Operator's Manual

ManualsBrandsToro ManualsLawn MowersToro 26638



'% ,., ,*-#+2

)) (&'0/ %/%.1%$



      



 



!

"  



  -! "',-+.-"(', +.%%2  &"%"+ 0"-!

-! ('-+(%, ' -! )+()+ ., ( -! *.")&'-

 /+ %%(0 !"%+' (+ )()% .'&"%"+ 0"-!

-!, "',-+.-"(', -( ., -! %0'&(0+ (%

+ .%-"(', &2 +,-+"- -!   ( -! ()+-(+

 /+ &(0 0!"% )()% ,)"%%2 !"%+' (+

)-, + '+2

 ) "' &"' -!- -! ()+-(+ (+ .,+ ",

+,)(',"% (+ "'-, (+ !3+, (.++"'  -(

(-!+ )()% (+ -!"+ )+()+-2



 !"% &(0"'  %02, 0+ ,.,-'-"% ((-0+

' %('  -+(.,+, ( '(- ()+- -! *.")&'-

0!' +((- (+ 0+"'  ()' ,'%,

 !(+(. !%2 "',)- -! + 0!+ -!

*.")&'- ", -(  ., ' +&(/ %% (#-,

0!"! &2  -!+(0 2 -! &!"'

 %02, 0+ ,-2 %,,, (+ 2 ,!"%, .+"'

()+-"(' -( )+(-- 2, +(& (+" ' (#-, -!-

&2  -!+(0' +(& -! &!"' +"'  ( !+"'

)+(--"(' )+(--"/ %(/, '  ,-2 !%&- ",

/",% ' &2  +*."+ 2 %(% + .%-"(',

   -+(% ", !" !%2 %&&%

 -(+ .% "' ('-"'+, ,)""%%2 ," ' (+

-!", ).+)(,

 .% (.-((+, ('%2 ' ( '(- ,&($ 0!"%

+.%%"' 

  .% (+ ,-+-"'  -! ' "' /+

+&(/ -! ) ( -! .% -'$ (+  )-+(% 0!"%

-! ' "' ", +.''"'  (+ 0!' -! ' "' ", !(-

  )-+(% ", ,)"%% ( '(- --&)- -( ,-+- -!

' "' .- &(/ -! &!"' 02 +(& -! + (

,)"%%  ' /(" +-"'  '2 ,(.+ ( " '"-"(' .'-"%

)-+(% /)(+, !/ ",,")-

 )% %% .% -'$, ' ('-"'+ ),

,.+%2

 )% .%-2 ,"%'+,

 (+ .,"'  %02, /",.%%2 "',)- -( , -!-

-! %, % (%-, ' .--+ ,,&%2 + '(-

0(+' (+ &  )% 0(+' (+ &  %,

' (%-, "' ,-, -( )+,+/ %'

 ' &.%-"4% &!"', -$ + , +(--"'

(' % ' ., (-!+ %, -( +(--



 ( '(- ()+- -! ' "' "'  ('"' ,)

0!+ ' +(., +(' &('(1" .&, '

(%%-

 (0 ('%2 "' 2%" !- (+ "' (( +-"""% %" !-

 /(" ()+-"'  -! *.")&'- "' 0- +,,

0!+ ,"%

 %02,  ,.+ ( 2(.+ ((-"'  (' ,%(),

 %$ '/+ +.'

 (+ 0!% +(-+2 &!"', &(0 +(,, -!

 ( ,%(), '/+ .) ' (0'

 1+", 1-+& .-"(' 0!' !' "'

"+-"(' (' ,%(),

 ( '(- &(0 1,,"/%2 ,-) ,%(),

 , 1-+& .-"(' 0!' +/+,"'  (+ ).%%"'

-! %0'&(0+ -(0+, 2(.

