Operator's Manual

2
All Rights Reserved
Printed in the USA
W 2007 by The Toro Company
8111 Lyndale Avenue South
Bloomington, MN 55420-1196
Contents
Introduction 2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety 3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Before Operating 3. . . . . . . . . . . . . . . . . . . . . . . . . .
While Operating 3. . . . . . . . . . . . . . . . . . . . . . . . . . .
Maintenance 3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety and Instruction Decals 4. . . . . . . . . . . . . . . . .
Specifications 7. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Specifications 7. . . . . . . . . . . . . . . . . . . . .
Setup 8. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Activating the Battery 8. . . . . . . . . . . . . . . . . . . . . .
Mount Debris Blower To Tow Vehicle 9. . . . . . . . .
Removing Debris Blower From Tow Vehicle 11. . . .
Greasing The Blower 11. . . . . . . . . . . . . . . . . . . . . . .
Before Operating 12. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking the Oil Level 12. . . . . . . . . . . . . . . . . . . . .
Fill Fuel Tank 12. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Check Tire Pressure 13. . . . . . . . . . . . . . . . . . . . . . . .
Operation 14. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Controls 14. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Starting Instructions 15. . . . . . . . . . . . . . . . . . . . . . . .
Adjusting Discharge Direction 15. . . . . . . . . . . . . . . .
Operating Tips 15. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Maintenance 16. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Greasing the Blower 16. . . . . . . . . . . . . . . . . . . . . . . .
Servicing the Air Cleaner 16. . . . . . . . . . . . . . . . . . . .
Servicing the Engine Oil 17. . . . . . . . . . . . . . . . . . . .
Adjusting The Blower Belt 18. . . . . . . . . . . . . . . . . .
Servicing the Battery 19. . . . . . . . . . . . . . . . . . . . . . .
Servicing the Spark Plugs 20. . . . . . . . . . . . . . . . . . .
Replacing the Fuel Filter 21. . . . . . . . . . . . . . . . . . . .
Draining the Fuel Tank 21. . . . . . . . . . . . . . . . . . . . . .
Troubleshooting 22. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cleaning and Storage 23. . . . . . . . . . . . . . . . . . . . . . . . . .
Evaporative Emission Control Warranty Statement 27. .
The Toro General Commercial Products Warranty 28. . .
Introduction
Read this manual carefully to learn how to operate and
maintain your product properly. The information in this
manual can help you and others avoid injury and product
damage. Although Toro designs and produces safe
products, you are responsible for operating the product
properly and safely.
Whenever you need service, genuine Toro parts, or
additional information, contact an Authorized Service
Dealer or Toro Customer Service and have the model and
serial numbers of your product ready. The two numbers are
stamped on a plate which is located on the rear of blower
housing.
Write the product model and serial numbers in the space
below:
Model No.
Serial No.
This manual identifies potential hazards and has special
safety messages that help you and others avoid personal
injury and even death. Danger, Warning, and Caution are
signal words used to identify the level of hazard. However,
regardless of the hazard, be extremely careful.
Danger signals an extreme hazard that will cause serious
injury or death if you do not follow the recommended
precautions.
Warning signals a hazard that may cause serious injury or
death if you do not follow the recommended precautions.
Caution signals a hazard that may cause minor or moderate
injury if you do not follow the recommended precautions.
This manual uses two other words to highlight information.
Important calls attention to special mechanical
information and Note: emphasizes general information
worthy of special attention.