| s-Speed Wheel Horse Operator’s Manual Garden Tractors .
FOR YOUR SAFETY Two of the most potentially serious types of accidents and follow these instructions. Also refer to the Safe involving power mowers are contact with the mower Operation Practice in this Operator's Manual for other blade and overturning the rider/tractor To minimize important safety information.
DANGER! Mower Blades are Designed to CUT: therefore, ALWAYS: OPERATE ONLY WITH DEFLECTOR OR CATCHER IN PLACE KEEP HANDS and FEET AWAY « Shut off engine and set parking brake, * Remove ignition key. o Allow moving parts {o stop before dismounting, servicing, or cleaning unit. NEVER: « Perform ANY work on the mower with engine uniting. « Mow with other people around, especially children, *» Leave mower unattended. A\ DANGER LORELEI N D @ *KEEP HANDS AND FEET CLEAR OF BLADE AT ALL TIMES.
DECALS WITH LOCATIONS L LT LU DEPRESS BRAKE PEDAL AND PULL T0 DISENGAGE: L3311 LEFT SIDE ON FRAME PLATE NEXT TO PARKING BRAKE CONTROL PART NUMBER 111510 TRV BATTERY DISCONNECTED. DAMAGE 10 ELECTRICAL SYSTEM WILL RESULT.
CONTENTS Page Tractor Specifications i General Safety Suggestions 1V, V, VI Model and Serial Number 1 Registration and Warranty 1 Parts Manual 1 Instruments and Controls 23 Operating Your Tractor 4-5 Safety Interlock System 4 Seat Control 4 Correct Engine Operation 4 Starting Engine 4 Stopping Engine 4 Throttle and Choke Control 4 Fuel Specification 5 Oil Specification 5 Correct Mechanical Transmission Operation 3 To Go Forward or Reverse 5 To Change Speeds or Direction 5 To Stop 5 Correct Tractor Usage 68
SPECIFICATIONS: ENGINE: TRACTOR ENGINE RATED DISPLACEMENT BORE STROKE IGNITION MODEL MODEL* HAM cu. Inject in/mm infirm 310 Mimi 10 325826 288729 Electronic 312 M128 12 338857 3268286 Electronic 416 P16 16 433710 25266 Electronic “Latter Fro fix: Mueller and PROCTOR POWER FLOES. Basic engines morel number shown; yps and serial umbras from angina LD, plate are required to completely identity engine.
SAFE OPERATION PRACTICES — RIDING VEHICLES GENERAL This machine is capable of amputating hands wind feet and can throw objects that can course injury and damage. KNOW the controls and how to stop machine quickly. READ THIS OPERATOR'S MANUAL and instructions furnished with attachments, Read, understand, and obey all safety messages appearing on the machine and in the operator’s manual, LEARN from your operator’s manual and from careful EXPERIENCE how to operate your equipment correctly.
4, The parking brake is designed to hold tractor in place ot rest, with engine off. Parking brake will net restrain tractor with engine running and transmission engaged, STABILITY /OVERREACTION Know the terrain on which you are operating your equipment. There are areas on which your equipment can not be safely operated, Avoid operating equipment on hillsides, slopes or rough terrain, DO NOT operate machine on hillsides or slopes exceeding 15° (27% grade).
Keep vehicle and attachments in good operating condition and keep safety devices in place und working. Under normal usage, grass catcher bag material is subject to deterioration ond weir. It should be checked frequently to determine need for bug replacement. Use only genuine Wheel Horse replacement parts to assure that original standards are maintained. Shields, deflectors, switches, blade controls and other safety devices must be in their proper position and functional.
MODEL AND SERIAL NUMBER LOCATIONS Model and Serial numbers are used 1o identify your new tractor and major attachments. These numbers should always be referred to when consulting dealer or factory concerning service, parts, or other information you may require. If these plates are removed during repair operations, they should always be replaced. Tractor made! and serial number plate is located just below seat on rear fender.
INSTRUMENTS AND CONTROLS 5 Indicator light test switch is used to check fight bulbs and photoelectrically. Pus hon test switchover lights “On” or “Flashing™; if one or more lights are out check wiring and replace circuit board, or bulb assembly on 310, if necessary as outlined in “Maintenance” section of this manual. If PTO clutch or clutch pedal light is on when attempting to start engine, check that control is in proper position for starting.
OPERATING YOUR TRACTOR SAFETY INTERLOCK SYSTEM Satiety interlock system incorporates two switches for safe starting and a seat switch that shuts off engine when driver raises off seat with PTO engaged. Starting switches are actuated by left toot pedal and PTO church control. i tractor will not start, check that PTO clutch is disengaged and left foot pedal is depressed. Indicator fights will be on {if so equipped) and engine will not start unless both switches are properly actuated.