 -() -! %, " -! %0'&(0+ !, -( 

-"%- (+ -+',)(+--"(' 0!' +(,,"'  ,.+, (-!+

-!' +,, ' 0!' -+',)(+-"'  -! %0'&(0+ -(

' +(& -! + -(  &(0

 /+ ()+- -! %0'&(0+ 0"-! -"/

.+, (+ ,!"%, (+ 0"-!(.- ,-2 /", (+

1&)% %-(+, '(+ +,, -!+, "' )%

 ( '(- !'  -! ' "' (/+'(+ ,--"' , (+

(/+,) -! ' "'

 ",'   %% % ' +"/ %.-!, (+

,-+-"'  -! ' "'

 -+- -! ' "' (+ ,0"-! (' -! &(-(+ +.%%2

(+"'  -( "',-+.-"(', ' 0"-! - 0%% 02 +(&

-! %,

 ( '(- -"%- -! %0'&(0+ 0!' ,-+-"'  -!

' "' (+ ,0"-!"'  (' -! &(-(+ 1)- " -!

%0'&(0+ !, -(  -"%- (+ ,-+-"'  ' -!", ,

( '(- -"%- "- &(+ -!' ,(%.-%2 ',,+2 ' %"-

('%2 -! )+- 0!"! ", 02 +(& -! ()+-(+

 ( '(- ,-+- -! ' "' 0!' ,-'"'  "' +('- (

-! ",!+  !.-

Summary of content (24 pages)

