Operator's Manual

2
All Rights Reserved
Printed in the USA
 2003 by The Toro Company
8111 Lyndale Avenue South
Bloomington, MN 55420-1196
CALIFORNIA
Proposition 65 Warning
The engine exhaust from this product contains
chemicals known to the State of California to cause
cancer, birth defects, or other reproductive harm.
Warning
Important The engine in this product is not equipped
with a spark arrester muffler. It is a violation of California
Public Resource Code Section 4442 to use or operate this
engine on any forest-covered, brush-covered, or
grass-covered land as defined in CPRC 4126. Other states
or federal areas may have similar laws.
This spark ignition system complies with Canadian
ICES-002.
Ce système d’allumage par étincelle de véhicule est
conforme à la norme NMB-002 du Canada.
Contents
Page
Contents 2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Introduction 3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety 3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety and Instruction Decals 5. . . . . . . . . . . . . . . .
Specifications 7. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dimensions and Weights (approx.) 7. . . . . . . . . . .
Optional Equipment 7. . . . . . . . . . . . . . . . . . . . . . .
Setup 8. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Remove, Activate And Charge Battery 8. . . . . . . .
Install Battery 8. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mount Sweeper To Prime Mover 9. . . . . . . . . . . . .
Removing Sweeper From Prime Mover 9. . . . . . . .
Page
Before Operating 10. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Check Engine Oil 10. . . . . . . . . . . . . . . . . . . . . . . . .
Fill Fuel Tank 10. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Check Tire Pressure 11. . . . . . . . . . . . . . . . . . . . . . .
Transport Hooks 11. . . . . . . . . . . . . . . . . . . . . . . . . .
Adjust Reel Support Arm 11. . . . . . . . . . . . . . . . . . .
Adjust Rake Depth 12. . . . . . . . . . . . . . . . . . . . . . . .
Adjust Rubber Flap 12. . . . . . . . . . . . . . . . . . . . . . .
Operation 13. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Controls 13. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Starting Instructions 14. . . . . . . . . . . . . . . . . . . . . . .
Stopping Instructions 14. . . . . . . . . . . . . . . . . . . . . .
Operating Tips 14. . . . . . . . . . . . . . . . . . . . . . . . . . .
Inspection And Cleanup After Operation 14. . . . . . .
Maintenance 15. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lubrication 15. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil Sweeper Jack 15. . . . . . . . . . . . . . . . . . . . . . . . .
Changing Engine Oil and Filter 16. . . . . . . . . . . . . .
General Air Cleaner Maintenance 16. . . . . . . . . . . .
Servicing Air Cleaner 16. . . . . . . . . . . . . . . . . . . . . .
Replacing Spark Plugs 17. . . . . . . . . . . . . . . . . . . . .
Removing Debris From Engine 17. . . . . . . . . . . . . .
Replace Fuel Filter 17. . . . . . . . . . . . . . . . . . . . . . . .
Changing Rubber Flap 17. . . . . . . . . . . . . . . . . . . . .
Cleaning Blower Housing 18. . . . . . . . . . . . . . . . . .
Adjusting Belts 18. . . . . . . . . . . . . . . . . . . . . . . . . . .
Pulley Removal 20. . . . . . . . . . . . . . . . . . . . . . . . . .
Flex Tip Reel Removal 20. . . . . . . . . . . . . . . . . . . . .
Thatcher Installation 20. . . . . . . . . . . . . . . . . . . . . . .
Flex Tip Rake Rod Or Finger Plate Replacement 21
Flex Tip Rake Tine Replacement 22. . . . . . . . . . . . .
Brush Half Replacement 22. . . . . . . . . . . . . . . . . . . .
Changing Tires 23. . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery Care 23. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
The Toro General Commercial Products Warranty 24. .