Pushing down on clutch pedal does two things: (1) Clutches transmission drive belt from engine; {2) Actuates a safety interlock switch so starter will operate. Engaging clutch is done by releasing pedal which tightens transmission drive belt. Always release pedal slowly when engaging clutch. Always depress pedal when shifting transmission into or out of gear and when starting engine. Indicator light comes on, ifs quadruped with pedal released and ignition key in stein po\ i / Power driven attachments are en
used to regulate ground speed of tractor, The engine in your new Toto Wheel Horse has been designed with a special governor that limits maximum RPM. The governor allows engine {o operate most efficiently at a tsetse, and protects it from garage caused by excessive RPM. Always operate tractor with throttle control set at full spewed. Engine MUST be operating at full throttles whenever tractor ia in use.
CORRECT TRACTOR USAGE A caution A Read manuals provided with attachments before operating. Manuals give a more detailed description of operation and point out other areas of caution, Familiarize yourself thoroughly with equipment before attempting to use it. ATTACHMENT MOUNTING Hitches Attach-a-masc front and mid hitches are provided for easy installation and removal of attachments without tools.
weights and tire chains will minimize rear tire slippage. All tires may be fluid filled, WITH A MOWER Kemp al) shields | pica. Brezhnev pii Forbes payphone on average \awns, opera\e engine artful throttle while controlling ground speed with transmission. Tracer should be operated at 210 3.5 MPH (3.210 5.6 km* while mowing grass. Uneven cutting is often a result of excessive ground speed. Ta correct, reduce ground speed with transmission. Average lawns are usually cut at a height between 2 and 3 in. (5-7.
After dicing, generally, a spike tooth harrow helps pulverize doll and levels seed bed. Soil should now be ready for planting. Cultivator is used during growing season to help remove unwanted weeds, and ic help aerate plant roots. Generally, width of cultivator is taken into consideration before planting seed bed to insure cultivator fitting between rows without damaging crop roots. WITH A REAR BEGGAR Optional rear mount grass catcher can affect way tractor is operated.
MAINTENANCE % 7 oy, territorial o Tractor with engine off MAINTENANCE CHECKLIST NOTE: These serviced e factorials are adoration MAXIMUM under normal conditions. Incense ra quondam Under extremely . dint or dusty conditions. Every 100 Hours /1 Yeomanry Every 200 Hours/1 ezl Before Och Use After Each Use Every 25 Hours Every 50 Hours Every 1600 Hours SERVICE OPERATION 3 CHECK: Safety interlock System | X Engine Oli Level X Barbary Water Level sped.
Be sure to add same viscosity ol as is presently in engine. New tractors are shipped with 10W-30 oil in crankcase, It may be necessary to change original oit before using tractor in cold weather, Oil Changes Failure to change engine oil at recommend intervals can lead to serous damage to engine.
ENGINE Ol TEMPERATURE VISCOSITY CHART Kohl er Engine Air Temperature Above 32 degrees F (0 degrees G} SAE 30 Below 32 degrees F {0 degrees C) SAE 5-20, 5W.30 TOR POWER PLUS Engine USE THESE SAE VISCOSITY GRADES il Viscosity TEMPERATURE RANGE YOU EXPECT BEFORE NEXT O CHANGE After adding 80% of prescribed amount of ofl, check oil level. Add ofl as necessary to bring oil to “Full” feel or into “Safe” range on engine oif dipstick. NEVER overtire engine crankcase with oil.
To prevent any dirt or other contaminates from entering ethylene, always cover carburetor alr horn when alr cleaner is removed. LOWER HOUSING KNOB PER-CLEANER < ELEMENT WING NUT SPACER era Alr Cleaner Assembly Dry type air filter element is cleaned by tapping it lightly on flat surface 1o remove loose dirt particles. Replace element it dirt doss no drop off easily. Do not wash elements in liquid. Dakotan attempt to blow dirt off with compressed air as this can puncture filter element.
Tractor Model Plug Gap All Models 025 in. {6 mm} Tighten spark plug(s) to: Al Models 15 ft. Ibs. (20 nm) Electronic Ignition Breaker less electronic ignition system requires no periodic maintenance. Fuel System On 310,312 models, a fine-mesh screen type strainer is incorporated into fitting at bottom of fuel tank, which filters foreign matter from gasoline before it reaches carburetor. This strainer normally requires service only if fuel supply becomes severely contaminated.