PAGE 1
! " -! "',-+. -"(', + .%%2 &"%" + 0"-! -! ('-+(%, ' -! )+() + ., ( -! *.")& '- / + %%(0 !"% + ' (+ ) ()% .' &"%" + 0"-! -! , "',-+. -"(', -( ., -! % 0'&(0 + ( % + .% -"(', & 2 + ,-+" - -! ( -! () + -(+ / + &(0 0!"% ) ()% ,) " %%2 !"% + ' (+ ) -, + ' + 2 ) "' &"' -! - -! () + -(+ (+ .
PAGE 2
! Do not put hands or feet near or under rotating parts. Keep clear of the discharge opening at all times. Never pick up or carry a lawnmower while the engine is running. Never store the equipment with petrol in the tank inside a building where fumes may reach an open flame or spark. Stop the engine and disconnect the spark plug wire. Allow the engine to cool before storing in any enclosure.
PAGE 3
Safety alert triangle–– symbol within triangle indicates a hazard Do not open or remove safety shields while engine is running Safety alert symbol Rotating blade can cut off toes or fingers. Stay clear of mower blade as long as engine is running.
PAGE 4
Hourmeter/elapsed operating hours Fuel Neutral Fast First gear Slow Decreasing/increasing Grease lubrication point Engine start Engine stop Choke Primer (start aid) Second gear Third gear Cutting element–– basic symbol Cutting element–– Height adjustment Pull rope Wheel Wheel traction Push primer three times
PAGE 5
Properly dispose of batteries Lower control bar Insert key into ignition switch Raise control bar Turn key in ignition switch Raise/lower control bar Move control Raise control bar Raise/lower control bar Lower control bar Raise control bar Page Set-Up Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 Before Operating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 Operating Instructions . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 6
INSTALLING HANDLEĊLoosen knobs on mounting brackets (Fig. 1). Use cable ties to secure cables to lower ends of handle tubes (Fig. 3). Cable ties should be positioned 25 mm (1") from bend in handles. See Figure 3 for correct placement. Position mounting brackets in a vertical position so that holes face up. +/# Make sure cables do not interfere with the raising or lowering of discharge door.
PAGE 7
SET-UP INSTRUCTIONS INSTALL GRASS BAG 1. %-6) (-6',%5+) (225 6/-() &%+ 5%03 %77%',)( 72 &%+ -172 (-6',%5+) 23)1-1+ %1( ,22. &%+ *5%0) 2172 5281()( 3257-21 2* 02817-1+ &5%'.)76 -+ Note: %.) 685) +5%66 &%+ (225 -6 fully '/26)( %+%-167 +5%66 &%+ &)*25) -167%//-1+ &%+ 21 02:)5 2. //2: (-6',%5+) (225 72 5)67 21 723 2* &%+ -+ 6 3 1 2 4 5 Figure 6 1. Bag door 2. Bag ramp Figure 5 3. Discharge door 4. Bag handle 5. Mounting bracket 6.
PAGE 8
BEFORE OPERATING FILL FUEL TANK WITH GASOLINE 2. ' # )#! '$! # !! ) ! ( # ($ + ( # ($ "" ($ # &$" ($% $ ( # #$( #($ ( !! & # $ #$( !! ( # )!! WARNING DANGER: Gasoline is extremely flammable and explosive under certain conditions. DO NOT SMOKE when handling fuel and keep fuel far away from open flames and sparks. Never buy more than a 30 day supply of gasoline. Store it in an approved container. Keep gasoĆ line out of reach of children.
PAGE 9
! CHECK OIL LEVELĊMaintain oil level between ADD and FULL range as shown on dipstick (Fig. 7). BEFORE EACH MOWINGĊEnsure self-propelled drive and control bar function properly. Traction drive and blade are designed to stop when control bar is released. CUTTING AND BAGGINGĊBest results are achieved when engine is running at maximum speed and only about 1/3 of the grass blade is cut. If long grass must be cut, use highest height-of-cut setting for first mowing.
PAGE 10
/4% The drive wheels are equipped with freewheeling clutches which enable the mower to be pulled rearward easier when the wheel drive is disengaged. To disengage the clutches, mower must be pushed forward at least 2.5 cm (1") after wheel drive operation has stopped. STOPPING (Fig. 11)ĊRelease control bar to stop blade and traction drive. Move ground speed control (OFF). to N". To stop engine, move throttle to Pull wire off spark plug if mower will be unattended or not used.
PAGE 11
! ! " ! ! ! Check the control bar before each use to ensure the Blade Brake Clutch (BBC) system is operating properly. &,645+0) *'+)*5 1( %65 .'7'34 %16.& $3+0) *#0&4 +051 %105#%5 8+5* /17+0) $.#&' 105#%5 8+5* $.#&' %16.& %#64' 4'3+164 2'3: 410#. +0,639 1 015 #&,645 5*' *'+)*5 1( %65 4'55+0)4 8*'0 '0)+0' +4 3600+0) #0& $.#&' +4 315#5+0) 1 015 265 (+0)'34 60&'3 *164+0) 51 .+(5 /18: '3 8*'0 #&,645+0) *'+)*5 1( %65 .'7'34 13/#. 10531.
