Setup Instructions

ManualsBrandsToro ManualsSprayers46in Sprayer, SprayMaster

36IN,46IN,AND52INSPREADER/SPRAYER

SetupInstructions

LooseParts

Usethechartbelowtoverifythatallpartshavebeenshipped.Partnumbersnotshownareavailableonthedealer

extranet.

DealerPack

PartNo.DescriptionQty.Use

—

10W-50engineoilserviceclassication

SJorhigher

required

Servicetheengine.

—

15W-50hydraulicuidAPIrating

CI-4/CF

required

Servicethehydraulicoil.

LiteraturePack

Manual,Operator's

Manual,EngineOwner

CheckingTirePressure

1.Checkthetirepressureinalltires.Properination

is18psi(124kPa).

2.Adjustifnecessary.

ServicingtheBattery

Important:Themachineisshippedwithalled

leadacidbattery.

DANGER

Chargingorjumpstartingthebatterymayproduce

explosivegases.Batterygasescanexplodecausing

seriousinjury.

•Keepsparks,ames,orcigarettesawayfrom

battery.

•Ventilatewhenchargingorusingbatteryinan

enclosedspace.

•Makesureventingpathofbatteryisalwaysopen

oncebatteryislledwithacid.

•Alwaysshieldeyesandfacefrombattery.

DANGER

Batteryelectrolytecontainssulfuricacid,whichis

poisonousandcancausesevereburns.Swallowing

electrolytecanbefatalorifittouchesskincan

causesevereburns.

•Wearsafetyglassestoshieldeyes,andrubber

glovestoprotectskinandclothingwhen

handlingelectrolyte.

•DoNotswallowelectrolyte.

•Intheeventofanaccident,ushwithwaterand

calladoctorimmediately.

1.Checkthevoltageofthebatterywithadigital

voltmeter.Locatethevoltagereadingofthebattery

inthetablebelowandchargethebatteryforthe

recommendedtimeintervaltobringthechargeup

toafullchargeof12.6voltsorgreater.

Important:Makesurethenegativebattery

cableisdisconnectedandthebatterycharger

usedforchargingthebatteryshouldhave

anoutputof16voltsand7ampsorlessto

avoiddamagingthebattery(seechartfor

recommendedchargersettings).

PartNo.3432-141Rev.A

PrintedintheUSA

AllRightsReserved

*3432-141*A

Summary of content (3 pages)

PAGE 1
36IN, 46IN, AND 52IN SPREADER/SPRAYER Setup Instructions Loose Parts Use the chart below to verify that all parts have been shipped. Part numbers not shown are available on the dealer extranet. Dealer Pack Part No. Description Qty. Use — 10W-50 engine oil service classification SJ or higher as required Service the engine. — 15W-50 hydraulic fluid API rating CI-4/CF as required Service the hydraulic oil. Literature Pack Manual, Operator's Manual, Engine Owner Checking Tire Pressure 1.
PAGE 2
Voltage Reading Percent Charge Maximum Charger Settings Charging Interval 12.6 or greater 100% 16 volts/7 amps No Charging Required 12.4 – 12.6 75–100% 16 volts/7 amps 30 Minutes 12.2 – 12.4 50–75% 16 volts/7 amps 1 Hour 12.0–12.2 25–50% 14.4 volts/4 amps 2 Hours 11.7–12.0 0–25% 14.4 volts/4 amps 3 Hours 11.7 or less 0% 14.4 volts/2 amps 6 Hours or More Servicing the Hydraulic Oil The machine is shipped with hydraulic oil in the reservoir. 1.
PAGE 3
Installing the Cable/Display Mount Some machines may be shipped with the cable/display mount rotated to the side. 1. Remove and retain the bottom bolt g285170 Figure 2 1. Cable/display mount 3. Top bolt 2. Rotate 4. Bottom bolt 2. Loosen the top bolt enough to rotate the cable/display mount upward. 3. Line up the mount with the hole in the console. 4. Install the bottom bolt through the mount and into the console. 5. Tighten the top and bottom bolt.