FORM NO. 3315628 Rev. A MODEL NO. 20435 — & UP MODEL NO. 20436 — & UP MODEL NO. 20437 — & UP OPERATOR’S MANUAL 21" RECYCLER® Il SUPER PRO" MOWER A\ SAFETY INSTRUCTIONS This mower meets or exceeds CPS blade safety requirements for walk behind rotary mowers and the specifications of the American National Standards Institute. However, improper use or maintenance by the operator or owner can result In injury.
A\ SAFETY INSTRUCTIONS MAINTENANCE AND STORAGE 20. Perform only those maintenance instructions described in this manual. i major repairs are ever needed ot if assistance is desired, contact your local Authorized TOR Service Dealer. 21. Before mower is cleaned, inspected, serviced, or adjusted, stop engine and disconnect wire from spark plug. Keep wire away from plug to prevent accidental starting.
TABLE OF CONTENTS Set—Up Instructions Before Operating .. . Recycler® [l Super Pro® Mower Tips .7 Operating Instructions .8 Maintenance 10 Servicing Air Cleaner . .10 Replacing Spark Plug Draining Gasoline Changing Crankcase Oi Adjusting Throttle .. .1 Adjusting Wheel Drive , o lnspectlng/Removmg/Sharpenmg Blade 12 Lubrication Adjusting Brake Cable Charging Battery Cleaning Mower Housing . . Preparing Mower For Storage Optional Equipment Tore Service Support . Product identification .
INSTALL STARTER ROPE (Fig. 3) INSTRUCTIONS 1. Pull starter rope through rope guide on handle. To make rope easier to loop, squeeze control bar on handle to release blade brake, STARTER 210 INSTALL BATTERY (electric start model only} 1. Refer to Charging Battery, page 14. Slide battery, decal side up, between mounting tabs on back of control panel and connect wires (Fig. 4). Insert key into switch when ready to start engine.
BEFORE OPERATING FILL CRANKCASE WITH OIL initially, crankcase must be filled with 20 ounces {0.6 liters) of SAE 30 oil. 10W--30 oil may be substituted if SAE 30 is not available. Use any high quality detergent oil having the American Petroleum Institute (AP} "service Before each use, ensure oil level is between FULL and ADD marks on dipstick (Fig. 5). Add il if level is low. 1. Position mower on level surface and clean around oit dipstick {Fig. 5. 2.
RECYCLER® 1l SUPER PRO® MOWER TIPS RECYCLER® Il SUPER PRO® MOWER FEATURES Your Toto Recycler® it Super Pro® mower has a new and completely different cutting concept; it leaves your lawn with a bagged look without bagging clippings.
OPERATING INSTRUCTIONS ® Walk at a slower mowing speed if leaves are not cut up finely enough to be hidden down in the grass. # if you cut up a lot of oak deaves, you might want 1o add lime to your grass in the spring. Lime reduces the acidity of oak leaves. STARTING, STOPPING, AND SELF~PROPELLING (self—propelled models only) 1. CONTROLS—Throttle, ground speed control {propelling models), control bar, and fingertip starter are on upper handier (Figs. 7 & 8).
OPERATING INSTRUCTIONS Note: The drive wheels are equipped with freewheeling clutches which enable the mower to be puled rearward easier when the wheel drive is disengaged. To disengage the clutches, mower must be pushed forward at least 1" after wheel drive operation has stopped. 8. STOPPING—To stop engine, release control bar. Pull wire off spark plug if mower will be unattended or not used.
MAINTENANCE A\ caution * Engine could start accidentally. * Accidental starting of engine could cause serious injury to operator or bystanders, * Pull wire off spark plug before performing any maintenance or adjustments. Remove key from switch on electric start model. SERVICING AIR CLEANER Norma fly, replace air cleaner after every 25 operating hours. More frequent replacement is required when mower is operated in dusty or dirty conditions. 1. Stop engine and pull wire off spark plug {Fig. 15).
