Service Manual
Table Of Contents
- Title Page
- Revision History
- Reader Comments
- Preface
- Table Of Contents
- 1 - Safety
- 2 - Product Records and Maintenance
- 3 - Kubota Diesel Engine
- 4 - Hydraulic System
- Specifications
- General Information
- Hydraulic Schematics
- Hydraulic Flow Diagrams
- Special Tools
- Troubleshooting
- Testing
- Traction System Operation Testing
- Charge Relief Valve Pressure Test (Using Pressure Gauge)
- Transmission Piston Pump Flow Test (Using Tester with Pressure Gauges and Flow Meter)
- Traction Relief Valve Pressure Test (Using Tester with Pressure Gauges and Flow Meter)
- Wheel Motor Efficiency Test (Using Tester with Pressure Gauges and Flow Meter)
- PTO Pressure Valve Test (Using Pressure Gauge)
- Implement Relief Pressure Test (Using Pressure Gauge)
- Gear Pump Flow Test (Using Tester with Pressure Gauges and Flow Meter)
- Lift Cylinder Internal Leakage Test
- Service and Repairs
- General Precautions for Removing and Installing Hydraulic System Components
- Flush Hydraulic System
- Charge Hydraulic System
- Hydraulic Tank
- Wheel Motors
- Wheel Motor Service
- Transmission
- Transmission Service
- Gear Pump
- Gear Pump Service
- Manual Lift Control Valve (SN Below 313000000)
- Manual Lift Control Valve Service (SN Below 313000000)
- Lift Control Manifold (SN Above 313000000)
- Lift Control Manifold Service (SN Above 313000000)
- Polar TracTM Hydraulic Control Valve
- Polar TracTM Hydraulic Control Valve Service
- Lift Cylinder
- Lift Cylinder Service
- Polar TracTM Lift Cylinder
- Polar TracTM Lift Cylinder Service
- Oil Cooler
- 5 - Electrical System
- Electrical Schematics and Diagrams
- Special Tools
- Troubleshooting
- Electrical System Quick Checks
- Component Testing
- Ignition Switch
- Indicator Lights
- Hour Meter
- PTO Switch
- Neutral Switches
- Seat Switch
- Parking Brake Switch (SN Below 310000000)
- Parking Brake Switch (SN Above 310000000)
- Standard Control Module
- Standard Control Module Logic Chart
- PTO Solenoid Valve Coil
- Lift Control Manifold Solenoid Valve Coils (SN Above 313000000)
- Fusible Link Harness
- Diode Assembly
- Glow Relay
- High Temperature Warning Switch
- High Temperature Shutdown Switch
- Dual Temperature Switch (Polar TracTM Machines)
- Deck Lift/Lower Switch (SN Above 313000000)
- Fuel Pump
- Fuel Stop Solenoid
- Glow Controller
- Service and Repairs
- 6 - Chassis
- 7 - Cutting Deck
- 8 - Foldout Diagrams
- Electrical Drawing Designations
- Hydraulic Schematics
- Hydraulic Schematic (SN Below 313000000)
- Hydraulic Schematic (SN Below 313000000) with Rear Attach Lift Kit
- Hydraulic Schematic (SN Below 313000000) with Polar Trac Installed)
- Hydraulic Schematic (SN Below 313000000) with Polar Trac and Rear Attach Lift Kit
- Hydraulic Schematic (SN From 313000001 to 314999999)
- Hydraulic Schematic (SN Above 315000000)
- Electrical Schematics
- Circuit Diagrams
- Wire Harness
Groundsmaster 7200/7210Page 3 – 10Kubota Diesel Engine
Fuel System
Figure 7
1. LH fuel tank
2. RH fuel tank
3. Fuel cap
4. LH vent tube
5. RH vent tube
6. Vent hose
7. Tee fitting
8. Flange nut
9. Fuel hose
10. Fuel pump
11. Fuel hose
12. R–clamp
13. Cap screw
14. Fuel filter
15. Hose clamp
16. Cable tie
17. Nut (3 used)
18. Washer head screw (3 used)
19. Spacer
20. R–clamp (2 used)
21. Fuel gauge
22. Clamp (4 used)
23. Cap screw (4 used)
24. Flange nut (4 used)
25. Spacer
26. Shield washer (2 used)
27. Cap screw
28. Flange nut (2 used)
29. Toolbox cover
30. Washer head screw (6 used)
31. Fuel hose
32. Hinge
33. Flange head screw
34. R–clamp
35. Rivet (2 used)
36. Flat washer (2 used)
37. Rubber washer (2 used)
38. Foam pad (4 used)
39. Grommet
40. Elbow fitting
41. Bushing (3 used)
42. Elbow fitting (2 used)
43. Hose clamp (2 used)
44. Strainer fitting (2 used)
FRONT
RIGHT
17
29
30
32
30 3
1
6
27
26
25
28
24
22
23
35
20
4
15
6
5
13
26
19
6
2
15
15
15
12
14
15
9
15
10
18
15
18
3
15
11
7
31
21
16
16
11
15
34
8
33
15
15
39
41
40
42
44
43
41
42
44
43
36
37
37
36
38