/ !2241% -!7)-4- 2!&%38 /03)-4- 0%1&/1-!.#% !.$ 3/ '!). +./6,%$'% /& 3(% 01/$4#3 )3 )2 %22%.3)!, 3(!3 8/4 /1 !.8 /3(%1 /0%1!3/1 /& 3(% -!#().% 1%!$ !.$ 4.$%123!.$ 3(% #/.3%.32 /& 3()2 -!.4!, "%&/1% 3(% %.').% )2 %5%1 23!13%$ !8 0!13)#4,!1 !33%.3)/. 3/ 3(% ()'(,)'(3%$ "8 3()2 28-"/, (% #/.&/1-2 3/ 3(% -%1)#!. !3)/.!, 3!.$!1$2 .23)343% 2 2!&%38 23!.$!1$2 &/1 1)$).
(% 7!3 $%6%,/0%$ 4/ 02/6)$% !. %&&)#)%.4 42/5",% &2%% !.$ 4)-% 3!6).' -%4(/$ /& -/7).' ()'( 15!,)49 452& /. 4(% &).%34 '2%%.3 (% ,!4%34 #/.#%043 ). %.').%%2).' $%3)'. !.$ 3!&%49 (!6% "%%. ).#/20/2!4%$ ).4/ 4()3 -!#().% !,/.' 7)4( 4(% ()'(%34 15!,)49 0!243 !.$ 7/2+-!.3()0 8#%,,%.4 3%26)#% 7),, "% $%2)6%$ )& 02/0%2 /0%2!4)/. !.$ -!).4%.!.#% 02!#4)#%3 !2% &/,,/7%$ % +./7 3).#% 9/5 (!6% 052#(!3%$ 4(% ).$53429 ,%!$%2 ). -/7).' %8#%,,%.#% 4(!4 &5452% 0%2&/2-!.#% !.$ $%0%.
. . . . . . . . . . . . . . . . . . . . 3-5 . . . . . . . . . 6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 . . . . . . . . . . . . . . . . . . . . . . 9 Install Front Wheels . . . . . . . . . . . . . . . . . . . . . . . . . 9 Install Rear Wheel . . . . . . . . . . . . . . . . . . . . . . . . 9 Mount Seat . .
# ! +( 5$)(6: $/(46 5:0%2/ 0($15 ! " 24 < = ;3(4521$/ 5$)(6: ,15647&6,21 ($' $1' 71'(4 56$1' 6+( ,15647&6,21 %(&$75( ,6 +$5 62 '2 9,6+ 5$)(6: $,/74( 62 &203/: 9,6+ 6+( ,15647&6,21 0$: 4(57/6 ,1 3(4521$/ ,1-74: Hazard control and accident prevention are dependent upon the awareness, concern, and proper training of the personnel involved in the operation, transport, maintenance, and storage of the machine.
!% ! " ! If a cutting unit strikes a solid object or vibrates abnormally, stop immediately, turn engine off, wait for all motion to stop and inspect for damage. A damaged reel or bedknife must be repaired or replaced before operation is continued. Before getting off the seat: A. Make sure cutting units are disengaged. B. Verify that functional control system is in neutral. C. Set the parking brake. D. Stop the engine and remove key from ignition switch. Traverse slopes carefully.
! / -002 -"4& "24 0 / &"4 "$, "24 0 / 2".& 2033 5#& "24 0 / "44&27 "3& "24 0 / 4&&2*/( 2.
$! # Tricycle vehicle with two front wheels providing drive and one rear wheel providing steering. Operator sits in center over #1 cutting unit with #2 and #3 cutting units in front of vehicle. !# # Certified to meet ANSI specification B7 1.4-1 990 and European CE standards. : Perkins 103-07 three cylinder water cooled engine. 41.3 cu. in. (676 cc) Full pressure lubrication, oil filter. 17.0 hp at 3600 rpm, 13.2 hp at 2600 rpm.
