Operator's Manual

ManualsBrandsToro ManualsSprayersElectric Hose Reel Kit, 2015 and After Multi Pro WM Turf Sprayer

FormNo.3396-130RevA

ElectricHoseReelKit

2015andAfterMultiPro

WMTurfSprayer

ModelNo.41245—SerialNo.315000001andUp

Operator'sManual

Introduction

Readthismanualcarefullytolearnhowtooperateand

maintainyourproductproperly.Theinformationinthis

manualcanhelpyouandothersavoidinjuryandproduct

damage.AlthoughTorodesignsandproducessafeproducts,

youareresponsibleforoperatingtheproductproperlyand

safely.

YoumaycontactTorodirectlyatwww .Toro.comforproduct

safetyandoperationtrainingmaterials,accessoryinformation,

helpndingadealer,ortoregisteryourproduct.

Wheneveryouneedservice,genuineToroparts,oradditional

information,contactanAuthorizedServiceDealerorToro

CustomerServiceandhavethemodelandserialnumbersof

yourproductready.Figure1illustratesthelocationofthe

modelandserialnumbersontheproduct.

Figure1

1.Modelandserialnumberplate

ModelNo.

SerialNo.

WARNING

CALIFORNIA

Proposition65Warning

Thisproductcontainsachemicalorchemicals

knowntotheStateofCaliforniatocausecancer,

birthdefects,orreproductiveharm.

Useofthisproductmaycauseexposureto

chemicalsknowntotheStateofCalifornia

tocausecancer,birthdefects,orother

reproductiveharm.

Note:ThisproductcomplieswithallrelevantEuropean

directives.Fordetails,pleaseseetheDeclarationof

Incorporation(DOI)atthebackofthispublication.

Determinetheleftandrightsidesofthemachinefromthe

normaloperatingposition.

Important:Teon®tapeisrequiredfortheinstallation

ofthiskit.Thetapeisusedtowrapthreadsofttings

beforeassembly.Threadsshouldbewrappedstarting

atthebaseandtravelingtothetipofttingtoensurea

waterproofseal.

Important:Youwillneedanon-petroleum-based

lubricant,suchasvegetableoil,toinstallthiskit.

Safety

Improperuseormaintenancebytheoperatoror

ownercanresultininjury.Toreducethepotential

forinjury,complywiththesesafetyinstructionsand

alwayspayattentiontothesafetyalertsymbol,which

meansCaution,Warning,orDanger—personalsafety

instruction.Failuretocomplywiththeinstructionmay

resultinpersonalinjuryordeath.

Readalsothesafetyandoperationinstructionsinthevehicle

Operator'sManual.

•Donotaimthehandsprayeratanypersonoranimal.

Fluidsunderhighpressurecanpenetrateskinandcause

severeinjury,possiblyresultinginamputationordeath.

Hotliquidsandchemicalscanalsocauseburnsorinjury.

Ifanypartofthebodycomesincontactwiththespray

stream,immediatelyconsultaphysicianfamiliarwith

injecteduidinjuries.

8111LyndaleAvenueSouth

Bloomington,MN55420

Registeratwww.Toro.com.

OriginalInstructions(EN)

PrintedintheUSA

AllRightsReserved

*3396-130*A

Summary of content (12 pages)

