Operator's Manual

23
Checking the Engine Oil Level
Before you use the line painter, make sure that the oil
level is between the Add and the Full marks as shown on
the dipstick (Fig. 35). If the oil level is below the Add
mark, add oil. Refer to Filling the Crankcase with Oil.
1
2
3
Figure 35
1. Dipstick
2. Full
3. Add
Servicing the Air Filter
Clean the foam pre-cleaner every 25 operating hours.
Replace the paper air filter once every season or every
300 operating hours; replace it more frequently in dusty
conditions.
Important Do not operate the engine without the air
filter assembly; extreme engine damage will occur.
1. Stop the engine and wait for all moving parts to stop.
2. Disconnect the wire from the spark plug (Fig. 36).
1
Figure 36
1. Spark plug
3. Remove the screw that secures the air cleaner cover
(Fig. 37).
4. Remove the cover and clean it thoroughly (Fig. 37).
1
2
3
Figure 37
1. Screw
2. Cover
3. Paper air filter
5. Remove the paper air filter and discard it (Fig. 38).
1
2
Figure 38
1. Paper air filter 2. Foam pre-cleaner
Important Do not try to clean a paper filter.
6. Remove the foam pre-cleaner and wash it with a mild
detergent and water, then blot it dry (Fig. 37).
7. Saturate the pre-cleaner with clean engine oil, then
squeeze it (do not twist) to remove the excess oil.
8. Install the foam pre-cleaner.
9. Install the new paper air filter.
10. Install the cover and secure it with the screw.