" ! Width of Cut: 59.0 in. (150 cm) Wheel Tread: 49.9 in. (127 cm) Wheel Base: 47.6 in. (121 cm) Overall Length (w/baskets) 92.4 in. (235 cm) Overall Width: 68.0 in. (173 cm) Overall Height: 50.5 in. (128 cm) Weight w/reels (8 Blade 4 Bolt):1,358 lbs.
! (.'- +('- 0! %, ' -(+*. &(.'-"' '.-, -( - % , ! +) &(/ 0! % (%- ' %( $'.- +(& 0! % &(.'!(% , "' + + ,-(+ (+$ ',- %% + + 0! % "'-( ,-(+ (+$ ', +- 0! % (%"'-( (' ( -! ,-(+ (+$ &(.'-"' !(% "',- %% ,) + ,.))%" "' %((, ) +-, ' ,%" -! (%-!+(. ! -! 0! % ',- %% '(-! + ,) + ('-( -! (%- ' +(.- -! (%- -!+(. ! -! + & "'"' ,-(+ (+$ &(.
SET UP INSTRUCTIONS 4. # (( &- ' & ' $## ( & & &$" ! (& ! $)(! ( # (( &- %$'(' 5. "$* !! & %' !$+!- ! (&$!-( ($ !! )#( ! ! * ! ' )% ($ !! & # #'( !! !! & %' 3. #'( !! % ($ '( & # + ! + ( ' & +' INSTALL CONTROL LEVER KNOB (Fig. 5) 1. & $#(&$! #$ $#($ ! * & IMPORTANT Do not overfill battery. Electrolyte will overflow onto other parts of the machine and severe corrosion and deterioration will result. 6.
(&1.$ ,1+0$. 3$(&'0 + - .(+& .(2$ ",1-)$. Slide the cutting unit under the pull frame while hooking the lift roller onto lift arm (Fig. 9). (&1.$ ..($. %. *$ .,))$. 0,- /".$3 If an adjustment is required, loosen jam nut on carrier frame stop screw and rotate screw up or down to raise or lower carrier frame. Tighten jam nut after adjustment is attained. Mount traction unit pull frame to cutting unit with (2) shoulder bolts.
! " ! " ! * / /$! .+'%)! .$ "/ *" /$! (*/*- 2%/$ '! ) #-! .! ) %)./ '' /$! (*/*- 4 -*/ /%)# /$! (*/*- '* &2%.! .* /$! (*/*- "' )#!. '! - /$! ./0 . */ /! /$! (*/* *0)/!- '* &2%.! 0)/%' /$! "' )#!. -! !) %- '%)# /$! ./0 . ) /%#$/!) /$! (*0)/%)# +. -!2. %# '% ! .&!/. *)/* +0'' "- (!. *(52& #13$2&73 2*6& .
+) " '!#' +.', (' ( # , % . % . % - '$ ) #-2 #, ))+(1#& - %2 ! %%(', % ' + +(.' . % - '$ ) +)52' 5'- 4#/, %#1 +)52' #&+#402 3%2''/ #&+#402 &(/ . % - '$ ) '%#53' &+'3'- (5'- +3 (-#..#$-' 53' %#54+0/ 7*'/ 3402+/) 02 *#/&-+/) +4 0 /04 3.0,' 7*+-' (+--+/) 4*' (5'- 4#/, 0 /04 (+-- (5'- 4#/, 7*+-' '/)+/' +3 25//+/) *04 02 7*'/ .
! $ " $ ! " -+ The hydraulic system is designed to operate on anti-wear hydraulic fluid. The machines reservoir is filled at the factory with approximately 5.5 gallons (20.8 L) of Mobil 424 hydraulic fluid. ,)'.
! ' % , # * ,+ & &- #+ ) ' % # * ) . &% #+ ) $&,%+ % ##&. % &.# +& ) ## . + , # #&* # * ) . ,*85( ;'5$8/,& 5(6(592,5 &$3 &5((1 ! " ! ,* %*' + , # #+ ) &.# #/ &) . + ) &) &+ ) &%+ $ % %+* . + ) &) &+ ) &%+ $ % %+* ) ') * %+ + / $,*+ ) $&- &) &$$ % % &' ) + &% #&* , # * ,+ & &- #+ ) %* ) . %,+ * ,) % &.# +& #+ ) $&- .
