Installation Instructions

ManualsBrandsToro ManualsAttachmentsGrass Basket Kit, Reelmaster 5010 Series 5in and 7in Cutting Units

Table Of Contents

FormNo.3386-464RevB

GrassBasketKit

ForReelmaster

5010SeriesCuttingUnitswith5inand7inReels

ModelNo.03662

InstallationInstructions

Installation

LooseParts

Usethechartbelowtoverifythatallpartshavebeenshipped.

ProcedureDescription

Qty.

Use

Cylindercollar

Bolt4

Flangedlocknut8

Spacer

Stopbracket

Carriagebolt

Installtherearliftcylinderlimitkit

(orderedseparately).

Basketguide1

Basketbracket1

Rollpin1

Washer1

Left-handtorsion-spring(gold)

Right-handtorsion-spring(black)

Basketcollar1

Flatwasher(0.344x0.875)

Bolt(5/16x1–1/4inch)

Bolt(5/16x1/2inch)

Plasticwasher1

Installthebasketguidesandbrackets.

Cut-offbar

Bolt(1/4x1–3/4inches)

Locknut(1/4inch)

Installthecut-offbar.

Nopartsrequired

–

Removethe4grassdeectors.

Flangedlocknut2

Removethesupporttube(for5–inch

diameterreelsonly).

Basketassembly1

Mountthebasketassemblytothe

cuttingunit.

Nopartsrequired

–

Adjustthebasketposition.

Important:Togainadditionalclearancefortherearbasketswhenraisingthecuttingunits,installtheRearLift

CylinderLimitKit.

8111LyndaleAvenueSouth

Bloomington,MN55420

Registeratwww.T oro.com.

OriginalInstructions(EN)

PrintedintheUSA

AllRightsReserved

*3386-464*B

Summary of content (8 pages)

PAGE 1
Form No. 3386-464 Rev B Grass Basket Kit For Reelmaster® 5010 Series Cutting Units with 5in and 7in Reels Model No. 03662 Installation Instructions Installation Loose Parts Use the chart below to verify that all parts have been shipped. Procedure Description Qty. Use Cylinder collar Bolt Flanged locknut Spacer Stop bracket Carriage bolt Basket guide Basket bracket Roll pin Washer Left-hand torsion-spring (gold) Right-hand torsion-spring (black) Basket collar Flat washer (0.344 x 0.
PAGE 2
over the top of the cylinder and the spacer is flush with the cylinder end. 1 3. Loosely install the stop bracket to the deflector bracket with 2 carriage bolts and 2 locknuts (Figure 1). Installing the Rear Lift Cylinder Limit Kit (Ordered Separately) 4. Move the stop bracket to the lowest position on the bracket and tighten the flange locknuts (Figure 1).
PAGE 3
1/2 inch) and flat washer (0.344 x 0.875). Position the components as shown in Figure 3. 2 Installing the Basket Guides and Brackets Parts needed for this procedure: 1 Basket guide 1 Basket bracket 1 Roll pin 1 Washer 1 Left-hand torsion-spring (gold) 1 Right-hand torsion-spring (black) 1 Basket collar 2 Flat washer (0.344 x 0.875) 1 Bolt (5/16 x 1–1/4 inch) 1 Bolt (5/16 x 1/2 inch) 1 Plastic washer Figure 3 1. Carrier frame 3. Flat washer (0.344 x 0.875) 2. Basket guide 4.
PAGE 4
and the shorter, rear leg of the spring is to be inserted into the hole in the basket bracket. 4 6. Check if the bracket basket rotates freely. Important: The plastic washer must be installed onto the basket collar to prevent binding. Removing the 4 Grass Deflectors 3 No Parts Required Procedure Installing the Cut-off Bar 1. Remove the 4 flange-head bolts securing the front grass-shield to the cutting-unit frame (Figure 5). Remove the grass shield.
PAGE 5
6 Mounting the Basket Assembly to the Cutting Unit Parts needed for this procedure: 1 Basket assembly Procedure Figure 6 1. Support tube 3. Flange-head bolt 2. Carrier frame 4. Flanged locknut (3/8 inch) Mount a basket to each cutting-unit carrier-frame by inserting the basket-mounting pin into the basket-guide bracket and depressing the opposite mounting pin into the pivoting-basket bracket (Figure 7). 2.
PAGE 6
7 Adjusting the Basket Position No Parts Required Procedure Make sure that the basket is parallel to the cutting unit with a minimum clearance of 6 mm (0.250 inches) between the lip of the basket and the reel. If an adjustment to the basket position is required, proceed as follows: 1. On each side of the basket, loosen the carriage bolt nuts securing the basket-stop brackets to the basket (Figure 8). Figure 8 1. 0.250 clearance 2. Basket-stop bracket 4. Carrier-frame arm 5. Contact point 3. Basket 2.
PAGE 7
Notes: 7
PAGE 8