Operator's Manual

ManualsBrandsToro ManualsAttachmentsTri-Roller, Greensmaster 3300/3400 Series TriFlex Traction Unit

FormNo.3449-667RevA

Tri-Roller

Greensmaster

3300/3400SeriesTriFlex

TractionUnit

ModelNo.04722—SerialNo.408000000andUp

Operator'sManual

Introduction

ThisproductcomplieswithallrelevantEuropean

directives.Fordetails,pleaseseetheDeclarationof

Incorporation(DOI)atthebackofthispublication.

Thisrollerisdesignedformaintainingturfongreens

andsmallfairwaysofgolfcourses.Usingthisproduct

forpurposesotherthanitsintendedusecouldprove

dangeroustoyouandbystanders.

Readthisinformationcarefullytolearnhowtooperate

andmaintainyourproductproperlyandtoavoid

injuryandproductdamage.Youareresponsiblefor

operatingtheproductproperlyandsafely.

Visitwww.Toro.comforproductsafetyandoperation

trainingmaterials,accessoryinformation,helpnding

adealer,ortoregisteryourproduct.

Wheneveryouneedservice,genuineToroparts,or

additionalinformation,contactanauthorizedT oro

distributorandhavethemodelandserialnumbersof

yourproductready.Themodelandserialnumbers

arelocatedonaplateontherearframe.Writethe

numbersinthespaceprovided.

Important:Withyourmobiledevice,youcan

scantheQRcode(ifequipped)ontheserial

numberdecaltoaccesswarranty,parts,andother

productinformation.

g279029

Figure1

1.Modelandserialnumberlocation

Thismanualidentiespotentialhazardsandhas

safetymessagesidentiedbythesafety-alertsymbol

(Figure2),whichsignalsahazardthatmaycause

seriousinjuryordeathifyoudonotfollowthe

recommendedprecautions.

g000502

Figure2

Safety-alertsymbol

Thismanualuses2wordstohighlightinformation.

Importantcallsattentiontospecialmechanical

informationandNoteemphasizesgeneralinformation

worthyofspecialattention.

8111LyndaleAvenueSouth

Bloomington,MN55420

Registeratwww.Toro.com.

OriginalInstructions(EN)

PrintedintheUSA

AllRightsReserved

*3449-667*

Summary of content (8 pages)

PAGE 1
Form No. 3449-667 Rev A Tri-Roller Greensmaster® 3300/3400 Series TriFlex® Traction Unit Model No. 04722—Serial No. 408000000 and Up Operator's Manual Introduction This product complies with all relevant European directives. For details, please see the Declaration of Incorporation (DOI) at the back of this publication. This roller is designed for maintaining turf on greens and small fairways of golf courses.
PAGE 2
Safety Setup General Safety 1 This product is capable of amputating hands and feet. Always follow all safety instructions to avoid serious personal injury. Installing the Tri-Roller Units • Read and understand the contents of this Operator’s Manual before starting the engine. • Do not put your hands or feet near moving components of the machine. No Parts Required • Do not operate the machine without all guards and other safety protective devices in place and working on the machine.
PAGE 3
g018312 Figure 4 1. Suspension-arm bar 4. 2. Tri-roller unit bar Close the latches down and around the tri-roller unit and lock them in place (Figure 3). Note: You will hear and feel a “click” when the latches are properly locked in place. 5. Insert the motor into the left side of the tri-roller unit (as viewed from the operator’s position) and pull the motor retaining bar on the tri-roller unit toward the motor until you hear a “click” from both sides of the motor (Figure 5). g014690 Figure 5 3 1.
PAGE 4
7. 2 Repeat steps 2 through 6 for the other tri-roller units as required. 3 Removing the Tri-Roller Unit Adding Rear Weight No Parts Required Parts needed for this procedure: Procedure 1. 2. 1 Park the machine on a clean level surface, lower the tri-roller units to the ground until the suspension hydraulics are fully extended, shut off the engine, engage the parking brake, and remove the key from the ignition switch.
PAGE 5
Maintenance Preparing for Maintenance Before starting on any maintenance procedure, do the following: 1. Park the machine on a level surface. 2. Lower the roller units fully to the ground so that the suspension hydraulics are fully extended. 3. Engage the parking brake, shut off the engine, and remove the key. Lubricating the Tri-Roller g254873 Lubricate the 2 grease fittings (Figure 8) on each tri-roller unit after every 15 hours of operation, with No. 2 lithium grease.
PAGE 6
Declaration of Incorporation The Toro Company, 8111 Lyndale Ave. South, Bloomington, MN, USA declares that the following unit(s) conform(s) to the directives listed, when installed in accordance with the accompanying instructions onto certain Toro models as indicated on the relevant Declarations of Conformity. Model No. 04722 Serial No.
PAGE 7
EEA/UK Privacy Notice Toro’s Use of Your Personal Information The Toro Company (“Toro”) respects your privacy. When you purchase our products, we may collect certain personal information about you, either directly from you or through your local Toro company or dealer.
PAGE 8
The Toro Warranty Two-Year or 1,500 Hours Limited Warranty Parts Conditions and Products Covered The Toro Company warrants your Toro Commercial product (“Product”) to be free from defects in materials or workmanship for 2 years or 1,500 operational hours*, whichever occurs first. This warranty is applicable to all products with the exception of Aerators (refer to separate warranty statements for these products).