FORM NO, 3310572 MODEL NG, & UP OWNER'S MODEL NO, & UP MANUAL 826 AND 832 SNOW THROWERS SAFETY INSTRUCTIONS BEST COPY AVAILABLE CAUTION: This Snow thrower is engineered end tested to offer reasonably safe and effective service, provided it is operated in discordance with these instructions. FAILURE 110 po s MAY RESULT IN PERSONAL IN ! TRAINING 1. Never allow children to operate a snow thrower or adults to operate sit without proper instruction. 2.
TABLE OF CONTENTS Loos Parts Chart General Assembly \nsxrucmms Tire Pressure Preparation Before Samsung Filling With Oil e Filling With Gasoline Fuel Shut-Off Know Your Controls Operating Instructions Starting Special Low Temperature Staving Procedure Stopping & Emergency Stopping Auger Impeller Clutch Left & Right Hand Wheel Catches Safety Interlock System Transport . ..
LOOSE PARTS ASCRIPTION DESCRIPTION QUANTITY Truncation & Shift Rod Assembly 1 Hax Flange Resew 4 Clovis Pin 1 Pyramidal Washer i Hair Pin Cotter 1 Lockout ' : Tab 3 Kot V Tab Spacer 3 ° . Hex Case 5 Hex Ems Screw 7 Lockout 5 Lockout 2 Clevis Pin 1 Knob 1 Cotter Pin 1 Clevis Pin 1 Owner’s manual 1 Cotter Pin 1 Registration Card 1 bag containing hardware. Unpack your snowstorm with care to avoid damaging the unit or misplacing the loose parts.
PREPARATION BEFORE STARTING The engine bas been shipped tram the Factory without il anus gasoline. Othello, 3t is essential that the Preparation Before Starting constructions in this manual be strictly followed FILLING WITH Ol 1 Pi gee snow thrower on a level surface and remove o filler plug from #opine 2. Using 3 tunnel, slowly pour forty-four (48] lounges (2% pints} of a good grade classification SABRE-20 or 10W ol into the crankcase until the point of overflowing. 3.
OPERATING INSTRUCTIONS (Continued) 2. Move choke fever to full choke and throttle control lever to start position. Pull starter rope om or more times until engine fires at feast acne. A “pop’ at the muffler indicates the engine is firing. 3. Open choke slightly. 4 Pull starter again — engine shouts start. 5, As engine begins to run, open choke gradually. 6. Engine begins to die, close choke sightly. i NOTE: If fuel drips out of carburetor while trying ta start engine, the engine is over choked.
OPERATING INSTRUCTIONS (Continued) TRANSPORT When moving unit from one place Lo another (by pushing pull both wheel clutch knobs sut. TIPS ON SNOW THROWING 1. Always have gear shift fever in "N {Notional) and close fuel shut-off valve when machine is not in use. 2. Use forward speed best suited to conditions, A RULE OF THUMB: If drive wheels are slipping, your forward speed should be reduced. 3. Whenever possible, discharges stow downwind 4. Always overlap each pass slightly to assure complete stow removal.
MAINTENANCE {Continued) Jo Replace vit drat cap rand wearable Seth oil (See Fitting REPLACING V-BELTS With Oit, page 51 H the traction o auger dive lets become worn, silhouetted, CHANGING AUGER GEAR BOX OIL o oit sealed o the point they are ao longer efficient, Change gear oi} once o yer. Drain oil tater age i b they should be replaced. Proceed as Hollows: i operation; oif will be warm st fow gaily. 1. Disconnect the spark fug wire 1. Remove gas from gas tank, 2. Remove the belt guard, 2.
MAINTENANCE (Continued) Figaro 26 NOTE: 1 unit will not drive {(forward or reverse), even after the proper adjustment has been made, contact your local Toto Service Dealer. 8. If ground speed in first gear is oo slow of too fast, difficult to get shift lever into third gear slot, the {following adjustment may be necessary: Loosen the two nuts shown in Figure 27.
in the event the engine is to be stored for any length of tine {30 days or more} or at the end of the withdrawing season, prepare it as outlined in the following steps: N Remove fuel from tank. 2. OFF SEASON STORAGE Start engine ta use all fuel in carburetor and tine. When engine starts 1o sputter, operate choke which will drain carburetor. Remove spark plug and pour one {1} ounce of lubricating oil {SAE 30 in cylinder — Crank engine several times to distribute oil and replace plug.
OPTIONAL EQUIPMENT SNOW CAB 110V ELECTRIC STARTING KiT TIRE CHAINS DRIFT BREAKER-STORAGE BAR HEAVY DUTY SKIS THE TOR PROMISE 1t is Toto's policy to design and produce TOR products to provide ot customers with a high revel of performance and durability in normal petition. Our products, hover, sty produce's i high volume, and it is inevitable that accusingly @ unit will reach @ customer with a defeat in materials or workmanship which causes that unit to fall below the-normal high feel of TOR performance.