PAGE 12
Release the control bar (Position B, Fig. 17). A bang" should be heard. The blade should stop running in three seconds. 1” (2,5 cm) #"+( Bring the control bar up into the mid position (about 5 inches below the handle cross bar) (Fig. 19, position C). #"+( Immediately push the mower over the newspaper ball. Turn off the engine. Walk around the mower to check for the newspaper ball. If the ball did not go under the deck, repeat steps 5-11.
PAGE 13
whenever the mower's engine is running, and keep bystanders away as well. POTENTIAL HAZARD • If the Blade Brake Clutch system is inoperative, blade will continue to rotate when control bar is released. Contact with blade could occur. WHAT CAN HAPPEN • Blade contact can cause serious personal injury or death. HOW TO AVOID THE HAZARD • Never use a BBC equipped power mower with an inoperative safety system.
PAGE 14
" # ! " # ! #" " Service Item After every use Service Operation 5 Hours 25 Hours Housing Clean built-up grass clippings and dirt. Fasteners Check blade and engine mounting fasteners frequently. Keep all nuts, bolts and screws tight to be sure the mower is in safe working condition. Lubrication Grease rear grease fittings. X Spark Plug Inspect every 25 hours and replace if necessary.
PAGE 15
MAINTENANCE 1. Stop engine and wait for it to cool. Pull wire off spark plug (Fig. 10). 1 2 2. Clean around spark plug and remove plug from cylinder head. IMPORTANT: Replace a cracked, fouled, or dirty spark plug. Do not sand blast, scrape, or clean electrodes because engine damage could result from grit entering cylinder. 3. Set air gap at 0.5 mm (0.020") (Fig. 21). Install correctly gapped spark plug and gasket seal. Tighten plug firmly to 19 N m (14 ft-lb). 3 ÎÎÎÎ ÎÎÎÎ ÎÎÎÎ .5 mm (0.
PAGE 16
Reconnect spark plug wire. If mower does not self-propel or has a tendency to creep forward when drive is not engaged, an adjustment to the wheel traction control cable is necessary. Stop engine and pull wire off spark plug (Fig. 10). Lift control bar until some resistance is felt. Control bar should be 38 mm (1! 2") from handle when properly adjusted (Fig. 24).
PAGE 17
! Stop engine and pull wire off spark plug (Fig. 10). Drain gasoline from fuel tank; refer to Draining Gasoline, page 15. Tip mower on its left side. Avoid rotating blade as starting problems may result. INSPECTING BLADEĊCarefully examine blade for sharpness and wear, especially where flat and curved parts meet (Fig. 26A).
PAGE 18
! " ! After every 25 operating hours or when season ends, front and rear wheels must be lubricated. Apply two or three drops of light oil on inside and outside of all wheel bolts. Spin wheels to distribute oil into bushings. Wipe up excess oil. 300 Move rear wheel height-of-cut levers to 2" setting. Wipe grease fittings with clean rag (Fig. 29). Install grease gun onto fitting and gently apply two or three pumps of #2 Multi-Purpose Lithium Base Grease. $.%%+ -#+%* )'1.
PAGE 19
$! ' ! , &! '/. $ -$%!' ) .$! ,! !$%) .$! + )!' - ,!!) -$*/' ! '! )! +!,%* % ''2 . .$! !) *" ! $ (*1%)# -! -*) . (%)%(/( .* !)-/,! !-. +!,"*,( ) ! ) .* +,!0!). + ,.- !#, .%*) , %) # -*'%)! ",*( "/!' . )& ,!"!, .* , %)%)# -*'%)! + #! %+ (*1!, *) %.- '!". -% ! %# !(*0! .1* ' ! )/.- ).% - '+ /+ ' ! ' ! -+ !, ,*. .%)# - ,!!) ) "*/, *'.- -! /,%)# -$%!' .
PAGE 20
To ensure best performance, keep underside of mower housing and inside of discharge area clean. !-&')% $.&*# Whenever the underside of the mower requires cleaning, follow this procedure for washing debris out from underside of deck. Position mower on a flat concrete or asphalt surface near a garden hose. 295 '%/,$ Start the engine. Use a hard wood scraper to remove dirt and grass clippings that stick to housing. Avoid burrs and sharp edges.
PAGE 21
#!"- ' %% '.-, (%-, ' , + 0, % ' #+- " !+ ,, %#))#'!, ' !+#& +(& 1- +' % ) +-, ( -" '!#' ,"+(. #'! ' -() ( &(0 + "(.,#'! % ' #+ % ' + + + -( +/# #'! #+ % ' + ) ! . +# - -" 0" %, + + -( . +# -#(' ) ! (. " .) %% +.,- (+ "#)) ) #'- ,.+ , (+( (- ) #'- #, / #% % +(& ' .
PAGE 22
! ( ' $* & The Toro Company guarantees that your TORO GTS 200 Engine will start on the first or second pull for five years from the date of purchaseĊif you provide the routine maintenance it requiresĊor we will fix it. The cost of parts and labor are included, but you must pay transportation costs.
PAGE 23
! ! ! ! & "'$% % $( $ ! $ ! ! " ! ' $ & % # $ ' ") $ &"$
PAGE 24