Main Fuse A 25 amp automotive type ATO or ATC fuse is used to protect main circuit of electrical system. — 416 Model Fuse Location Light Circuit Fuse Microcircuits powered by battery. Lights will operate when ignition switch is in“Hun” position. A 15 amp automotive type ATO or ATC fuse is part of light circuit, Gage Circuit Fuse Gage circuits are protected by light circuit 15 amp automotive type ATO or ATC fuse.
8-Spewed Transmission Dipstick CHASSIS LUBRICATION Steering gear, brake pedal, clutch petal, spindles, front wheel bearings and front axis pivot are equipped with fittings 1o facilitate lubrication with a pressure grease gun. Before applying grease fun, clean zero fittings carefully to prevent dirt from being forced into fitting. After inserting grease, wipe off any excess grease. A general purpose grease ([lithium base} is used io lubricate tractor.
EXHAUST SYSTEM Make regular visible and audible inspections of exhaust system throughout rife of tractor. Locate leaks in muffler and piping while engine Is operating. Repair all leaks immediately after they are detected for personnel safety. A penance \ atlas of exhaust guess h el \ urinal an) signal Injury or death. Acting exurbia ably ahd visually for leeks dally. Coincidentally. CLEANING AND STORAGE Tractor should be washed regularly with a mild automotive detergent and water.
TROUBLESHOOTING CHECKLIST SYMPTOM Engine will not turn over, POSSIBLE CAUSE Dead battery. Open safety interlock switch. Starter. Solenoid, Ignition switch, POSSIBLE REMEDY Charge or replace battery. Be sure PTO is disengaged and brake pedal is depressed. Consult authorized dealer, Consult authorized dealer. Consult authorized dealer, Engine turns over but will not start. Spark plug not firing. Ignition system. No fuel in tank. Fuel valve closed. Improper carburetor adjustment. ignition switch.
TROUBLESHOOTING CHECKLIST (Continued) SYMPTOM Engine knocks, POSSIBLE CAUSE Fuel octane too low. Faulty Ignition System. Engine overheated. POSSIBLE REMEDY Drain fuel and replace with higher octane supply. Consult authorized dealer. Shut off engine ond allow to cool. Engine occasionally “skips” at high speed. Spark plug(s) fouled, faulty or gap too wide. Faulty Ignition System, Incorrect carburetor adjustment. Check spark plug condition and gap. Consult authorized dealer.
WIRING DIAGRAM 310 MODEL HEADLIGHTS LY. GREEN LT, GREEN LIGHT e ORANGE RED OPTIONAL HOUR LIGHT SWITCH o TEST SWITCH PINK 15 AMP FUSE (A} RECTIFIER -ENGINE ol SWITCH STARTER BLUEBEARD TAN LY, BLUE NG CONTACTS [ope N WHEN BTG DISENGAGED BATTERY, current @ NEUTRAL SAFETY SWITCH 18] 1] Horseless. PTO INTERLOCK SWITCHES §8.0.CONTACTS CLOSED WHEN PTO DISENGAGED SWITCH POSITION, ELECTRICAL CONN, BETWEEN TERMINUS. OFF GM+A (SWITCH CASE.
WIRING DIAGRAM 312 BLACK ‘ FINK 2 & £ AEE%58%8 & 2 LIGHT BLUE 1]213]a]5 e D8 ORANGE LTI GND. o bevel] p fells LIGHT BLUE ENGINE . o ORANGE o800 aag) [start Er } REG) I TaN = suck] |8 i BLACK 4 DARK BLUE. g SEAT ORANGE. ¥ LIGHT Wired PTO SWITCHES] GREEN & AN (PTO ENGAGED) GRAY WHITE PARKING BRAKE |o PURPLE wirehair PURPLE TEST SWITCH] RED RED 15 AMP FUSE 25 AMP FUSE ¢ [l PNk BATTERY HEADLIGHT SWITCH BLACK/LIGHT GREEN HEADLIGHTS BLACK LIGHT GREEN TAIL LIGHTS BLACK LIGHT GREEN Switch POSITION ELECTRICAL CONN.
A separate parts manual for your Toto Wheel Horse product can be obtained by completing the attached form below. You will receive an invoice with manual. PUBLICATIONS TOR WHEEL HORSE 8111 Tyndale Ave. So. Blooming ton, Minnesota 55420 MAIL LABEL -PLEASE PRINT CLEARLY PARTS MANUAL ORDER FORM enter number shown on your attachment: To: Name Address.
10° SLOPE CHART Read all safety instructions on pages 3-6 ALIGN THIS EDGE WITH A VERTICAL SURFACE {TREE, BUILDING, FENCE POST, POLE ETC )