MAINTENANCE DRAINING GASOLINE 1. Stop engine and wait for engine to cool. Pull wire off spark plug (Fig. 15). Remove key from switch on electric start model. ADJUSTING THROTTLE Throttle control adjustment may be required if engine does not start, Whenever a new throttle control cable is installed, throttle must be adjusted. 1. Stop engine and pull wire off spark plug (Fig.18). « Contact with burning gasoline could cause serious personal injury. * Drain gasoline from a cold engine only. 2.
MAINTENANCE CONTROL KNOB 402 Figure 20 2. CHECK is correct when rear wheels stop turning and control bar is about 1-1/2 inches from handle (Fig. 21). 3. Repeat steps 1 and 2 unfit properly adjusted. Figure 21 INSPECTING/REMOVING/SHARPENING BLADE Always mow with a sharp blade. A sharp blade cuts cleanly and without tearing or shredding the grass blades like a dull blade. 1. Stop engine and pull wire off spark plug {Fig. 18). Remove key from switch on electric start model. 2.
MAINTENANCE FORMED 270 Figure 23 6. SHARPENING BLADE—Using a file, sharpen top side of blade and maintain original cutting angle (Fig. 24). The blade will remain balanced if same amount of material is removed from both cutting edges. SHARPEN AT THIS ANGLE ONLY Figure 24 IMPORTANT: Check balance of blade by putting it on a blade balance. An inexpensive balance can be purchased at a hardware store.
MAINTENANCE Hand push model only Figure 27 CHARGING BATTERY (electric start model only) Although a new battery is not fully charge, a partial charge of four hours provides enough energy for several starts, However, a new battery must be charged for 72 continuous hours o ensure full charge. Also charge battery for 72 hours when mower is stored and in the spring. During normal operation, engine alternator keeps battery charged. 1. Stop engine and disconnect wire harness from battery terminal {Fig. 28).
MAINTENANCE Fuel can be left in gas tank only if a fuel additive, such as Toto's Stabilizer/Conditioner, is added to gasoline before storing. Toto's Stabilizer/Conditioner is a petroleum distillate based conditioner/stabilizer. Toto does not recommend stabilizers with an alcohol base, such as ethanol, methanol or prophylaxis. Use fuel additive in redecorated quantities as specified on container. Under normal conditions, fuel additives remain effective in fuel for 68 months. 2.
OPTIONAL EQUIPMENT For special conditions, the following accessories may be purchased at your local Authorized Toto Service Dealer. 1. Rear Bagging Kit (Model 59174 for self—propelled modals, Model 58179 for hand push mod discharge tunnel and rear mounting grass bag to convert Recycler® | Super Pro® mower {0 a rear bagging mower (Fig. 30}. Includes discharge tunnel plug. DISCHARGE TUNNEL DISCHARGE Figure 30 2. Slide Discharge Kit, Model Rear Bagging Kit, Model 58174). Installs in seconds.
It is Torah's policy to design and produce high quality products. To ensure customer satisfaction, Toto has extensive warranty coverage on its products. Your TOR GTS Engine powered product has two warranty statements covering it.
What Does This Warranty Not Cover? This Warranty does not cover: 1. Any repairs on products used commercially. 2. Normal maintenance including replacement of spark plugs, air filter, fuel filter, and carburetor adjustments. 3. Oil change and lubrication. 4. Repairs or adjustments due to! a. Failure to follow proper maintenance procedures; b. Rotary mower blade striking an object; ¢. Contaminants in the fuel system; d. Improper fuel or fuel mixture (consult your owner's manual if in doubt); e.
GUARANTEED TO START MAINTENANCE RECORD To keep the starting guarantee in effect, you must perform the following maintenance after every 25 operating hours, mare often in dusty and dirty conditions.
Consumer Products TOR THE TOR TOTAL COVERAGE GUARANTEE A Full Two—Year Warranty {Limited Warranty for Commercial Use) What Is Covered By This Express Warranty? The Tore Company promises to repair any TOR Product used for residential purposes if defective in materials or workmanship for a period of two years from the date of purchase. The cost of parts and labor are included, but the customer pays ihe transportation costs.