Setup Instructions

ManualsBrandsToro ManualsOutdoorsPower Clear 518 ZR 18 in. Single-Stage Gas Snow Blower

FormNo.3396-416RevA

PowerClear

518ZR/ZESnowthrower

ModelNo.38472—SerialNo.316000001andUp

ModelNo.38473—SerialNo.316000001andUp

Operator'sStartGuide

Introduction

WARNING

CALIFORNIA

Proposition65Warning

Thisproductcontainsachemicalorchemicals

knowntotheStateofCaliforniatocausecancer,

birthdefects,orreproductiveharm.

Theengineexhaustfromthisproduct

containschemicalsknowntotheStateof

Californiatocausecancer,birthdefects,

orotherreproductiveharm.

Thismachineisintendedtobeusedbyresidential

homeowners.Itisdesignedprimarilyforremoving

snowfrompavedsurfaces,suchasdrivewaysand

sidewalks,andothersurfacesfortrafconresidentialor

commercialproperties.Itisnotdesignedforremoving

materialsotherthansnow,norisitdesignedforclearing

offgravelsurfaces.

Thisdocumentisintendedasasetupandquickstart

guideonly.Forcompleteoperatingandmaintenance

informationaseitheraninteractivemanualorprintablePDF

gotoWWW.TORO.COM/EN-US/PARTS/PAGES/

PARTSLOOKUP .ASPXandenteryourmodelnumber.You

canaccessthispagebyscanningthefollowingQRcode:

Figure1

Wheneveryouneedservice,genuineToroparts,oradditional

information,contactanAuthorizedServiceDealerorToro

CustomerServiceandhavethemodelandserialnumbersof

yourproductready.Figure2identiesthelocationofthe

modelandserialnumbersontheproduct.Writethenumbers

inthespaceprovided.

Figure2

1.Modelandserialnumberlocation

Thismanualidentiespotentialhazardsandhassafety

messagesidentiedbythesafetyalertsymbol(Figure3),

whichsignalsahazardthatmaycauseseriousinjuryordeath

ifyoudonotfollowtherecommendedprecautions.

Figure3

1.Safetyalertsymbol

ThisOperator’sStartGuideuses2wordstohighlight

information.Importantcallsattentiontospecialmechanical

informationandNoteemphasizesgeneralinformation

worthyofspecialattention.

Formodelswithstatedpower,thenetpoweroftheenginewas

laboratoryratedbytheenginemanufacturerinaccordance

withSAEJ1940.Asconguredtomeetsafety,emission,and

operatingrequirements,theactualenginehorsepoweronthis

classofsnowthrowerwillbesignicantlylower.

8111LyndaleAvenueSouth

Bloomington,MN55420

Registeratwww.Toro.com.

OriginalInstructions(EN)

PrintedintheUSA

AllRightsReserved

*3396-416*A

Summary of content (12 pages)

PAGE 1
Form No. 3396-416 Rev A Power Clear® 518 ZR/ZE Snowthrower Model No. 38472—Serial No. 316000001 and Up Model No. 38473—Serial No. 316000001 and Up Operator's Start Guide Introduction model and serial numbers on the product. Write the numbers in the space provided. WARNING CALIFORNIA Proposition 65 Warning This product contains a chemical or chemicals known to the State of California to cause cancer, birth defects, or reproductive harm.
PAGE 2
Contents Safety Introduction .................................................................. 1 Safety ............................................................................ 2 Safety and Instructional Decals ................................. 2 Preparing the Machine for First Use .................................. 3 Installing the Handle................................................ 3 Installing the Discharge Chute................................... 3 Filling the Engine with Oil .................
PAGE 3
117-7713 1. Warning—read the Operator’s Start Guide and the Operator's Manual. 2. Cutting/dismemberment hazard, impeller—stop the engine before leaving the machine. 4. Fuel spill hazard—do not tip machine forward or backward. 5. To engage the auger, squeeze the control bar. 6. Release the control bar to disengage the auger. 3. Thrown object hazard—keep bystanders a safe distance from the machine.
PAGE 4
Filling the Engine with Oil Your machine does not come with oil in the engine, but it does come with a bottle of oil. Important: Before starting the engine, fill the engine with oil. Max fill: 0.35 l (12 oz), type: automotive detergent oil with an API service classification of SJ, SL, or higher. Use Figure 6 to select the best oil viscosity for the outdoor temperature range expected: Figure 7 1. The oil level is at its maximum. 3. The oil level is too low—add oil to the crankcase. 2.
PAGE 5
Note: Moving the Z-fitting higher decreases the gap between the control bar and the handle; moving it lower increases the gap. 3. Hook the spring to the adjuster link and slide the spring cover over the adjuster link. 4. Check the adjustment; refer to Checking the Control Cable. Note: The belt may slip (squeal) in wet conditions; to dry out the drive system, start the rotor and run it without a load for 30 seconds. Filling the Fuel Tank Figure 8 1.
PAGE 6
Figure 10 1. 1/2 inch (13 mm) Figure 12 Note: For best results, purchase only the quantity of gasoline that you expect to use in 30 days. Otherwise, you may add fuel stabilizer to newly purchased gasoline to keep it fresh for up to 6 months. 1. Choke lever 3. Firmly push in the primer 2 times with your thumb, holding the primer in for a second before releasing it each time (Figure 13). Starting the Engine WARNING The electrical cord can become damaged, causing a shock or fire.
PAGE 7
6. Unplug the extension cord from the power source and the machine (Model 38473 only). CAUTION If you leave the machine plugged into a power source, someone can inadvertently start the machine and injure people or damage property (Model 38473 only). Unplug the power cord whenever you are not starting the machine. For more information about operation and maintenance, go to WWW.TORO.COM/EN-US/PARTS/PAGES/ PARTSLOOKUP.ASPX. Figure 14 1.
PAGE 8
Notes: 8
PAGE 9
Notes: 9
PAGE 10
Emission Control Warranty Statement For the United States, California, and Canada *374-0299* Your Warranty Rights and Obligations The California Air Resources Board (CARB), the U.S. Environmental Protection Agency (EPA), and The Toro Company, are pleased to explain the emission control system warranty on your 2015–2016 small off-road engine/equipment. In California and the United States, new small off-road engines/equipment must be designed, built, and certified to meet stringent anti-smog standards.
PAGE 11
1. Fuel System Parts • • • • • • 2. Fuel tank, cap, and tether Carbon canister Air cleaner Intake manifold Crankcase vent and line(s) Purge line and fittings Spark plug(s) and wire(s) Magneto ignition system Catalytic Exhaust System • • • 5. Fuel line, fittings, and clamps Ignition System • • 4. Fuel pump Air Induction System • • • • 3.
PAGE 12
The Toro 2-Year GTS Starting Guarantee and The Toro Total Coverage Guarantee Power Clear Single-Stage Snowthrowers A Two-Year Full Warranty (45 Day Limited Warranty for Commercial Use) The Toro Starting Guarantee The Toro Company and its affiliate, Toro Warranty Company, pursuant to an agreement between them, jointly guarantee that your Toro GTS (Guaranteed to Start) engine, when used for residential purposes*, will start on the first or second pull for two (2) years from the date of purchase, if you pro