Operator's Manual

9
Specifications
General Specifications
Type
Three wheeled, front steer, rear drive, one person ride–on turf sweeper with welded
steel frame and integral hopper for collecting debris.
Engine
Manufacturer: Kohler, Model CH1 BS, air cooled, 4 cycle
Horsepower: 18 @ 3600 RPM
Maximum Torque: 30 ft.–lb. @ 2500 RPM
Compression Ratio: 8.5. I
Displacement: 38.1 cu. in. (624 CC)
Oil Capacity w/filter: 2.1 quarts (2 liters)
Governor: Mechanical
Governor Limit: 3000 RPM
Idle Speed: 1200 RPM
Air Cleaner–High density paper element with oiled foam precleaner
Fuel Filter: 15 micron in–line filter
Battery
12 volt with 370 cold cranking amps. (CCA) at 0_ F. Type 24.
Fuel System 5 gallon (18.9 liter) tank.
Electrical
Type 24. 12 volt with 370 Cold Cranking Amps (CCA) at 0_ F. Electrical circuit is
fused at 10.0 Amps.
Traction System
Sundstrand Series 15 pump coupled to Parker/Ross Model MS 10 wheel motors.
Filtration – 25 micron suction line filter (replaceable spin on element).
Foot pedal control with cable to ramped neutraling device on hydrostatic pump with
eccentric neutral adjust.
Controls
Throttle, choke, Reel PTO Engagement handle, parking brake, hopper release
handle, and ignition switch are all hand–operated. Forward/reverse traction pedal is
foot operated.
Gauges Hour meter, hydraulic vacuum gauge, and engine oil pressure warning light.
Reel Drive
Electric clutch with brake. Automatically engages when Reel PTO Engagement
Handle lowers reels (2 heights). Sweeping pick–up with two counter–rotating finger
reels, baffles and skirts. Reels rotate at 1100 RPM, and effectively pick up light
debris on turf up to 5 mph.
Steering Manual, 14 in. soft touch, 3 position tilt steering wheel, 6 to 1 ratio.
Brakes Rear 6 in. drums with hand lever actuated to dual cables.
Tires, Wheels
Front (1)–18 x 8.5–8 in. turf tread.
Rear (2)–18 x 9.5–8 in. ribbed tread. All tires 4 ply rating, tubeless type.
Seat High–back cushion with slide adjust.
Interlock Switches
Prevents engine starting if traction pedal or Reel PTO Engagement handle are
engaged. Stops engine if operator leaves seat with either traction pedal or PTO
switch engaged.
Hopper
Stationary, 1.25 cu. yd. capacity, with deflectors and grass filling baffles. Gas strut
supported rear dumping door, with integral discharge duct and wire mesh screen
for directing dust and air away from operator.