Operator's Manual

2
All Rights Reserved
Printed in the USA
 2002 by The Toro Company
8111 Lyndale Avenue South
Bloomington, MN 55420-1196
CALIFORNIA
Proposition 65 Warning
The engine exhaust from this product contains
chemicals known to the State of California to cause
cancer, birth defects, or other reproductive harm.
Warning
Important The engine in this product is not equipped
with a spark arrester muffler. It is a violation of California
Public Resource Code Section 4442 to use or operate this
engine on any forest-covered, brush-covered, or
grass-covered land as defined in CPRC 4126. Other states
or federal areas may have similar laws.
This spark ignition system complies with Canadian
ICES-002.
Ce système d’allumage par étincelle de véhicule est
conforme à la norme NMB-002 du Canada.
Contents
Page
Introduction 3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety 3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety and Instruction Decals 5. . . . . . . . . . . . . . . .
Specifications 7. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dimensions and Weights (approx.) 7. . . . . . . . . . .
Optional Equipment 7. . . . . . . . . . . . . . . . . . . . . . .
Setup 8. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Remove, Activate And Charge Battery 8. . . . . . . .
Install Battery 8. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mount Sweeper To Prime Mover 9. . . . . . . . . . . . .
Connecting Drive Shaft to Prime Mover PTO Shaft 10
Removing Sweeper From Prime Mover 10. . . . . . . .
Before Operating 11. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Check Engine Oil 11. . . . . . . . . . . . . . . . . . . . . . . . .
Check Clutch Housing Oil 11. . . . . . . . . . . . . . . . . .
Fill Fuel Tank 12. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Check Tire Pressure 12. . . . . . . . . . . . . . . . . . . . . . .
Transport Hooks 13. . . . . . . . . . . . . . . . . . . . . . . . . .
Adjust Reel Support Arm 13. . . . . . . . . . . . . . . . . . .
Adjust Rake Depth 13. . . . . . . . . . . . . . . . . . . . . . . .
Adjust Rubber Flap 14. . . . . . . . . . . . . . . . . . . . . . .
Page
Operation 14. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Controls 14. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Starting Instructions (Engine Driven) 15. . . . . . . . .
Stopping Instructions 16. . . . . . . . . . . . . . . . . . . . . .
Starting Instructions (PTO Driven) 16. . . . . . . . . . .
Operating Tips 16. . . . . . . . . . . . . . . . . . . . . . . . . . .
Inspection And Cleanup After Operation 16. . . . . . .
Maintenance 17. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lubrication 17. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil Drive Chain 18. . . . . . . . . . . . . . . . . . . . . . . . . .
Oil Sweeper Jack 18. . . . . . . . . . . . . . . . . . . . . . . . .
Changing Engine Oil and Filter 18. . . . . . . . . . . . . .
General Air Cleaner Maintenance 19. . . . . . . . . . . .
Servicing Air Cleaner 19. . . . . . . . . . . . . . . . . . . . . .
Replacing Spark Plugs 19. . . . . . . . . . . . . . . . . . . . .
Removing Debris From Engine 20. . . . . . . . . . . . . .
Replace Fuel Filter 20. . . . . . . . . . . . . . . . . . . . . . . .
Changing Clutch Housing Oil 20. . . . . . . . . . . . . . .
Adjusting Clutch 20. . . . . . . . . . . . . . . . . . . . . . . . . .
Changing Rubber Flap 21. . . . . . . . . . . . . . . . . . . . .
Cleaning Blower Housing 21. . . . . . . . . . . . . . . . . .
Adjusting Belts 22. . . . . . . . . . . . . . . . . . . . . . . . . . .
Adjusting Drive Chain 24. . . . . . . . . . . . . . . . . . . . .
Changing Gear Box Oil 25. . . . . . . . . . . . . . . . . . . .
Gear Box Removal 25. . . . . . . . . . . . . . . . . . . . . . . .
Locking Collar Removal 26. . . . . . . . . . . . . . . . . . .
Pulley Removal 26. . . . . . . . . . . . . . . . . . . . . . . . . .
Flex Tip Reel Removal 26. . . . . . . . . . . . . . . . . . . . .
Thatcher Installation 27. . . . . . . . . . . . . . . . . . . . . . .
Flex Tip Rake Rod Or Finger Plate Replacement 27
Flex Tip Rake Tine Replacement 28. . . . . . . . . . . . .
Brush Half Replacement 28. . . . . . . . . . . . . . . . . . . .
Changing Tires 29. . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery Care 29. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
The Toro General Commercial Products Warranty 32. .