Service Manual

Groundsmaster 4100−D Page 5 − 1 Electrical System
Chapter 5
Electrical System
Table of Contents
ELECTRICAL SCHEMATIC, CIRCUIT DIAGRAMS,
AND WIRE HARNESS DRAWINGS 2. . . . . . . . . . . .
SPECIAL TOOLS 3. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TROUBLESHOOTING 4. . . . . . . . . . . . . . . . . . . . . . . . .
Starting Problems 4. . . . . . . . . . . . . . . . . . . . . . . . . . .
General Run & Transport Problems 5. . . . . . . . . . . .
Cutting Deck Operating Problems 6. . . . . . . . . . . . .
ELECTRICAL SYSTEM QUICK CHECKS 7. . . . . . . .
Battery Test (Open Circuit Test) 7. . . . . . . . . . . . . . .
Check Operation of Interlock Switches 7. . . . . . . . .
ADJUSTMENTS 8. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wing Deck Position Switches 8. . . . . . . . . . . . . . . . .
Cutting Deck Raise and Lower Switches 9. . . . . . .
COMPONENT TESTING 10. . . . . . . . . . . . . . . . . . . . . .
Ignition Switch 10. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuses 11. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Warning Lights 12. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PTO Switch 13. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Audio Alarm 13. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Transport, Alarm Silence, and
Temperature Override Switches 14. . . . . . . . . . . .
Seat Switch 15. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parking Brake Switch 15. . . . . . . . . . . . . . . . . . . . . . .
Hour Meter 16. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Glow Relay 16. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Start, Engine Shutdown, Seat, PTO, Alarm,
Down Latching, and Over Temperature Relays 17
Hydraulic Valve Solenoids 18. . . . . . . . . . . . . . . . . . .
Engine Run Solenoid 19. . . . . . . . . . . . . . . . . . . . . . .
Fuel Sender 20. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Gauge 21. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Pump 22. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Glow Controller 23. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Temperature Sender 24. . . . . . . . . . . . . . . . . . . . . . . .
High Temperature Shutdown Switch 25. . . . . . . . . .
Temperature Gauge 26. . . . . . . . . . . . . . . . . . . . . . . .
Traction Neutral Switch 27. . . . . . . . . . . . . . . . . . . . .
Diode Assemblies 27. . . . . . . . . . . . . . . . . . . . . . . . . .
Diode Circuit Board 28. . . . . . . . . . . . . . . . . . . . . . . .
Wing Deck Position Switches 29. . . . . . . . . . . . . . . .
Cutting Deck Raise and Lower Switches 30. . . . . .
SERVICE AND REPAIRS 31. . . . . . . . . . . . . . . . . . . . .
Hydraulic Valve Solenoids 31. . . . . . . . . . . . . . . . . . .
Battery Storage 32. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery Care 32. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery Service 33. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Electrical
System