Installation Instructions

ManualsBrandsToro ManualsAttachmentsRight-Hand Replacement Mower, 2011 and After Groundsmaster 4000-D Traction Unit

FormNo.3434-423RevA

Right-HandandLeft-HandReplacementMower

Decks

2011andAfterGroundsmaster

4000-DTractionUnit

ModelNo.30476—SerialNo.403300001andUp

ModelNo.30477—SerialNo.403300001andUp

InstallationInstructions

WARNING

CALIFORNIA

Proposition65Warning

Useofthisproductmaycauseexposure

tochemicalsknowntotheStateof

Californiatocausecancer,birthdefects,

orotherreproductiveharm.

Safety

SafetyandInstructional

Decals

Safetydecalsandinstructionsare

easilyvisibletotheoperatorandare

locatednearanyareaofpotential

danger.

decal133-8061

133-8061

Installation

RemovingtheHydraulic

Motor

1.Parkthemachineonalevelsurface,lowerthe

mowerdeck,engagetheparkingbrake,shutoff

theengine,andremovethekey.

2.EnsurethatthetractionpedalisintheNEUTRAL

positionandthePTOleverisintheOFFposition.

3.Removetheboltssecuringthehydraulicmotor

tothedeck(Figure1).

4.Liftthemotoroffthedeckandlayitonaclean

surfaceoutoftheway.

Note:Ensurethatyoudonotdamage

aluminumcoupler.

g011511

Figure1

1.Hydraulicmotor2.Mountingbolts

5.Removetheelastomericspiderfrominsidethe

pulleycoupler.Inspectitforwearandreplaceit

ifitisworn.Otherwise,retainittoinstallonthe

newdeck(Figure2).

Note:Inspectthespiderhubforwearand

replaceitifitisworn(Figure2).

8111LyndaleAvenueSouth

Bloomington,MN55420

Registeratwww.T oro.com.

OriginalInstructions(EN)

PrintedintheUSA

AllRightsReserved

*3434-423*A

Summary of content (8 pages)

PAGE 1
Form No. 3434-423 Rev A Right-Hand and Left-Hand Replacement Mower Decks 2011 and After Groundsmaster® 4000-D Traction Unit Model No. 30476—Serial No. 403300001 and Up Model No. 30477—Serial No. 403300001 and Up Installation Instructions Installation WARNING CALIFORNIA Proposition 65 Warning Use of this product may cause exposure to chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm. Removing the Hydraulic Motor 1.
PAGE 2
g011595 Figure 2 1. Spider 3. Pulley coupler 2. Spider hub Replacing the Side Mower Deck 1. g011598 Figure 4 1. Lift-arm mount Remove the hairpin cotter and clevis pin securing the height-of-cut link to the height-of-cut bracket on the deck (Figure 3). 2. Mounting bolts, washers, and locknuts (8) 3. Move the mower deck away from the traction unit. 4. Slide the new mower deck into position and mount it to the traction unit by reversing this procedure. 5.
PAGE 3
edge at 2 locations as indicated in Figure 5. Rim and paint irregularities make the outer edge an unreliable point of measure. These 2 measurements should be within 3 mm (1/8 inch) of each other. D. If the deck is not aligned with the traction unit, loosen the jam nut on the rod end of the wing-deck shock-arm assembly (Figure 6). Adjust the coupler so that it freely rotates inside the shock-absorption tube. Make all adjustments with the rod end of the shock arm bolted to the deck. g011600 Figure 6 1.
PAGE 4
Notes:
PAGE 5
Notes:
PAGE 6
Notes:
PAGE 7
The Toro Warranty Two-Year or 1,500 Hours Limited Warranty Conditions and Products Covered Parts The Toro Company and its affiliate, Toro Warranty Company, pursuant to an agreement between them, jointly warrant your Toro Commercial product (“Product”) to be free from defects in materials or workmanship for 2 years or 1,500 operational hours*, whichever occurs first. This warranty is applicable to all products with the exception of Aerators (refer to separate warranty statements for these products).
PAGE 8
California Proposition 65 Warning Information What is this warning? You may see a product for sale that has a warning label like the following: WARNING: Cancer and Reproductive Harm—www.p65Warnings.ca.gov. What is Prop 65? Prop 65 applies to any company operating in California, selling products in California, or manufacturing products that may be sold in or brought into California.