Installation Instructions

ManualsBrandsToro ManualsRiding ProductsBriggs and Stratton Engine Maintenance Kit

FormNo.4505-965RevA

BriggsandStratton

EFIEngineMaintenanceKit

KitNos.142-8436and145-8479

InstallationInstructions

SafetyAlertSymbol

ThisSafetyAlertSymbol(Figure1)isusedbothin

thisinstructionsheetandonthemachinetoidentify

importantsafetymessageswhichmustbefollowedto

avoidaccidents

Thissymbolmeans:ATTENTION!BECOMEALERT!

YOURSAFETYISINVOLVED!

g000502

Figure1

SafetyAlertSymbol

Thesafetyalertsymbolappearsaboveinformation

whichalertsyoutounsafeactionsorsituationsand

willbefollowedbythewordDANGER,WARNING,or

CAUTION.

DANGER:Indicatesanimminentlyhazardous

situationwhich,ifnotavoided,Willresultindeathor

seriousinjury.

WARNING:Indicatesapotentiallyhazardoussituation

which,ifnotavoided,Couldresultindeathorserious

injury.

CAUTION:Indicatesapotentiallyhazardoussituation

which,ifnotavoided,Mayresultinminorormoderate

injury.

Thismanualusestwootherwordstohighlight

information.Importantcallsattentiontospecial

mechanicalinformationandNoteemphasizesgeneral

informationworthyofspecialattention.

WARNING

Whilemaintenanceoradjustmentsarebeing

made,someonecouldstarttheengine.

Accidentalstartingoftheenginecould

seriouslyinjureyouorotherbystanders.

Removethekeyfromtheignitionswitch,

engageparkingbrake,andpullthewire(s)

offthesparkplug(s)beforeyoudoany

maintenance.Alsopushthewire(s)asideso

itdoesnotaccidentallycontactthespark

plug(s).

Note:Determinetheleftandrightsidesofthe

machinefromthenormaloperatingposition.

Note:Parkthemachineonalevelsurface.Make

sureallmovingpartshavestopped,parkingbrakeis

engaged,thekeyhasbeenremoved,andthespark

plugwirehasbeendisconnected.Allowthemachine

tocoolbeforestartingtheseinstructions.

OriginalInstructions(EN)

PrintedintheUSA

AllRightsReserved

*4505-965*

Summary of content (6 pages)

PAGE 1
Form No. 4505-965 Rev A Briggs and Stratton® EFI Engine Maintenance Kit Kit Nos. 142-8436 and 145-8479 Installation Instructions Safety Alert Symbol Note: Determine the left and right sides of the This Safety Alert Symbol (Figure 1) is used both in this instruction sheet and on the machine to identify important safety messages which must be followed to avoid accidents This symbol means: ATTENTION! BECOME ALERT! YOUR SAFETY IS INVOLVED! machine from the normal operating position.
PAGE 2
Loose Parts Use the chart below to verify that all parts have been shipped. Item Part No. Description Item Part No. Description 1 142-7451 Filter-Fuel 1 4 142-8434 Filter-Inner Air 1 2 142-6841 Filter-Oil 1 5 142-8435 Plug-Spark 2 3 142-8433 Filter-Outer Air 1 6 135-2566 Bottle-Oil, Engine 5 Qty Qty Servicing the Air Cleaner Engine Maintenance Check the air cleaner daily or before starting the engine. Check for a buildup of dirt and debris around the air cleaner system.
PAGE 3
4. Check the engine oil level. 2 1 3 5 1 4 g377174 Figure 2 1. Outer air filter 2. Inner air filter 4. Cover 5. Clamp 3. Housing Installing the Elements: 1. 2. 3. g379684 Install the new inner air filter element included in the kit in the same place and angle of the old inner air filter element in the housing. 1. Dipstick Place the outer air filter element included over inner air filter element as shown in Figure 2. 5.
PAGE 4
. Turn and remove the oil drain cap. Located at the bottom of the oil reservoir. Drain into approved container (no hose included). Note: Dispose of the used oil at a recycling center. 5. Replace the oil filter every oil change. Open oil fill cover on top of oil reservoir. Remove the oil filter as seen in Figure 4 by turning filter counter clockwise. Dispose of it properly. g027478 Figure 5 4. 1 Clean around the spark plug to prevent dirt from falling into the engine and potentially causing damage.
PAGE 5
Fuel System Maintenance DANGER In certain conditions during fueling, static electricity can be released causing a spark which can ignite gasoline vapors. A fire or explosion from gasoline can burn you and others and cause property damage. • Always place gasoline containers on the ground away from your vehicle before filling.
PAGE 6
3. The fuel filter is in the fuel line between the tank and engine. 4. Squeeze the ends of the hose clamps together and slide them away from the filter. g035841 Figure 7 Note: It is important to reinstall the fuel line hoses and secure with plastic ties the same as they were originally installed at the factory to keep the fuel line away from components that could cause fuel line damage. 5. Remove the filter from the fuel lines. 6.