FORM NO. 3318–939GB Carefree Cordless Walk Power Mower Model No. 21040–7900001 & Up Model No. 21042–7900001 & Up Model No.
Figures — Figuras 1 1 m–2886 1.
1 3 5 m–2886 1. Lower handle 1 4 m–2889 1 1. Clip 6 5 2 3 4 6 2 1 m–2900 1. Upper handle 2. Lower handle 3. Screw (2) 4. Bolt (2) 5. Knob (2) 6. Control cable m–2890 1. Clip 2.
7 9 1 m–2891 1. Side discharge chute 1. Mulch door 2225 2. Handle 10 8 m–2892 11 2232 1. Peg (2) m–2893 1. Key iii 2.
1 12 14 2 1 3 m–2895 1. Rain shield 2. Plug receptacle 2 m–2896 13 4 5 1. Key 2. Circuit breaker button 6 3. Rain shield 1 2 3 95–5015 1. Red light 2. Yellow light 3. Green light 4. Quarter full box 5. Half full box 6.
15 16 m–2898 1. Control bar 17 m–2897 2215 1. Control bar v 2. Slide pushed down 1.
18 3 20 2 1 1. Blade bolt 2. Washer 1 2205 3. Blade 2207 1. Front cavity 21 19 1 1 153 A 1. Sharpen at this angle only 2 1 B 3 1 C 4 1. Sail 2. Flat part of blade 270 3. Wear 4.
1 22 23 2 3 4 m–2901 1. Screw (4) 2. Shroud m–2902 1. Screw (4) 2. Battery hold-down strap vii 3. Battery pack 4.
Contents Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Safe Operating Practices . . . . . . . . . . . . . . General Operation . . . . . . . . . . . . . . . . . . . While Operating . . . . . . . . . . . . . . . . . . . . . Maintenance And Storage . . . . . . . . . . . . . Sound Emissions . . . . . . . . . . . . . . . . . . . . Page 1 2 2 2 2 3 5 Vibration Level . . . . . . . . . . . . . . . . . . . . .
The left and right sides of the machine are determined by standing behind the handle in the normal operator’s position. under 16 years of age to operate the mower. Never allow adults to operate mower without proper instructions. 2. The operator of the mower is responsible for keeping everyone, especially children and pets, away from area of operation. The operator is responsible for accidents or hazards occurring to other people or their property. 3.
4. Use Right Appliance – Do not use lawn mower for any job except that for which it is intended. 5. Stay Alert – Watch what you are doing. Do not operate mower when tired or under the influence of drugs, alcohol or medication. 6. 7. Avoid dangerous environments. Never operate mower in wet grass or damp locations. Do not use mower in the rain. Always maintain secure footing. Keep a firm grip on the handle and walk; never run. Mow only in daylight or in good artificial light.
5. Don’t abuse extension cord while charging. Do not yank cord to remove it from plug receptacle. Keep cord away from heat, oil and sharp edges. 6. When replacing batteries, all batteries should be replaced at the same time. Mixing fresh and discharged batteries could increase internal cell pressure and rupture the battery(ies). 7. When inserting the batteries into this product, the proper polarity or direction must be observed.
Sound Emissions This unit has a maximum airborne noise emission, based on measurement of identical machines: Sound Pressure Level – 76dB(A)* Sound Power Level – 88 LwA* * Unit tested under no load condition. Vibration Level This unit has a maximum vibration level of 2.5 m/s@, based on measurement of identical machines*. * Unit tested under no load condition.
Keep dry Low Electrical shock, electrocution High Cutting element – height of cut Splash-proof construction C.E.
Assembly 4. IMPORTANT: Do not insert the key into the plug receptacle until mower is fully assembled. Install Handle IMPORTANT: Control cable must be over, not under, handles (Fig. 2). POTENTIAL HAZARD • Excessive pulling on control cable may cause mower to start. When mower is operating, blade is rotating. WHAT CAN HAPPEN • Contact with rotating mower blade could cause serious personal injury. If handles are in highest height position, use clip to attach cable to left side of lower handle tube (Fig.
To charge battery: 1. 2. Always charge mower in a dry area protected from the weather. Also, keep mower away from water and any flammable substances. The red light on the control panel will begin to flash to indicate battery is present and is ready to charge. 5. After a few minutes, the red light will stop flashing and become a steady red. This indicates the battery is charging. 6. When the battery is almost fully charged, the red light will go out and the green light will go on.
Battery Power Status Operation The three horizontal LED lights at the top of the control panel indicate approximately how much charge is left in the battery while the mower is in operation (Fig. 13). The lights are only accurate when the mower is operating and cutting grass. The following is an explanation of the symbols under the battery power status LED lights: This mower is intended for residential use only. • Full Box – Battery is between 50% and 100% charged.
To Stop Motor 1. IMPORTANT: Never reset circuit breaker when key is in receptacle and control bar is squeezed to handle. Release control bar. POTENTIAL HAZARD • When key is in plug receptacle, mower is operational. Someone could accidentally start the mower. 1. Remove key from plug receptacle (Fig. 14). 2. Wait 30 seconds to 1 minute before pushing in circuit breaker button (Fig. 14). 3. Reinstall key in plug receptacle. 4. Resume cutting under less load.
• Maintain a sharp blade throughout the cutting season. Periodically file down nicks on blade. • Only mow dry grass or leaves. Wet grass and leaves tend to clump on yard and may cause mower to plug or motor to stall. They may also be slippery to walk on and could cause you to slip and fall. POTENTIAL HAZARD • Wet grass or leaves can cause you to slip and contact blade. WHAT CAN HAPPEN • Blade contact can seriously injure you.
Adjusting Height-of-Cut Maintenance The mower has five height-of-cut adjustments: 3.8 cm, 5.1 cm, 6.4 cm, 7.6 cm and 8.9 cm. The rear adjustment lever adjusts the height-of-cut for both rear wheels, and the front adjustment lever adjusts both front wheels. POTENTIAL HAZARD • When key is in plug receptacle, mower is operational. Someone could accidentally start the mower. WHAT CAN HAPPEN • Accidental starting of mower could seriously injure you or other bystanders.
• Check for any discolored or charred wires and battery and switch contacts. If any are damaged, see your Authorized Toro Service Dealer for repairs. POTENTIAL HAZARD • A worn or damaged blade could break and a piece of blade could be thrown in operator’s or bystander’s direction. Blade WHAT CAN HAPPEN Always mow with a sharp blade. A sharp blade cuts cleanly and without tearing or shredding the grass blades like a dull blade.
Battery Replacement 4. Reconnect the positive and negative wires to the battery terminals (Fig. 23). Battery Removal 5. Reinstall battery hold-down strap (Fig. 23). 1. Stop the motor and remove the key from the plug receptacle. 6. Reinstall shroud with four screws (Fig. 22). 2. Remove the four screws from the shroud and remove the shroud (Fig. 22). Old Battery Disposal 3. Move control panel out of the way. DO NOT PLACE USED BATTERIES IN YOUR REGULAR TRASH! 4.
Storage Store mower in a cool, clean, dry place. Do not store mower if it contains a battery in a warm basement. Cover mower to keep it clean and protected. 1. Clean mower housing. See Cleaning section in Maintenance chapter. 2. Remove grass clippings, dirt and grime from external parts of the shrouding and top of mower housing. 3. Check condition of blade. See Blade section in Maintenance chapter. 4. Tighten all nuts, bolts, and screws. 5.