. "0',+ $# ) )' 1!#3)/. 0%$!, (!2 3(1%% &4.#3)/.2 /.% 3/ -!+% 3(% -!#().% -/5% &/16!1$ 36/ 3/ -/5% )3 "!#+6!1$ !.$ 3(1%% 3/ 23/0 -!#().% %01%22 3/0 /& 0%$!, 3/ -/5% &/16!1$ !.$ "/33/- /& 0%$!, 3/ -/5% "!#+6!1$ /1 3/ !22)23 ). 23/00).' 6(%. -/5).' &/16!1$ ,2/ !,,/6 0%$!, 3/ -/5% 3/ .%431!, 0/2)3)/. 3/ 23/0 -!#().% /1 /0%1!3/1 #/-&/13 $/ ./3 1%23 (%%, /& &//3 /. 1%5%12% 6(%. /0%1!3).' &/16!1$ )' 1+"0',+ ) ,+0.,) $2$. )' 1/5)$%2 36/ 31!#3)/.
(*/ (.# ) % -*+ %#$- ! & % ") # ' % $ "! ! & --!+0 +)%)# %#$- & ")% && $* $ % ") + "% ' % '& " ( ( % '! $ ' & ! ! "( ' & $ ) ! %&"$ ! ! %( +!,,.
" !" # " ! +)6 %,2/0 ,# *,4&+$ ,-"/ 1&,+ &0 /".2&/"! #,/ 1%" /""+0* 01"/ /" ( &+ -"/&,! &+ " 1%" #&/01 %,2/0 ,# ,-"/ 1&,+ /" /&1& ) 1, #212/" !"-"+! &)&16 ,# 1%" * %&+" *,+&1,/ &10 #2+ 1&,+0 +! -"/#,/* + " ),0")6 0, 1% 1 *&+,/ !#& 2)1&"0 4%& % ,2)! )" ! 1, * ',/ -/, )"*0 /" +,1"! +! + " ,//" 1"! +0-" 1 1%" /""+0* 01"/ #/".
! ' *(', ( ' "' 1 ("% "%, * %( , ,* '+ * )-&) "'% , + * / (, ' % ( ",,"' (' ,* '+ * )-&) "'% , ' %((+ ' + * / % , + * / ('%1 ) % ! ) % +!(-% '(, )* ++ /!" ! & '+ ,! "', *%( $ +1+, & "+ () * ,"' (** ,%1 (** , )*( % & " '(, () * ,"' )*() *%1 ! ' +, 1 +,* & ( - % %(/+ (-, ( ,* '+ * )-&) + * / ," !, ' + * / * , "'"' ' % ( ",,"' (* %((+ '"' ", (' ,! + , ' ) *$"' * $ ,* ,"(' ) % "' ' -,* % -' ,"('
Actuate the raise/lower-mow lever as the front edge of the grass baskets cross the outer edge of the green. This procedure drops the cutting units to the turf and starts the reels. '%1.# ('%*)#*0 /0.', ,,.+3 '* 10 %. // +* .'%&0 ##, $+! ( /,+0 $0 " +$ ) !&'*# )'(' .'5# 4+1./#($ 2'0& 0 $ !0 0& 0 0 + !100'*% 1*'0 .##( '/ "#( 4#" 2* (+2#.'*% *" . '/'*% 0.#$+.# 4+1 /&+1(" ,. !0'!# 0+ 0.4 0+ % '* 0 .#-1'.
10 +3* +* +,!. 0%*# 0%)! * ! /! (%*!1, "+. 0$! *!40 , // 5 )+)!*0 .%(5 01.*%*# 0$! ) $%*! %* +,,+/%0! %.! 0%+* 0$!* 01.*%*# %* 0$! %.! 0%+* +" 0$! 1* 10 ,+.0%+* % ! %" %*0!* %*# 0+ 01.* .%#$0 "%./0 /3%*# /(%#$0(5 (!"0 0$!* .%#$0 $%/ 3%(( //%/0 %* #!00%*# 0$! ) $%*! )+.! -1% '(5 (%#*! "+. 0$! *!40 , // +((+3 0$! / )! ,.+ ! 1.! "+. 01.*%*# %* 0$! +,,+/%0! %.! 0%+* 0 / #++ ,. 0% ! 0+ 0.5 0+ ) '! / /$+.0 01.* / ,+//% (! +3!2!. 01.* %* 3% !. . 1.%*# 3 .)!.
