Installation Instructions

ManualsBrandsToro ManualsSprayersFan Kit, EFI Workman Vehicles For Use With Multi Pro WM Turf Sprayer

Table Of Contents

FormNo.3379-774RevA

FanKit

EFIWorkman

VehiclesForUseWithMultiProWMTurfSprayer

ModelNo.127-9719

InstallationInstructions

WARNING

CALIFORNIA

Proposition65Warning

Thisproductcontainsachemicalorchemicals

knowntotheStateofCaliforniatocausecancer,

birthdefects,orreproductiveharm.

TheFankitisanattachmentforaturfsprayapplication

vehicleandisintendedtobeusedbyprofessional,hired

operatorsincommercialapplications.Itisprimarilydesigned

forreducingtheairtemperatureunderthesprayerassembly.

ThisproductcomplieswithallrelevantEuropeandirectives.

Fordetails,pleaseseetheseparateproduct-specic

DeclarationofConformity(DOC)sheet.

Readthismanualcarefullytolearnhowtooperateand

maintainyourproductproperly.Theinformationinthis

manualcanhelpyouandothersavoidinjuryandproduct

damage.AlthoughTorodesignsandproducessafeproducts,

youareresponsibleforoperatingtheproductproperlyand

safely.

YoumaycontactTorodirectlyatwww .Toro.comforproduct

andaccessoryinformation,helpndingadealer,ortoregister

yourproduct.

Wheneveryouneedservice,genuineToroparts,oradditional

information,contactanAuthorizedServiceDealerorToro

CustomerServiceandhavethemodelandserialnumbers

ofyourproductready.

Safety

Thismanualidentiespotentialhazardsandhassafety

messagesidentiedbythesafetyalertsymbol(Figure1),

whichsignalsahazardthatmaycauseseriousinjuryordeath

ifyoudonotfollowtherecommendedprecautions.

Figure1

1.Safetyalertsymbol

Thismanualuses2wordstohighlightinformation.

Importantcallsattentiontospecialmechanicalinformation

andNoteemphasizesgeneralinformationworthyofspecial

attention.

Readalsothesafetyandoperationinstructionsinthevehicle

Operator’sManual.

Lightningcancausesevereinjuryordeath.Iflightningisseen

orthunderisheardinthearea,donotoperatethemachine;

seekshelter.

8111LyndaleAvenueSouth

Bloomington,MN55420

Registeratwww.T oro.com.

OriginalInstructions(EN)

PrintedintheUSA

AllRightsReserved

*3379-774*A

Summary of content (8 pages)

PAGE 1
Form No. 3379-774 Rev A Fan Kit EFI Workman® Vehicles For Use With Multi Pro WM Turf Sprayer Model No. 127-9719 Installation Instructions WARNING CALIFORNIA Proposition 65 Warning This product contains a chemical or chemicals known to the State of California to cause cancer, birth defects, or reproductive harm.
PAGE 2
Installation Loose Parts Use the chart below to verify that all parts have been shipped. Procedure Description Use Qty. 1 No parts required – Prepare the machine 2 Fan collar Fan Fan guard bracket Fan guard Hex bolt (5/16 - 18) Hex bolt M6 - 1 x 20 Nut 1 1 1 1 5 4 3 Install the Fan Kit. 3 No parts required – 1 Preparing to Install the Kit No Parts Required Procedure 1. Ensure that the machine is empty of all fluids.
PAGE 3
1 Figure 3 1. Sprayer tank support 3. Sprayer tank 4. Shut off the engine, set the parking brake, and remove the key. 5. Disconnect the battery as follows: A. Squeeze the battery cover to release the tabs from battery base (Figure 4). Figure 4 Remove the battery cover from the battery base (Figure 4). C. Remove the terminal of the positive battery cable from the battery post (Figure 5). 4 3 Figure 5 2. Cylinder barrel B.
PAGE 4
2 1 2 Installing the Fan Kit Parts needed for this procedure: 1 Fan collar 1 Fan 1 Fan guard bracket 1 Fan guard 5 Hex bolt (5/16 - 18) 4 Hex bolt M6 - 1 x 20 3 Nut 3 Installing the Fan Kit g024582 1. Remove the 4 bolts on the pulley; refer to Figure 6. Figure 7 1. Fan 2. Fan collar 1 3. Hex bolt M6 - 1 x 20 3. Remove existing bolts and install the fan guard bracket; refer to Figure 8. 2 1 2 g024589 Figure 6 1. Pulley 2. Bolt 3 g024583 Figure 8 2.
PAGE 5
1 2 2 1 3 g024584 g024585 Figure 9 1. Fan guard Figure 10 3. Nut 1. Hex bolt (5/16 - 18) 2. Hex bolt (5/16 - 18) 5 2.
PAGE 6
3 Lowering the Sprayer Tank No Parts Required Procedure 1. Pull the sprayer tank support from the cylinder rod and remove the support (Figure 3). 2. Insert the sprayer tank support into the brackets on the back of the ROPS panel (Figure 2). 3. Lower the sprayer tank; refer to the Operator’s Manual.
PAGE 7
Notes: 7
PAGE 8