cutting Units 14. . . . . . . . . . . . . . . . . . . . . . . . .
Raise Cutting Units 16. . . . . . . . . . . . . . . . . . . . . . . . .
Mow and Backlap 18. . . . . . . . . . . . . . . . . . . . . . . . . . .
Right and Left Turns 20. . . . . . . . . . . . . . . . . . . . . . . .
SPECIAL TOOLS 22. . . . . . . . . . . . . . . . . . . . . . . . . . . .
TROUBLESHOOTING 24. . . . . . . . . . . . . . . . . . . . . . . .
TESTING 27. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Precautions for Hydrostatic Testing 27. . . . . . . . . . . .
Test No. 1: Traction Circuit Charge Pressure 28. . .
Test No. 2: Traction Circuit System
Relief Pressure 29. . . . . . . . . . . . . . . . . . . . . . . . . .
Test No. 3: Relief Valve (R1) and (R2) Pressure 30.
Test No. 4: Gear Pump Section (P1 & P2)
Flow 31. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Test No. 5: Reel Drive Motor Cross-over
Relief Pressure 32. . . . . . . . . . . . . . . . . . . . . . . . . . .
Test No. 6: Reel Drive Motor Efficiency 34. . . . . . . .
Test No. 7: Gear Pump Section (P3) Flow and
Relief Valve Pressure 36. . . . . . . . . . . . . . . . . . . . . .
ADJUSTMENTS 37. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adjust Manifold Relief Valve (R1 and R2) 37. . . . . .
Adjust Traction Drive for Neutral 38. . . . . . . . . . . . . .
Adjust Cutting Unit Drop Rates 39. . . . . . . . . . . . . . .
Adjust Traction Control Linkage 40. . . . . . . . . . . . . . .
SERVICE AND REPAIRS 41. . . . . . . . . . . . . . . . . . . . .
General Precautions for Removing and
Installing Hydraulic System Components 41. . .
Check Hydraulic Lines and Hoses 42. . . . . . . . . . . . .
Flush Hydraulic System 42. . . . . . . . . . . . . . . . . . . . . .
Charge Hydraulic System 43. . . . . . . . . . . . . . . . . . . .
Change Hydraulic Fluid 44. . . . . . . . . . . . . . . . . . . . . .
Replace Hydraulic Oil Filter 45. . . . . . . . . . . . . . . . . .
Replace Transmission Fluid 46. . . . . . . . . . . . . . . . . .
Replace Transmission Filter 46. . . . . . . . . . . . . . . . . .
Transmission Control Linkage 47. . . . . . . . . . . . . . . .
Transmission 48. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Transmission Service 52. . . . . . . . . . . . . . . . . . . . . . .
Disassembly 53. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inspection 57. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Assembly
57. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Shaft Seal Replacement 63. . . . . . . . . . . . . . . . . . . .
Trunnion Seal Replacement 64. . . . . . . . . . . . . . . . .
High Pressure Relief/Check Valve
Replacement 65. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Charge Pressure Relief Valve Replacement 66. . .
Heat Exchanger By-Pass Valve
Replacement 67. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Filter By-Pass Valve Replacement 68. . . . . . . . . . . .
Filter Reverse Flow Check Valve Replacement 68.
Charge Pump Replacement 69. . . . . . . . . . . . . . . . .
Gear Pump 70. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gear Pump Service 72. . . . . . . . . . . . . . . . . . . . . . . . .
Shaft Seal Replacement 73. . . . . . . . . . . . . . . . . . . .
Section Seal Replacement 73. . . . . . . . . . . . . . . . . .
Relief Valve Service 73. . . . . . . . . . . . . . . . . . . . . . . .
Reel Motor Service 74. . . . . . . . . . . . . . . . . . . . . . . . . .
Removal 74. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 74. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adjusting Valve (Cross-over Relief Valve)
Service 75. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Disassembly 75. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Seal Replacement (Motor Disassembled) 75. . . . .
E-seal Replacement 75. . . . . . . . . . . . . . . . . . . . . . . .
O-ring Replacement 75. . . . . . . . . . . . . . . . . . . . . . . .
Reassembly 76. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hydraulic Control Manifolds 78. . . . . . . . . . . . . . . . . .
Reel Manifold Removal and Installation 78. . . . . . .
Lift Manifold Removal and Installation 79. . . . . . . . .
Hydraulic Control Manifold Service 80. . . . . . . . . . . .
Solenoid Operated Cartridge Valves 82. . . . . . . . . .
Relief Cartridge Valves 82. . . . . . . . . . . . . . . . . . . . . .
Rotary Cartridge Valves 83. . . . . . . . . . . . . . . . . . . . .
Logic Cartridge 84. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Flow Divider 85. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lift Cylinders 86. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lift Cylinder Service 88. . . . . . . . . . . . . . . . . . . . . . . . .
Hydraulic Reservoir 90. . . . . . . . . . . . . . . . . . . . . . . . .
Hydraulic Oil Cooler & Transmission
Heat Exchanger 92. . . . . . . . . . . . . . . . . . . . . . . . .