($ ' ' & $ #% %#(' " (& Daily Maintenance Check For Week Of ___________ Maintenance Ch k Item Check I MON Safety Interlock Operation Instrument Operation Brake Operation Fuel Level Engine Oil Level TUES WED THURS FRI SAT SUN Clean Screen and Radiator Inspect Air Filter Unusual Engine Noises Hydraulic Hoses for Damage Fluid Leaks Tire Pressure Reel–to–Bedknife Adjustment Height–of–Cut Adjustment L
"$ % $( ! "$ ! '%& !&% &" & ! %&"# ! ! ! $ "( * $" & %) & (% 20!#2)-, 3,)2 (!1 '0%!1% &)22),'1 2(!2 +312 "% *3"0)#!2%$ 0%'3*!0*7 5)2( - %,%0!* 30.-1% )2()3+ !1% 0%!1% & +!#(),% )1 -.%0!2%$ 3,$%0 ,-0+!* #-,$)2)-,1 *3"0)#!2% !** "%!0),'1 !,$ "31(),'1 !&2%0 %4%07 (-301 -& -.
!"+-! .!-1% %*# +- ) '%*# &0./)!*/. /+ /$! ) $%*! ./+, !*#%*! * -!)+1! '!3 "-+) /$! .2%/ $ # % $, & ( , ) 3 !), ' " 1#$ # )/& *)--$ &3 /- ( $, & % *& ' " $, & ( , ) 3 ,0$ .# $, & ( , !$&. , 0 ,3 #)/,- '), !, +/ (.&3 $( 2., ' /-.3 ), $,.3 )( $.$)(- %# & - & . # - - /,$(" $, & ( , )0 , .) $, & ( , ) 3 * , .
*( ' ,&$ -(* ,# %(*1$/ (,(1( **5 %1$/ 1'$ %(/01 '-2/0 -% -.$/ 1(-, 1'$/$ %1$/ "' ,&$ -(* $3$/5 '-2/0 ,# %(*1$/ $3$/5 '-2/0 $+-3$ #/ (, .*2& ,# *$1 -(* %*-4 (,1- #/ (, . , '$, -(* 01-.0 (,01 ** #/ (, .*2& *(41& &$"42& %*&2&, '4&, *2 ',"--"#,& 42& $"43*/. 6)&. 23/1*.( /1 )".%,*.( *3 / ./3 2-/+& 6)*,& '*,,*.( 3)& '4&, 3".+ / ./3 '*,, '4&, 3".+ 6)*,& &.(*.& *2 14..*.( )/3 /1 6)&. -"$)*.& *2 *. ". &.$,/2&% "1&" ,6"72 '*,, '4&, 3".
,// 7+( 5(3/$&(0(17 ),/7(5 :,7+ 2%,/ +<'5$8/,& )/8,' /8%5,&$7( 7+( 6($/,1* *$6.(7 $1' +$1' 7851 817,/ *$6.(7 &217$&76 ),/7(5 +($' +(1 7,*+7(1 7851 )857+(5 ,/7(5 6+28/' 12: %( 6($/(' ,// +<'5$8/,& 5(6(592,5 :,7+ $3352;,0$7(/< *$//216 2) +<'5$8/,& 2,/ ()(5 72 # # 7$57 7+( 0$&+,1( $1' 581 ,7 $7 ,'/( )25 72 0,187(6 72 &,5&8/$7( 7+( )/8,' $1' 5(029( $1< $,5 75$33(' ,1 7+( 6<67(0 723 7+( 0$&+,1( $1' 5(&+(&.