PAGE 1
Form No. 3396-130 Rev A Electric Hose Reel Kit 2015 and After Multi Pro® WM Turf Sprayer Model No. 41245—Serial No. 315000001 and Up Operator's Manual WARNING Introduction Read this manual carefully to learn how to operate and maintain your product properly. The information in this manual can help you and others avoid injury and product damage. Although Toro designs and produces safe products, you are responsible for operating the product properly and safely. You may contact Toro directly at www.Toro.
PAGE 2
• Do not place your hand or any other part of your body in CAUTION front of the spray nozzle. Chemicals are hazardous and can cause personal injury. • Do not leave the equipment under pressure when you are not present. • Read the directions on the chemical labels before handling the chemicals and follow all manufacturer recommendations and precautions. • Do not use the hand sprayer if the hose, trigger lock, nozzle, or any other part is damaged or missing.
PAGE 3
Setup Loose Parts Use the chart below to verify that all parts have been shipped. Procedure 1 2 3 4 5 Description Qty.
PAGE 4
1 Preparing the Machine No Parts Required Procedure 1. Ensure that the machine is empty of all fluids. Note: If chemicals have been used in the machine, flush the system thoroughly with clean water; refer to your vehicle Operator's Manual for instructions. Figure 2 2. Park the machine on a flat area, set the parking brake, stop the pump, stop the engine, and remove the ignition key. 3. Disconnect the terminal of the negative battery cable from the battery. 1. Shoulder bolt 3. Flange nut (5/16 inch) 2.
PAGE 5
3. Drop the swivel plate into the hole on the hose-reel base. 3 4. On the underside of the hose-reel frame, attach the thrust washer and snap ring to the post on the swivel plate (Figure 5).
PAGE 6
4 Installing the Control Valve Parts needed for this procedure: Figure 7 1. Flange nut (3/8 inch) 3. Short bolt (3/8 inch) 2. Small washer 8. Install the large washer and spring pin to the underside of the hose-reel frame (Figure 8). 1 Control valve 1 Hose-reel supply hose 1 Gasket clamp 1 Straight, barbed fitting 1 Shut-off valve 1 Female cap 1 Fitting Procedure 1. Remove the retainer that secures the a actuator to the manifold valve for the section valve or agitation valve (Figure 9).
PAGE 7
1 2 3 Figure 12 1. Female cap 2. Shutoff valve 2 8. Disconnect the cap and coupler from the pressure-gauge port (Figure 13). g029410 Figure 10 1. End cap 3. Fitting and hose assembly 2. Retainers 4. Note the current settings on the left and right knobs. 5. Rotate the boom bypass valve cluster 180 degrees as shown in Figure 11. Figure 13 1. Gasket Figure 11 4. Coupler 2. 90-degree fitting 5. Control valve 3. Gasket clamp 6. Hose-reel supply hose 9.
PAGE 8
Note: If the Tank Cleanse Rinse Kit is installed, route the hose behind the rinse pump. Figure 15 2. Connect the free end of the long hose to the fitting on the spray gun (Figure 16). 1 2 Figure 14 1. Tank-supply hose 3 4 2. Hose-reel supply hose 14. Secure the wiring harness to the supply hose using 2 cable ties. 5 g017765 Figure 16 1. Hose 2. Hose clamp Connecting the Spray Hose Parts needed for this procedure: 1 Long hose with fitting 1 Spray gun 1 Small hose clamp 3. Barb 4.
PAGE 9
Operation 6. Set the engine to the desired speed, then engage the neutral engine-speed lock. Important: Do not use a pressure setting higher than 1034 kPa (150 psi) with the hand sprayer. WARNING Fluid under pressure can penetrate skin and cause injury. • Keep your body and hands away from nozzles that eject high-pressure fluid. • Do not aim the sprayer at any person or animal.
PAGE 10
Declaration of Incorporation Model No. 41245 Serial No. 315000001 and Up Product Description Invoice Description Electric Hose Reel Kit, Multi ELECTRIC HOSE REEL KIT Pro WM Turf Sprayer - MULTI PRO WM General Description Directive Utility Vehicle 2006/42/EC, 2004/108/EC Relevant technical documentation has been compiled as required per Part B of Annex VII of 2006/42/EC.
PAGE 11
International Distributor List Distributor: Country: Phone Number: Distributor: Phone Number: 57 1 236 4079 Colombia Japan 81 3 3252 2285 Czech Republic 420 255 704 220 420 255 704 Slovakia 220 Argentina 54 11 4 821 9999 Russia 7 495 411 61 20 Ecuador 593 4 239 6970 Finland 358 987 00733 Agrolanc Kft Balama Prima Engineering Equip. B-Ray Corporation Hungary Hong Kong Korea 36 27 539 640 852 2155 2163 82 32 551 2076 Maquiver S.A. Maruyama Mfg. Co. Inc. Mountfield a.s.
PAGE 12
Toro General Commercial Product Warranty A Two-Year Limited Warranty Conditions and Products Covered The Toro Company and its affiliate, Toro Warranty Company, pursuant to an agreement between them, jointly warrant your Toro Commercial product (“Product”) to be free from defects in materials or workmanship for two years or 1500 operational hours*, whichever occurs first. This warranty is applicable to all products with the exception of Aerators (refer to separate warranty statements for these products).