MODEL NO. 07344 FORM NO. 3316-828 REV. A MANUAL TOR 1/3 PLATFORM LIFT OPERATORS for Workman Vehicle HL SAFETY INSTRUCTIONS Fo -assure maximum safely, optimum performance, and to.gain knowledge of the product, iris essential that you operator of the 1/3 Platform Lit read and understand the contents: of this mane before it is operated. Pay particular Tarkenton “to; ihe SAFETY INSTRUCTIONS highlighted by this symbol AL The safely need symbol means CAUTION, WARNING Or DANGER ~~ personal safely instruction.
A SAFETY AND INSTRUCTION DECALS The following decals are installed on the Ht If any card Garaged or legible! Please hem: Thi naval part banana ie cited billow and in’ your participation. Replacement decals tar be ordered from your Authorized Toto Distributor ADAGE CONTACT BETWEEN NON-INSULATED PLATFORM LIFT AND DOWER LINES WILL CAUSE ELECTROCUTION. ELECTROCUTION WILL CAUSE SERIOUS PERSONAL URINARY OR DEATH: + NEVER USE PLATFORM LIFT NEAR POWER LINES.
LOOSE PARTS CHART Note: Use this chart Asia checklist to assert all pars necessary for assembly rile Don received Without techs parts; total setup anionic be Completed, Son pads may have already beer assembled at factory. DESCRIPTION Main Wire: Ha mess / Belays Cable Tie Careworn #102411" 1g. Lockout #1024 Barking Brake Switch Spacer — Long Spacer Shari Screw ripsaw 1 Sower #104 E ig Washer #10 Nut #1004 Fear Wire: Harness wi Level Switch Cable Tie Reinforcing Plate Flange HD: Cap screw 3/8185 11g.
SET-UP INSTRUCTIONS The 13: platform is designed io be used only with a Workman Vehicle and must fountainhead with tha wing Harries, level, decals, switches and all interlock switches installed. 4, Position vehicle on A Clean, elev surface, sop engine, engage parking brake and remove key from seniority, Disconnect postie cable from battery. 2. unscrew and: reverie all cobs from: console lovers. Figure 1 Canter console cover 3: Beat assembly 2 ‘Seatmate 4; Bidet & lender assembly #.
SET-UP INSTRUCTIONS Figure ¥ 1. Vehicle frame channel 2 Undercharged inset Note: To prevent IR castor ams from expanding, pick up the plateau li rom the botheration positioning on frame. 7. Position lift root Trams aligning mounting holes with holes i frame, 28 Headhunter: side of Tie frame channels with-a reinforcing plate:and (2) 38-16 x 17 lg. flange head corkscrews and tangents (Fig. 8). Reinforcing plates to be used in rear mounting holes only.
SET-UP INSTRUCTIONS Figurative Lif Re Hi mounting brackets: To mount iit in mid position opinionated HI Hitler Tubes, usa the following steps. 38. Using dimensions shown in figure 11, locate; mark: and drill (2y.1376 13/8)" dia holes, hvu footballer, of each HL Hitch Frame Tubs. Nita: To sage hole drilling in hitch bes.
BEFORE OPERATING 4. While. standing next io matching, grasp pendant genial and rotate Bt Key switch to ON" position, Check overhead clearance and for amy obstructions, 8. Press UP" torsion miss sift high enough ions safety blocks: Stand oles of issuer army while platforms moving, A) pacer Contact ‘with moving scissor arms can cause personal injury. ® Stand clear of ‘scissor arms While platform is moving. * Make sure area is clear of bystanders before forwarding platform.
OPERATING INSTRUCTIONS A warning AA pander Operation of platform IH without parking brake engaged can result in p-over and personal injury. ® Always apply parking brake: before operating pinafore TH The use of shew! kooks is recommended # Do not release: parking: brake while platform ft is raddled.
OPERATING INSTRUCTIONS Figure 22 te Emergency dowering Vale unit 3 Loop ERY ruler 1o normal operation. push distributional 180° clockwise and release; A) pander Falling of Jumping from raised platinum will cause personal injury. # Secure bot handrail sap challenge A Cross opening before raising platform.
MAINTENANCE CHECK SAFETY CIRCUITS The electrical sally circuits of the lit require the vehicle: 10 be parked on audiotape of vss than 5 Depressant parking brake tn be engaged orderings activate the il recruit To verity parking brake switch operation: 1 Position the vehicle ona local aids; sat parking Drake and chock wheels: 2. Boilerplate key switch "ON position; ‘While: standing med schilling gray pendant control and so sate if hey switch to "ONT position: Press “up” Mutton and raise Ila low inches.