.2& & % ! * %&% ) '&$ + $ " ) & ' & ! ! &$! ( $ % !( &! & !) !$ $ %"!$& "!% & ! ! )' % '%& & & &!$+ '& %" + ( $ % $ !!% '& ! &$' ! "% $ ) !!% '& % '$ ! !) $ &% ! " " (!& )'30& 0"$2).- "#+& 3+*(&"% ", -321 $$&-20)$ .
&(! "(312 4 *4#1 5, #,%',# '1 !-*" #2 2 - !7*',"#0 2- 2-.
# / 0 $#16 %-%%*#0 ," /2 #/ %*-3#0 4, 4-/)',% 4'1& #*#!1/-*61# & /%# 1 11#/6 ', 4#** 3#,1'* 1#" .* !# 0- % 0#0 ./-"2!#" 4&'*# !& /%',% ! , "'00'. 1# ',!# 1 % 0#0 /# #5.*-0'3# )##. -.#, $* +# ," #*#!1/'! * 0. /) 4 6 $/-+ 1 11#/6 "- ,-1 0+-)# 20# + 6 /#02*1 '$ 1 % 0#0 /# ',& *#" ,.*2% !& /%#/ $/-+ #*#!1/'! * -21*#1 #$-/# !-,,#!1',% 1- -/ "'0!-,,#!1',% !& /%#/ *# "0 $/-+ 17 1#/6 .-010 !!, 0+, +" 00!.4 (! * 4 3 /$%*# ,!.%+ % ((4 3%0$ .
% + ") ) & ' & # ' ) $! ! & '%& $ ) & ' $ $ & $ % # & $ $ $ $ ! $ ) & * + ") $ "$ ( " & "$ ! "'$ & $ " #$ %%'$ % !%"$ $ ! ' $ $ ( " & $ "$ ! $ ' "$ ! + ") % &+ $ + $ %& $& $ + $ ( " & $ $")! ") $ + "$ * % $ +
!#( # " ) #!$% % !( $ # & " ' ' %# % ! ( !%!#$ #" # ! !! # !"% ! % ! % # % $ " " " !( # $ " !"% ! ' ' $ "% $% # "& " # " # !%!#$ $ " % " # ' # "!( # $% # ' ' ! ! $ # # !( # % & % % " "
(%#+ !44%28 ,5)$ %6%, (%#+ !44%28 !",% /..%#4)/.3 %26)#% )2 ),4%2 5"2)#!4% ,, 2%!3% )44).'3 (!.'% .').% ), (%#+ !. ,4%2.!4/2 %,4 %.3)/. 6%28 (23 6%28 (23 6%28 (23 6%28 (23 6%28 (23 %0,!#% .').% ), ),4%2 %0,!#% )2 ),4%2 ,%-%.4 /215% (%%, 5' 543 %0,!#% 5%, ),4%2 !4%2 %0!2!4/2 /215% %!$3 !.
% ! "% " " # ! # ! # "% # ! !" " " " " ! $ " " " " # ! " & ! " % !# & " ! # ! " !!# " " " " " "! " " & # "! " ! #! #! " " # " "! #" ' $
)& /2/ /--&2$*", 2/%5$43 7/ !&"2 *-*4&% "22".49 )& /2/ /-0".9 7"22".43 9/52 /2 .&7&2 /2/ /--&2$*", 2/%5$4 : 2/%5$4 052$)"3&% "'4&2 ".5"29 4/ #& '2&& '2/- %&'&$43 *. -"4&2*",3 /2 7/2+-".3)*0 '/2 4)& 0&2*/% /' 4*-& ,*34&% #&,/7 )&2& " 7"22".4"#,& $/.%*4*/. &8*343 /2/ 7*,, 2&0"*2 4)& 2/%5$4 "4 ./ $/34 4/ 9/5 *.$,5%*.( %*"(./3*3 ,"#/2 0"243 ".% 42".30/24"4*/. )*3 7"22".49 #&(*.3 /. 4)& %"4& 4)& 2/%5$4 *3 %&,*6&2&% 4/ 4)& /2*(*.", 2&4"*, 052$)"3&2 "22".49 52"4*/.