Operator's Manual
2
All Rights Reserved
Printed in the USA
2002 by The Toro Company
8111 Lyndale Avenue South
Bloomington, MN 55420-1196
Contents
Page
Introduction 2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety 3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Before Operating 3. . . . . . . . . . . . . . . . . . . . . . . . . .
While Operating 3. . . . . . . . . . . . . . . . . . . . . . . . . . .
Maintenance 3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety and Instruction Decals 5. . . . . . . . . . . . . . . . .
Specifications 6. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Specifications 6. . . . . . . . . . . . . . . . . . . . .
Measurements 7. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Optional Equipment 7. . . . . . . . . . . . . . . . . . . . . . . .
Setup 7. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tractor Preparation 8. . . . . . . . . . . . . . . . . . . . . . . . .
Install Jack 9. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adjust Hitch 9. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Install Control Tower 10. . . . . . . . . . . . . . . . . . . . . . .
Mount Control Linkage And Levers 10. . . . . . . . . . .
Connect Supply/Return Hoses To Tractor 12. . . . . . .
Install Lift Chains 12. . . . . . . . . . . . . . . . . . . . . . . . . .
Install Drawbar 12. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Install Reelmaster Mowers 13. . . . . . . . . . . . . . . . . . .
Check Tire Pressure 13. . . . . . . . . . . . . . . . . . . . . . . .
Operation 14. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Controls 14. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Training Operation 14. . . . . . . . . . . . . . . . . . . . . . . . .
Mowing Operation 15. . . . . . . . . . . . . . . . . . . . . . . . .
Transport Operation 15. . . . . . . . . . . . . . . . . . . . . . . .
Inspection And Clean–up After Mowing 17. . . . . . . .
Lubrication 18. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Maintenance 20. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Changing Hydraulic Fluid 20. . . . . . . . . . . . . . . . . . .
Wheel Bearings 20. . . . . . . . . . . . . . . . . . . . . . . . . . .
Lift Arm Bushing Replacement 21. . . . . . . . . . . . . . .
Hydraulic Schematic 22. . . . . . . . . . . . . . . . . . . . . . .
The Toro General Commercial Products Warranty 24. . .
Introduction
Read this manual carefully to learn how to operate and
maintain your product properly. The information in this
manual can help you and others avoid injury and product
damage. Although Toro designs and produces safe
products, you are responsible for operating the product
properly and safely.
Whenever you need service, genuine Toro parts, or
additional information, contact an Authorized Service
Dealer or Toro Customer Service and have the model and
serial numbers of your product ready. The two numbers are
stamped on a plate which is located on the left frame
channel.
Write the product model and serial numbers in the space
below:
Model No.
Serial No.
This manual identifies potential hazards and has special
safety messages that help you and others avoid personal
injury and even death. Danger, Warning, and Caution are
signal words used to identify the level of hazard. However,
regardless of the hazard, be extremely careful.
Danger signals an extreme hazard that will cause serious
injury or death if you do not follow the recommended
precautions.
Warning signals a hazard that may cause serious injury or
death if you do not follow the recommended precautions.
Caution signals a hazard that may cause minor or moderate
injury if you do not follow the recommended precautions.
This manual uses two other words to highlight information.
Important calls attention to special mechanical
information and Note: emphasizes general information
worthy of special attention.